Volkswagen - Eurovan :: 2011 - Downshifting Into 1st Gear On Steep Grades
I have a 2003 VW Eurovan that had it's transmission rebuilt in 2011. In 2012, we were going up a steep mountain road approx. 25 mph and the van downshifted into first gear. We tried everything from speeding up to pulling over and letting it cool down to turning the engine off and on. It would only upshift into the correct gear when we reached the crest of the hill and started going downhill. As I live in San Diego, there are no hills high enough to reproduce this with city driving and so it never happened again until we went back to the same place this year and at almost the exact same spot on the road. We took a trip later in the year to Oregon where we encountered many uphill grades and each time we hit a steep part and going around 20-30 mph, the van would downshift again either into first or second gear, and each time upshifting when we started going downhill.
At the end of this last trip, a new whining noise appeared and is present everyday we drive and gets louder and higher pitched the faster we go. We have taken the van numerous times to the dealership who says there are no engine codes to suggest a problem and their last assessment was the downshifting may be an overheating problem and the whining noise was definitely from the transmission indicating a bearing problem and they suggested getting the transmission rebuilt again. The transmission shop states that the transmission is fine by the fact that the fluid is in good shape, the transmission is basically "dumb" and only does what the computer tells it to and therefore it is a computer problem and the whining noise, although new, is just a normal noise that all transmissions make. Each place points me in the direction of the other but neither has solved my problem.
Volkswagen - Eurovan :: 2001 - When Turn On Ignition It Takes 20 - 30 Seconds Before Car Starts
Our check engine light came on earlier this summer. A local mechanic who supposedly specializes in German autos said there was a vapor lock leak in the fuel system. He replace our gas cap and reset the warning light. A few weeks later the light came back on. This time he replaced fuel pump and reset the warning light. This created a new problem: when you turn on the ignition it now takes 20-30 seconds before the car ignites/starts. The engine turns over but takes that long to start. If you turn the ignition on and then quickly turn if off and then on again it starts immediately.
A few weeks went by and the check engine light came on again. I took it to a new mechanic. He said the fuel pump appeared to be fine and replaced a fuel line sensor. This didn't work at all as far as I can tell.
Now the check engine light is back on and we still have the prolonged starting problem. Now that the temps are cold the starting issue does seem a little better.
Volkswagen - Eurovan :: 2002 - Engine Light On / Sputters And Feels Like Vapor Lock When Rainy
I have a 2002 VW Eurovan, 2.8L V6 Winnebago Vista 21B, 130k miles, my check engine light is on but having a hard time trying to figure out what's causing it and what direction to head without spending a fortune. It started while traveling across country two years ago, several days into the trip, after driving several hours at freeway speeds on a cool rainy day, I stopped for gas and when I turned it back on it sputtered and coughed and ran REALLY rough, I slowly moved the vehicle out of the way, about 50 ft, turned it off and when I turned it back on it was fine, except the check engine light came on. I took it into VW and they ran the test... the codes were: P0118 Coolant Temperature Sensor 1 3 Cylinder Misfires P0305, P0300, P0303 P1151 Bank 1, mixture adaptation, range 1, Lean limit not reached, static
They said it wasn't going to destroy the vehicle, to continue on my trip and I'd need to do some sleuthing to find the culprit. The light came on and off throughout the trip but didn't have the sputtering again ( although I didn't push it as hard when driving it either, kept it around 65 - 70).Got back to Montana and a local shop replaced the ignition coil. That didn't fix the check engine light, which is on continuously now (that's been 2 years with mild use of about 8k miles).
Until now, it hasn't sputtered again so I didn't really worry about it, but it happened in Oregon last week when it was again cool and rainy, I'd been driving hwy speeds for a few hours, I stopped for gas and when I restarted it sputtered, coughed and rumbled like it did 2 years ago. I turned it off for 30 secs, restarted and it was fine.In talking this over with a variety of folk, we're thinking the issue could be a fuel filter, fuel pump, coolant sensor or catalytic converter sensor... I have a fuel pressure test scheduled in a couple of weeks.
Volkswagen - Eurovan :: 1995 Auto Transmission - Small Chirp Noise When Shifts Into 4th Gear
I had a small chirp noise in my Van when it shifts into 4th gear. Took it into United transmissions for a total rebuild. First rebuild had the same noise so they did it again and it came back with the same noise.at that point they said they don't know what it is. I can find no one in this state that will rebuild the Tranny.
View 5 RepliesVolkswagen - Eurovan :: 1997 - Rapid Clicking Sound Randomly Comes From Under And To The Left Of Steering Wheel
While driving, a rapid clicking sound randomly comes from under and to the left of the steering wheel and the van concurrently has stuttered power. It still drives but is rapidly getting worse with frequency and we are on a road trip on the Oregon Coast with young kids and limited local mechanics. It seems like something as simple as a loose connection but before digging in to check electrical connections .....
View 5 RepliesFord 7.3L Power Stroke (1999-2003) :: Almost Died When Headlights Turned On?
