Ford F-150 (2004-2008) :: Intake Manifold Replacement?
Looking for any pictures or directions on replacing the intake manifold on the 2004 F150, 5.4. Got all the parts with the pulgs, and ignition coils.
View 6 RepliesBonneville :: 1995 Pontiac GM 3.8 Upper Intake Manifold Replacement
Just today,when replacing the UIM on a naturally aspirated 95 Pontiac Bonneville 3.8 with a Dorman upgraded type from my local auto parts, I ran into an issue. When following specified torquing sequences and specs , be very careful with the 1 long stud (#7), as it will split your new manifold there if you try to torque to 89 in/lbs. Took 1st back for replacement ,and the second new one started to split at the same place. Was using a brand new Craftsman in/lb torque wrench set correctly and following instructions exactly. I've seen a lot of excellent info on this UIM issue with the GM 3.8 ltr 1995-2004 years, but never this issue with the replacement ones. If I have to change this again will definitely go with the aluminum one.
View 1 RepliesMonte Carlo :: 2003 SS - Intake Manifold Gasket Replacement
I took my Monte in for the annual Missouri Safety Inspection. Note: I had no known problems with my 2003 Monte SS 117K Miles. After the inspection, which passed, I was informed of a variety of problems: Intake Manifold Gasket Replacement, Valve Cover Gasket w/Intake replacement, Thermostat w/Intake Removal, Fuel Injector O-Rings w/Intake Removal.
My question is should I have all of this done? It's not cheap..roughly 1000 bucks. I know very little about this and I don't want to just tell my mechanic to do it without some research. Are these common problems with Monte's of this age/mileage and just part of the cost of owning this car. I am the original owner and have avoiding costly repairs/maintenance..it's been a great car.
Ford F-150 - 1997-2003 :: 2001 5.4L - Intake Manifold And Gaskets Replacement
I am about to replace the intake manifold and gaskets. I know all of that process, but first question is if there is anything i should do whilst in there. Second question; what can I do with my intake to get more power? Mainly just kind of wondering before I get my parts ordered.
View 4 RepliesChevrolet - Silverado :: Check Engine Light Comes On After Intake Manifold Gaskets Replacement
I have a 1998 chevy silverado z/71 4x4. I had a water leak and had the intake manifold gaskets replaced. Ever since then, the check engine light comes on and it soots up the o2 sensors and the 4 plugs on the right bank. It may run good for a month or so and then it starts all over again.
View 1 RepliesFord Super Duty (1999-2016) :: 2005 F350 - Melted Air Intake Manifold Port - Code P0171 And P0174
Wife took truck out and turned around after going less then a mile, saying it was running very bad. We got this truck about two months ago at a state vehicle auction. It was a state used truck, 145,000 miles, 05 Ford F350, ext cab and 8' bed. Anyway at first I thought it was valve tap until research said an exhaust manifold. With a fog machine in rear exhaust pipe we confirmed it was leaking and replaced the exhaust manifold. Figured it was probably a good time to replace spark plugs too. Took truck for a ride and she still buck and farted.
Got a code machine and got P0171 and P0174. Couldn't find a vacuum leak, but your could hear the air being sucked in. went to local parts store, guys couldn't find leak, but they said truck sounded like a steam machine. today I made a homemade smoke machine and smoke came from air intake, figured the gaskets were bad. The pictures show what I saw when I took the gaskets off. The port that has melted is the same port were the exhaust manifold was leaking from. Am in deep "doo-doo". What caused this?
Toyota - Corolla :: 1993 - Cracked Exhaust Manifold
I have a 1993 Toyota Corolla 1.6L with 200K miles. It is a sweet ride, but about every 2 or 3 years, the exhaust manifold cracks. I have replaced it several times, installing new gaskets, and carefully following the torque specifications on all of the bolts, but eventually, it cracks again.
View 18 RepliesCorolla / Matrix 2009-13 :: Change Coolant In Toyota 1.8L
I am going to change the coolant in my 2009 corolla 1.8L. The service manual instructions tell me to open the "cylinder block drain cock plug" and I can't find it. The picture in the manual is not very clear, but it points to a spot on the engine just above the throttle body.
View 9 RepliesToyota - Corolla :: 2007 - Change Trans Fluid?
I just changed my corolla trans fluid for the first time. the owners manual said a drain and fill take 3 quarts of T IV trans fluid. I purchased 3qts of T IV but more than 3 qts came out so I am about 8 to 12 oz. short. All of the toyota dealers are closed to day so I can not buy any until tomorrow. can I drive it this way for one day without hurting anything or should I put some of the old trans fluid back in?
