Clutches - Airconditioning :: 2002 Chevy Cavalier AC Clutch Not Engaging
My AC pulleys bearing froze up and broke the belt. I replaced the pulley and clutch, checked fuses and relays, all good. The clutch still wouldn't engage.I bought some AC 134A and put half a can and its still not engaging. How do I get that clutch to engage?
2002 Chevy Cavalier 2.2 Ecotec engine
Honda - Cr-v - Airconditioning :: 2002 - AC Stopped Working Suddenly / Burning Smell
I was driving my 2002 CRV with 86K miles on it, when suddenly the A/C stopped working and there was a burning smell. Immediately stopped A/C and took it to my local dealer, Honda. They say the compressor blew metal debris throughout the A/C system, destroying it completely. I am, of course, furious that a low mileage Honda in excellent condition would require this kind of repair. Should I have it done? Should I find another mechanic and get aftermarket parts?
View 12 RepliesFord Ranger / B-Series :: 1992 - A/C Compressor Did Not Have Any Clutches On It
My compressor on my 92 Ranger did not have any clutches on it. Where they went. I got a compressor off of a 94 at the pick and pull. It was charged and the compressor turned fine. Brought it home and tried to install it. My hoses in the back of mine(92) are different than the 94. I went back and got the hoses, condenser and evaporator off of the 94. Put it all together. The high pressure hose on the 94 has some sort of switch on the high pressure side. What is this switch for and how can I wire it in to the electrical system on the 92? I assume it is some sort of pressure switch that allows the system to flow. I'm getting 30 pounds on the low side and 150-200 ponds on the high side. Also, when I increase the RPM's, the compressor kicks on and off. It's not like it would or should normally but fast.
View 7 RepliesNissan - Airconditioning - Quest :: Compressor Cycles Off And On Way Too Fast When Defroster Is On
The AC compressor on my 97 Quest cycles off and on way too fast when my defroster's on. I know the AC is supposed to dehumidify the incoming air - but it shouldn't be this rapid. Is there a way to control this or shut off the AC when the defroster's on ? 97 Nissan Quest..
View 2 RepliesSaturn - Airconditioning - Astra :: 2008 - Compressor Never Budges When AC Is Enabled
My fiance's 2008 Saturn Astra no longer has AC. The compressor does nothing when AC is enabled. You can hear the engine bog slightly when the button is pressed so /SOMETHING/ is happening, but the compressor never budges. My first instinct was to check the freon so I picked up a kit to recharge the system. Pressure was 60psi on the upper and lower ports. I saw some people commenting about blower relay's and resistors. The HAV system and blower work...fine minus AC.
View 6 RepliesHonda - Cr-v :: 2002 - AC Compressor Won't Turn On
2002 Honda crv air compressor won't turn on. Fan relay was bad; fan turned on when relay bypassed but compressor still won't turn on.
View 4 RepliesCaprice :: 1996 LT1 - AC Compressor Clutch Plate Stalled
I'm using a compressor clutch kit to try and pull off the compressor clutch plate from my '96 LT1. Using the tools I got the clutch plate almost all the way off but then it stalled. I've broken every one of the remover screws trying to get it off the last bit. I'm considering picking up a 3 jaw puller to get the job done.
View 5 RepliesHonda - Clutches :: Cannot Shift Easily Between Gears On Hot Days
Clutch won't shift on a HOT day. When its hot I can't shift very easy between gears. However, the clutch is newer and so it works just fine. When its cold its sometimes tough but not as hard at all. Could it be a clutch master cylinder or slave cylinder? Do I need to bleed it?
View 1 RepliesCivic - Honda - Airconditioning :: 1997 - AC Malfunction / Blow Hot Air
I have a '97 Honda Civic w/ about 168k miles, am hoping to get at least another year or two out of it before I go looking for a used Honda Fit or something similarly budget-minded to replace it. I just ran the A/C on cold for the first time this season (I realize I was running it all winter when I defrosted the windows), and it was clearly not working, just blowing hot air. Now, the last time I had anything done with the A/C was in 2005, when I was in a minor accident and the very nice mechanic flushed it and replaced the freon (if I have that right) for no extra charge in the course of uncrumpling the front of the car for me.