I have a 2003 F350 SD FWD Dually With 4.10 Axle Ratio. I'm looking for some front rotors and pads and I'm looking for recommendations. I tow a 44' Goose neck racing trailer on a regular basis so I dont want autozone crap rotors that are going to warp in a few thousand miles. I was on rockauto.com, they have Wagner, Bendix, Motocraft, Powerstop, etc etc. I thought maybe those Powerstop drilled and slotted looked interesting, but I dont know much about them.
View 14 RepliesJetta - Volkswagen :: 2003 Stalled On The Highway While Driving
My '03 JETTA stalled on the hwy while I was driving...it just lost power and the battery light came on. I had the blower on and the radio, and the lights as it was nighttime...i turned the key to the off position and turned it back on and the car started without hesitation...what could have caused that to happen?... Battery is brand new and vehicle just had a tune up.
View 8 RepliesFord F-150 - 1997-2003 :: 1999 - Died While Driving - Won't Start?
My niece has a 1999 F150 with a 4.6L engine. She was driving it down the road and it died and would not start. She called her husband, he went where she was, and when he got there, it started. She drove it home, and the next day, same thing. Died going down the road, no start, let it sit overnight, cranked like a new truck. Now it has died and will not start at all. They replaced the fuel pump. Nothing. When you turn on the key, the fuel pump runs continuously. If you pour fuel in the air filter, it will start. They checked all the fuses, nothing blown. When they try to hook it up to an OBD scanner, it does not work. No codes, nothing, it won;t pick it up.
View 9 RepliesVolkswagen - Beetle :: 2003 - Lost Acceleration Suddenly When Driving Down The Freeway
I have a 2003 new beetle with a manual transmission. It has about 60K miles. I was driving down the freeway (about 60mph steady, not stop and go), and my car suddenly lost all acceleration. Pressing on the gas did not rev the engine. Otherwise, my car was on. I pulled over and put it in first and it still would not go. However, when I turned my car off and back on, it started like a charm and I was able to move and accelerate. .
I took it to the mechanic and they could not find anything wrong with it except that the battery was low. I don't think that could be the problem, could it? I'd hate to bring the car back out on the freeway, but how can I fix it if there's nothing wrong with it.
Ford 7.3L Power Stroke (1999-2003) :: Died While Driving - Won't Start Now?
i just bought my first diesel truck, a 7.3 of course. 2002 f350 4x4 crew cab, short bed. Any ways i drove it for like 2 weeks and left it at my uncles house so he can use to go to work. then 2 days later he calls me to tell me that the truck shut off while driving just like that. he tried turning it on a couple of times and it would just crank. he gave up and had it towed. I have been looking through all power strokes forums and found some solutions like changing the CPS or the IPR.
View 14 RepliesFord 7.3L Power Stroke (1999-2003) :: 2002 - Died While Driving?
So I'm on my way out of town, when the truck just doesn't feel right. I proceed to make a u turn and pull off the high way. During the course of the u turn the truck shuts off. I pop the hood and notice the oil is everywhere from the fuel bowl back. Oil is also dripping off the passenger frame rail.
There is also a nice size puddle of oil pooled under the truck. I believe that I blew the high pressure oil line that feeds the injectors. I had to get towed back home. If it is the high pressure hose, how much does the stealership normally charge?
Passat - Volkswagen :: 2003 V6 Jerks When Light Throttle Is Applied While Driving Under 2000 Rpm
I have a 2003 Passat Wagon, V6, with a little over 80,000 miles that has developed a problem that I have not been able to get fixed: after the engine has warmed up, when driving at under 2000 rpm, the car jerks when light throttle is applied. I could also describe it as a thump or shudder. There is a small blip in the tachometer when it jerks. If I give it enough gas to cause the transmission to shift up, it does not jerk, nor does it do it over 2000 rpm. It recently had it's 80,000 mile service and runs very strong and smoothly when given enough gas.
My dealer couldn't figure what was wrong, and after they consulted with VW decided that I must have put in some bad gas. The problem was to have gone away after 5 or 6 tanks of good gas. After that didn't solve the problem, I went to an independent repair shop. They told me that it couldn't be misfire because there were no codes registered. Their theory is that it is problem with the transmission, whereby with light throttle the transmission is told to shift but then slips right back down, thus the jerkiness. They couldn't offer a solution, however. What to do about it?
Stalling - Jetta - Volkswagen :: 2003 1.8T Stall Randomly When Driving Or Idling In The Driveway
I am having a problem with my car stalling randomly. It happens when I am driving and it also happened when the car was idling in the driveway. I believe it to be an electrical problem as there are no lights on the dashboard when I try to turn it over, however after a few minutes it will start and run ok. At first I thought it was the fuel pump, but now I'm not so sure. There is no pattern to when it happens either. When driving the car will start sputtering then stall. I'll let it sit for a minute or so, then it starts again. What can be causing this?
View 5 RepliesFord 7.3L Power Stroke (1999-2003) :: 2002 - Died While Driving Intermittently?
