Ford Super Duty (1999-2016) :: Front Disc Brake Caliper Pistons Won't Go Back In
2001 F250 SD diesel. Brakes have been working fine with no pulling. They just started to squeal recently so I knew it was time for some new pads.
I'm having a problem that seems to plague me often when I try to replace disc brake pads. I can't get the twin pistons to go back in to allow room to get the new, thicker pads in.
I unscrewed the cap to the master cylinder and used a spreading tool (that came in a brake kit from Advance Auto Parts) to compress the pistons. No movement.
I put a lot of force on it. No piston movement.
I unscrewed the bleeder screw and tried again. No movement.
Ford 6.7L Power Stroke Diesel :: 2011 - Disc Brake Caliper Sticking?
Have 50,000 mile on my 2011 F350 6.7 and up until today the truck has been flawless. This is my weekend vehicle and sees very light duty hauling fishing gear to my boat (100 miles hwy) and pulling my 7x12 enclose trailer with goose decoys. On a couple of occasions pulling my 29 CC from marina to my home and back. Took truck in for oil change and tire rotation, service advisor informs me I have 2mm on rear brakes and 3mm on fronts. Not sure why rears have more wear than fronts. Schedule to have brakes done for today and now find out that front right caliper is sticky and they want to replace both front calipers. I cannot believe that a 2011 SD F350 with 50,000 miles and of that mostly highway needs brakes let a lone calipers are going bad. Service manger tried to tell me that brake fluid should be replaced every 2 years, to which I responded that I have Ford perform all scheduled maintenance. He went on to say that this is not scheduled maintenance, wtf bs is he telling me, if it is necessary then it would be scheduled maintenance. Truck gave zero indication of stuck caliper, no sound and no excessive brake dust on wheel.
View 14 RepliesGolf V R32 :: Loud Brake Squeal - Thumping Noise Up Front Above 80mph
@ 45k miles.
1) Loud brake squeal left front on very light pressure. Pads have 75% left.
2) Vibrating/thumping noise up front above 80mph. Does not sound mechanical and not felt through the wheel at all. Seems like a loose piece of trim flapping. Wheel well liners and plastic pan under car seem tight. And no, driving under 80 is not an option.
VAG quality FTW!
Toyota - Highlander :: 2004 - Front Driver Side Brake Caliper Seized?
My 2004 Toyota Highlander with 84K miles has been diagnosed with a seized front driver side brake caliper with worn brake pad (1/32). I had recall work done a few days ago at the dealership and this was discovered afterward during the "complimentary" multi-point check-up. - You know, the long laundry list of recommended work they try to sell you on. Of course the brake work is actually necessary.
Since the vehicle was just inspected 2 months ago at our local shop, my husband suggested I take it back there to verify the diagnosis and see what that mechanic would recommend. That mechanic confirmed and showed me the seized caliper/worn pad, which, by the way, was functioning well in mid January at inspection, and measured 7/32. This mechanic recommends replacing both calipers, pads, turning rotors. There was no indication of a problem with the RF caliper, but he says it's just a good idea to replace it so we would avoid having another problem in the future.
I want to ask everyone's opinion regarding replacement of just the bad caliper vs. both. Are we getting ripped off as far as the estimate and is the flush necessary? Also, is this issue typical in the first place, and what causes a brake caliper to seize? We've had several other vehicles driven many more miles than my Highlander and never experienced a seized caliper.
Toyota - Tacoma :: Squeal Noise Only When Weather Is Cold And Truck Is Coasting
The truck has 230,000 miles and has a squeal that sounds like a belt but it's not. I have put the truck in neutral coasted with the engine off and the noise is still there. The noise only happens when the weather is cold and only when the truck is coasting. Under acceleration the sound goes away.
Toyota Tacoma Prerunner 2003 (2.7)...
Lexus LS 2007+ :: Distinct Clicking Sound Coming From Passenger Front Brake Caliper Area
Every time I am pressing the brake pedal, I hear a distinct clicking sound coming from passenger front Brake Caliper Area.
I have applied brake grease (green) to the pad shim.
I have replaced the spring sets on each front caliper.
Passenger Brake Clicking Lexus LS460L - YouTube
Toyota - Highlander-hybrid :: 2010 OME Navigation System - Disc Stuck In Scan-disc Mode And Load / Eject Button Doesn't Work
Inserted updated nav disc as directed in nav disc slot, closed door. Now the disc is stuck in the scan-disc mode and the load/eject button doesn't work on it. Wondering if there is a way to force eject the disc or other way to unstick it. You can hear the disc 'whirring' briefly as if it is trying to eject, but is stuck. It does this over and over. That's the only sound; none of the other buttons are responsive.
View 1 RepliesToyota - Tacoma - Belts :: 1997 - Loud Roaring And Whistling Noises Mostly When Idle
My Tacoma makes very loud roaring and whistling noises mostly when I am idle and the brake is engaged while the clutch is depressed. Sometimes, she'll rear and balk continuously --- even more loudly --- depending on the outside temperature and her level of activity. I need to get her fixed, but live in the New York City area and am a broke graduate student terrified of getting ripped off. Do you think it's just belts? My transmission (sometimes I can feel the noise in my gear shifter)?
View 10 RepliesPrius (Gen 3) :: Rear Brake Squeal Loud When Backing
The scene: 22k miles on a 2010 Prius II. Loud rear brake squeal, worse when backing, but still present going forward at low speeds. Does not seem to go away even when warmed up. I put it off having it checked at first because a little rust on the pads is very common in my climate.