Which brings up two issues:
1) I no longer have a trustworthy mechanic where I live, and have had much difficulty finding one, and
2) the car already has a salvage title so is worth about $500 max.
Now, obviously it is worth more than that to me, since it will still be cheaper to fix than get anything else, but I have the impression that A/C repair could get quite expensive, and it is enough to make me wonder if I could afford the monthly payment and insurance increase on that used Honda Fit..
Civic - Honda - Airconditioning :: 2005 AC Stops Working Intermittently
My AC stops working intermittently - I got a whole new compressor about 2 years ago, then it stopped working altogether about a month ago, they said they couldn't find any leak but filled it up w/ added dye. Now it blows cold for awhile on the highway, but will randomly blow warm air, and also blow warm air when I'm stopped at a light (Which is no good in Phoenix, AZ) I took it back in and they said they couldn't find a leak or anything wrong with it, that some hose was probably just freezing and then I would have to wait for it to thaw... but that doesn't explain why it never happened before... and it's not normal (clearly)... I just want a car that I don't have to roast in this summer!
View 3 RepliesFord Super Duty (1999-2016) :: F250 - AC Compressor Front Plate Rattling
1999 F250 SD 5.4 with 140k miles. There is a triangular plate with a bolt in the center and and what looks like a bolt in each corner of the plate.
Two of three bolts in the plate are missing and the third is loose allowing the plate to spin freely. Center bolt is tight.
Gotten to the point it's really noisy. Can the bolts be replaced in the plate or should I just go ahead and replace compressor. If bolts are replaceable what size?
Honda - Odyssey - Airconditioning :: 2007 - A/C Not Bowing Cold Air - Coolant Leak?
Mid- july I had the compressor rebuilt when the A/C suddenly started blowing warm air one week prior to a 1200 mile road trip.
Two weeks later the car wouldn't start. The battery (still under warranty) checked out as "good" was charged up and started the car fine. It needed an oil change before we headed home and the lube shop said that the coolant was low. I mentioned that I thought this was strange since I just had the compressor fixed and the guy and the quick lube just shrugged and I paid to top off the coolant. The next morning we set out towards home- 1200 more miles.
About 100 miles into the trip I noticed the A/C didn't seem to be blowing very cold. It was cool. Not cold. It was better after we stopped the car for lunch and that lasted for about 5 miles. When we stopped, our car was leaking copious amounts of fluids from both the engine and the passenger rear side of the car. By about 300 miles into the trip, the rear AC wasn't blowing at all. By 500 miles in NOTHING WAS BLOWING. Still leaking tons of fluids. Seemingly water.
We drove through the night with complaints of heat from the kids. Parked the car in the driveway. I moved the car into the garage... and I turned on the A/c to see if it was now working. The engine started to scream and smoke was rising from the hood. This didn't stop when I turned off the A/C.
The next morning, the battery was dead again. I had it towed to our mechanic. Other than the battery he could find nothing wrong. No noises. no smoke. A/C blowing AND it's blowing cold. Possible leak from the compressor (which I told him was under warranty from the guys who put it in and asked him not to touch it). They charged the battery.
I drove it to the A/C guys (A/C is blowing fine). They admit the A/C isn't as cool as one might hope. They drive it. Seems fine. Possible Coolant leak, but it's raining and they can't find the leak. They keep the car overnight. The Battery is dead the next morning. They replace the battery with a loaner. I'm desperate for my car. I pick it up and agree to bring it back in a few days to have them check the coolant levels and the battery.
NOW... Car starts, but it seems sluggish. The car revs like a formula 1 race car from 1st gear through 4th (maybe). The A/C is blowing cold (What the?? Blowing and cold?). Still leaking a lot of fluids (condensation?). Why? AND the check engine light has never gone on. What is wrong with my car???
Civic - Honda - Clutches :: Strange Clicking Sound When Pushing Down The Clutch Pedal
I started having a strange clicking sound when pushing down the clutch pedal. I have 43,000 miles on it and I have driven the clutch well(I really don't believe I already worn it up). It goes away and then it comes back. There is no problem on shifting from gear to gear, it works just fine. It is only when I push the pedal that it starts clicking like it pushing against something. The car dealership was so useless, they said I need a new clutch and that warranty does not cover it because I may have been using the clutch badly. Also do you think that they have the right to tell me it is my fault even though I have the extended warranty for 100, 000 miles.