View 4 RepliesToyota - Corolla :: 2002 - Check Engine Light Came On After Oil Change
Had the oil changed today; before doing so, I saw that the check engine light had come on. Have been told by 3 professional car maintenance people that there is no connection between needing oil / oil change and check engine, that it would have been the check maintenance light.
Will take it in for diagnostic test by dealer. Also, was told by the oil change guy that he heard pinging which could mean that the car needs to have the valves adjusted, and that the check engine light is due to needing something or other with the gas tank filter which could have a leak/crack, etc.
Toyota - Corolla :: Steering Wheel Shaking After Oil Change And Tire Rotation
So I have a Toyota Corolla 2004, and 117000 miles. Just this Saturday (2 days past) I got an oil change and a tire rotation (at a Valvoline drive through service station). This morning, once I was going 50-60 miles an hour on the highway, the steering wheel began to shake (left and right, fast). The vibrations come in waves, where maintaining a constant speed, it will shake, then the shaking will smooth out, and then it will start to shake again, in ~30 second cycles.
I'm assuming that this problem has something to do with my tire rotation, since it's the first one I did in recent memory, (Thought they do this as part of where I got my care inspected?) .. What should I do?
Toyota - Corolla :: 2003 - Check Engine Code P0420 - Change The Converter
I have a 2003 Toyota Corolla, mileage app. 106,000. Check engine light first came on when driving to destination 40+ miles away (most of my driving is shorter, around-town trips). My mechanic said code is P0420 and so they reset it and said if it comes on again that I need a new cat converter. It did not come on until about 6 weeks later when I was on a longer trip again (had driven about 40-50 miles). Can you tell me if the P0420 code absolutely means that a new cat. conv. is needed or if it could possibly be a sensor or something else hopefully less costly than a new cc?
View 3 RepliesTiguan :: CEL Came On - Intake Manifold Sensor
Today I was on my way back home from a weekend trip to see family when the CEL came on. The car was running fine no problems (we had driven 200 miles). Gas mileage was good, good power, no weird noises, engine temp was fine (it was 100 degrees outside). But being how the car has 39k on it and its the most expensive thing I own; I pulled over and had autozone scan it for me. It came up as Intake Manifold Sensor. I have never worked on this car but Im going to at some point, I'll replace it myself if it isn't to hard. I am wondering if it is as simple as replacing the sensor or could there be an underlying issue like a blown intake manifold gasket (like i said the car was running fine though)?
View 6 RepliesCorolla :: Toyota Matrix XR 2010 Front Bumper Replacement
I have a Matrix XR 2010 with front bumper sporty look . I like to change the front bumper to regular bumper and the reason is that for the last two winter seasons I have broken the spoilers and basically wreck the bumper.
View 2 RepliesCorolla / Matrix 2009-13 :: How To Program Toyota Replacement Key / Fob To Start Car
I bought a brand new Toyota Corolla LE, took it for a ride, then went jogging and while jogging I lost one of the master keys. Now, I got me a replacement key/fob and I have been able to program the buttons to lock/unlock the car , however, I have not had any success programming the chip to start the, local dealer here in the Bay Area want a lot of money that I currently don't have.
View 2 RepliesToyota - Corolla :: 2003 - Expansion Valve And AC Evaporator Replacement
I have a Toyota Corolla 2003. I need to replace the expansion valve and the evaporator of the AC. I have been told I have to remove the whole dash to do that. Is that true? and if so, where I can find a video or a step by step guide in how to do that?
View 5 RepliesToyota - Corolla :: Leak And Dripping When Parked - Oil Pan Gasket Replacement
I recently had my gasket replaced and 24 hours later, there were several oil leaks in my driveway and oil dripping from my 99 Toyota Corolla every time I parked. I brought it back to the shop this am since they were no open on Saturday. My question is they stated it might just be a loose filter and/or a bad filter.
View 4 RepliesMonte Carlo :: Intake Manifold Exploding On GM V6 3.8L
Turned the key on my 2002 MC SS, V6, 3.8L, and the Intake Manifold exploded.
Intake Manifold Exploding on a GM V6, 3.8L? It sounded like a 12ga shotgun. Fortunately no one was looking into the engine compartment at the time as they likely would have been killed given the amount of shrapnel from this explosion. Note that the explosion was powerful enough to blow off the oil cap, which is screwed on with very thick threads.
The vehicle was at my mechanics at time and in his forty years he's not seen an intake manifold explode save for those residing on Top Fuel or Funny Cars.
Golf IV R32 :: Nozzle On Intake Manifold Broke
One of the nozzles on the back of my intake manifold broke off. I don't know how to better explain it. The ones the back of the manifold closest to the firewall there are several hoses that hook to the manifold. The second one from the left broke.
View 7 Replies