At the dealer, the tech tells me I've worn completely through the pads and scored the rotor! At 22k! On a Prius, for crying out loud! It's not my driving, either, because that's the first I've ever had anything done to rear brakes on any car before 75k. The front brakes needed no attention at all. I challenged the service tech with these points; he even took me back into the shop to show me. The caliper pistons were moving freely, for what it's worth. Ultimately he just shrugged me off.
Honda - Accord :: 2004 - Right Front Disc Brake Started Making A Squeaking Noise
My right front disc brake started making a squeaking noise at about 50,000 miles when I applied the brakes. It was on and off at first but became more frequent. It wasn't a grinding noise and it wasn't the sensors for a low pad. I changed the pads and after about 2 weeks I started getting a grinding noise when I'd apply the brakes. I checked the pads and they were fine. After a few months I replaced the pads, grinding happened again after a few weeks of wear. Within the next few months I replaced the pads again, each time trying different types. Had the rotors turned recently and again, new pads. The grinding is gone but after a few weeks the brake makes a chirping sound now when applied. They work fine in stopping the car.
View 1 RepliesToyota - Tacoma :: Brake Pedal With No Resistance In The Morning
Brake pedal goes to floor with no resistance first time I start in am. Rest of day all normal. Started when cold weather came. Fluid ok, no leaks seen.
View 3 RepliesToyota - Tacoma :: 1997 - Brake Light Will Not Turn Off
I have a 1997 toyota tacoma. The truck runs great. Last year I replaced the front calipers and breakpads. I drive the truck maybe 3,000 miles per year. The issue I have is that the brake light will not turn off. I checked the hand brake and it works fine. The switch on the handbrake is fine too. The really unusual thing is that randomly it will turn off. usually around 30-40MPH or when I have slammed on the brake. The brake fluid is fine. Is there a sensor in the rear on the rear pads that I may need to replace?
View 6 RepliesToyota - Tacoma :: 1977 - Brake Pedal Sticking Down
My brake pedal is sticking down every time I push it in. I tried replacing the spring that was in there with a stronger one and sprayed the whole unit down with an all purpose silicon lubricant. It seemed to work a little but the problem is far from solved. It seems like it is sticking somewhere further away from the pedal. Master Cylinder maybe? I selected Tacoma because it's the closest option to my truck, but it's actually a 77 pickup/hilux.
View 4 RepliesToyota - Tacoma :: Ding-Sound In 4WD Low On 2006 Taco
I get a "dinging sound" like a warning when my truck is places in Four Wheel Dive Low. I do not hear the sound in 4 WD High. The sound will not stop and it makes things rather annoying when climbing up the huge hill leading out from my property. I check the Owner's Manual and it says nothing about a dinging sound; or at least I didn't find anything.
2006 Taco, Automatic, 127,000 miles
Lexus SC430 :: Driver Side Brake Has A Loud Pitched Squeal
I replaced my brake pads and rotors and now the driver's side brake has a loud pitched squeal. It doesn't squeal all the time and if I let up on the brakes and apply them it goes away.
I think maybe one piston is hung up.
How do you free up a stuck piston in the caliper piston?
Or could there be another reason for the squeal.
I installed Callahan slotted rotors and ceramic pads on all 4-wheels.
Lexus RX 2010-15 :: Brake Make A Loud Squeal While Releasing The Pressure
When I press and hold the brake and lightly release the pressure. The brakes would make this loud squeal. This happens when the car on or off. Just found out today that if I have to stop really suddenly, it makes the same noise. I have an rx450h w 42k miles. Any thought?
View 11 RepliesLexus GS 2013+ :: Loud Squeal Coming From The Front
I recently had new front oem rotors and pads installed on my 13 GS F Sport rwd and after a few hours of driving the loud squeal coming from the front was very embarrassing. I'm ready to pull whatever hairs on my head I have left. When I'm coming to a stop I hear it. If I'm braking lightly I hear it. If I reverse I hear it. I had the same problem prior to replacing the rotors and pads and felt that it was being caused by not having my rotors resurfaced prior to installing the last set of pads. Now, I have new everything and I have the same problem. I've already spent so much on the front brakes and I can't stand having an expensive car that sounds like a cheap car.
View 14 RepliesToyota - Tacoma :: 2004 - Passenger Side Brake Light Is Not Working
Passenger side brake light is not working. Bulb is fine. Seems that the "plunger action" in the socket may be lacking. I put some WD in there.....worked for a day or so....now not working. Can I replace this socket or do I need an entire lens assembly?
View 2 RepliesToyota - Tacoma :: 1996 - While Braking Front End Vibrates?
This is a 1996 Toyota Tacoma, 2WD, 2.4L. When I apply the brakes I get a very heavy vibration in the front end, almost like a wobble. The vehicle otherwise stops fine. No noises. The vibration occurs at pretty much any speed over 20 mph. The frequency does not seem tied to the actual speed but it's hard to tell for sure. It does not do it when I apply the emergency brake only.
I replaced the front disk brake pads, with new clips and shims. There were worn down pretty far and needed replacing. Unfortunately that did not make any difference in the vibration. Rotor runout and minumum thickness were checked while changing the disk brake pads and both were within specs. I did a quick inspection of the ball joints and tie rod ends by trying to move the tire and everything seems tight enough.
I'm not very proficient on suspension issues. What else can I look for.