I have a 2002 f350 dually with a 7.3 and 197k. At 186k it died while driving and I had it towed home. As soon as the tow truck dropped it the truck fired right up like nothing was wrong. Then it died again 2 days later. I replaced the cps, but the fix was replacing the icp and pigtail. Now it is doing the same thing again. It died on my wife while driving yesterday, i had it towed to the dealership I work at and it started and ran for about 2 hours with no issues. I hooked up the factory IDS and had a diesel tech look at it with me. The oil pressure, injector circuit and injectors, and IPR all look good. The batteries were a little weak so i replaced both of them. I drove it home yesterday, about 10 miles, and drove it around town today. Then i tried to jump start my 96 bronco and after about 10 minutes of running it sort of hick uped then 5 minutes later it died and would not start. I let it set for 30 minutes and it started and died after about a minute.
View 2 RepliesFord 7.3L Power Stroke (1999-2003) :: Truck Died While Driving Almost Like Ran Out Of Fuel
I have a 2001 F350 7.3l diesel.
My truck died the other day while driving almost like he ran out of fuel. Well he had fuel so I checked the oil and it was dry. There was an ugly puddle between the intakes and a whole lot on the ground leaking out. Also the puddle looked blueish.
Put in more oil and got him home but I can't find the leak. The only thing I've noticed is that the intercooler on the cold side came off slightly. A year ago I had to go mess with the UCVH and when I put it back together I had lost a dang intercooler duct clamp and replaced it with a sturdy ring clamp. Well it wasn't sturdy enough.
How much would this leak if it came off for a little while and how serious of a problem would I have as a result? I don't have any check engine light and as long as he has oil he runs fine.
Since I have reconnected the intercooler and idle tested the truck I can't reproduce the leak. I don't believe that a huge amount of oil is running through that intercooler because the turbo is lubricated through another system I have read. So what gives?
Also I am getting weird dip stick reading. For a little while when I ran the truck today he was showing WAY over full on the dip and then down again a little bit below the operating range line. Also there are a lot of air bubbles on the dip stick when it comes up. Way more than I am used to seeing.
Also, I really like the idea of cleaning my engine off really good. It's a frigging mess now. What precautions can I take to clean it up good without making a huge mess. Can I just go the car wash that has a degreaser hose and drain and just spray it down like nothing or is it sensitive and finnicky when wet? Cleaning between the intakes seems almost impossible without getting the whole turbo system out of the way. Should I be thinking about that?
Ford 7.3L Power Stroke (1999-2003) :: 2002 F350 Died While Driving
I have a 2002 f350 dually with a 7.3 and 197k. At 186k it died while driving and I had it towed home. As soon as the tow truck dropped it the truck fired right up like nothing was wrong. Then it died again 2 days later. I replaced the cps, but the fix was replacing the icp and pigtail. Now it is doing the same thing again. It died on my wife while driving yesterday, i had it towed to the dealership I work at and it started and ran for about 2 hours with no issues.
I hooked up the factory IDS and had a diesel tech look at it with me. The oil pressure, injector circuit and injectors, and IPR all look good. The batteries were a little weak so i replaced both of them. I drove it home yesterday, about 10 miles, and drove it around town today. Then i tried to jump start my 96 bronco and after about 10 minutes of running it sort of hick uped then 5 minutes later it died and would not start. I let it set for 30 minutes and it started and died after about a minute.
Ford F-150 - 1997-2003 :: Truck Died While Driving - Crank But No Spark / No Fuel
My Truck : 1999 Ford F-150 Extended Cab 4x4 5.4L V8
So the other day I was driving the truck and it just dies on me. Tried starting but it just cranked and cranked. Got it pulled over to a parking lot and then tried to start and I got it to run again. Died a couple mins later uo the road and it will not start at all anymore. I got it towed to my driveway and I've started diagnosing some things.
I dropped the tank thinking it was a pump I replaced awhile back. The pump wasn't running but jumped to conclusions and took it back to the auto parts store. They bench tested and it works fine. I checked for voltage at the pump connector. NOTHING. So I'm not getting power to Fuel pump. Then I checked the fuse and relay for the fuel pump. Everything was okay.
I did some research and decided to check for spark. NO SPARK. Another thing I noticed the other day was that the odometer is displaying all dashes. So I'm really unsure on what to really troubleshoot. I am going back to the truck tomorrow to check a few other things. I'm not sure if the Theft light is blinking or not so I will check that tomorrow and get back to you.
What to check? Any other relays or fuses besides the fuel pump? What about any modules to check like PCM, GEM, etc. Or I've heard the crankshaft sensor could be an issue.
Ford 6.0L Power Stroke Diesel :: 2003 F250 Truck Just Died While Driving
I am working on an 2003 F-250 6.0l. The truck just died while driving. No restart. Plugged in my scan tool and I am not getting any High pressure oil. Is there anything other than the Hpop I should be looking at. I know it is a big job to replace the hpop so I don't want to overlook something simple.
View 14 RepliesFord 6.0L Power Stroke Diesel :: 2003 F250 - Died While Driving - Won't Turn Over?
While driving my truck to work this morning, it completely died at 65mph. The radio and all electronics are still working. Coasted to a safe place to try and restart, but it won't turn over. The glow plug light stays on. Could this be an alternator problem or something more serious? I'm waiting for a tow truck. I'll see if there are any codes when I get it home.
View 14 Replies