View 6 RepliesHonda - Accord - Clutches :: 2003 - Clutch Master Cylinder Changed Six Times In 12 Months?
I have changed the clutch master cylinder on my '03 Honda Accord (6 cyl.) six times in the past 12 months. Either the o ring seal blows out or the bolts holding the plate down breaks off. I bleed the clutch of bubbles until the oil runs through also. What am I doing wrong?, I'm about to send this car packing.
View 9 RepliesHonda - Accord - Clutches :: 2000 - Rumbles Or Shudders When Releasing The Clutch After Shift Into Second Gear
I just rolled over to 90,000 miles on my 2002 Accord. Its running beautifully, however every so often the car "rumbles" or "shudders" when I'm releasing the clutch after I shift into second gear, or sometimes it'll do it when I'm facing up a hill pulling into first gear letting out the clutch. Its almost as if the clutch rapidly grabs then slips a bunch of times, similar to if it was warped. It doesn't completely slip at all to my knowledge. The car was bought new by my family and has been driven pretty carefully since (although 2 people have learned to drive stick on it, and my dad isn't the most "gentle" driver in the universe). I know that Clutch rebuilding and replacing is a big expensive job and its something I wouldn't even consider doing myself. So, when is it time to really seriously consider dropping down the serious cash to get the clutch rebuilt? To be honest, the shuddering is really annoying (it doesn't happen all the time though) but its something I could live with for a bit.
View 8 RepliesOverheating - Civic - Honda - Airconditioning - Radiators :: 1997 - Leak From Steam Venting / Overheats When AC On?
I just received this car as a freebie but it has come with an issue or two. The most pressing is a cooling issue. They gave it to me with the words, "The radiator leaks". Upon some testing this doesn't seem to be the whole picture.
1) If I fill the radiator up, leave the car parked over night, the next morning the radiator is still full. so I assume it is leaking from steam venting or from something else.
2) The car overheats very fast when the AC is on and the vehicle is stopped. Within about 10 minutes it went through every drop in the radiator.
3) When driving with the AC fan on medium speed, it can go a solid 30-45 minutes with no issue.
4) If I turn the AC fan on to high it takes a matter of minutes for it to begin to over heat.
A friend mentioned something about a weeper valve? I know very little about cars. So if there was any insight as to what it may be that would be excellent.
Honda - Pilot - Airconditioning :: 2003 - Heat Starts To Blow Out Of Upper Vents When AC Is On Automatic
Problem: About 10 minutes after driving, the heat starts to blow out of the upper vents when the a/c is on automatic. The heat comes out even if the outdoor temperature is mild (55 – 70 degrees Fahrenheit) and the cabin temperature is warm, which heats up the SUV quickly making it very uncomfortable. Turning the a/c off tends to somewhat solve the problem some of the time, however, occasionally hot air creeps through the vents even with the a/c off. The a/c often makes a gurgling sound whether it is on or off. I noticed today (2/3/12) that the back vents are not affected by the problem, so the very warm air is only coming from the front upper vents.
View 1 RepliesHonda - Accord :: Car Fell Of Jack And Now Makes Noise Only When Turn Right While Driving
After coming home at a late night in my 2005 Honda Accord, I heard noise coming from the drivers side front wheel. I've heard this noise once before after a rock got stuck up in my brakes. I pulled into a parking lot and jacked up the car and got the tire off. I couldn't see anything that would be making the noise. After going to get something from the trunk the car fell off the jack. I had a tow truck come and lift it up. We put the tire back on and he said there shouldn't be anything serious and I no longer heard the noise coming from the wheel on my way home. But after driving it the next day, I noticed when the car is turned sharply to the right while driving, it makes a scratching/screeching noise. What could have happened?
View 8 RepliesHonda - Accord :: Catalytic Converter Heat Shield Recently Fell Off
My wife drives a 2005 Honda accord and the catalytic converter heat shield recently fell off. I am wondering if it is safe to continue driving the car without the heat shield? I have read that the main function of the heat shield is to prevent fires when parking in long grass. Does it also protect the bottom of the car from starting on fire?
View 1 Replies