Ford Escape / Hybrid :: How To Clean Throttle Body
I need to pull my throttle body so I can give it a proper clean, but Haynes says that I shouldn't use a wire brush because that will damage the "special coating" on the bore and butterfly plate. It says just to use a rag and solvent.
The crud on mine looks like it will need more than a rag, so I was thinking about a toothbrush rather than a wire brush - do you reckon that'll be OK?
Ford F-150 (2004-2008) :: Way To Clean The Throttle Body?
I have a 2004 Ford F150 4x4 with 170,000 miles. its running a little rough so I thought I would clean the throttle body. do you clean it on the truck or remove it?
View 6 RepliesFord F-150 - 1997-2003 :: Started As EGR / Throttle Body Clean
I'm usually over in the EX forum but today was working on my brothers 1998 F150 - V8 4.6L. Had the EGR code P0401 and due to FTE I found the problem took the throttle body off and found it was definitely plugged. One of the bolts was really loose and came off way to easily. Didn't realize until cleaning why... Now I drilled 8 studs out of my aluminum EX heads but this one has me pondering how I'm going to clamp this thing down and center a bit..
1st pic - ports WOW - guessing this was the problem ...
2nd pic - bigger issue ...
3rd pic - the ports cleaned up ...
Camry :: 2009 - Vibrates When At Idle / How To Clean Throttle Body And IAC Valve
I have a 2009 Camry which has the well known very bad vibration at idle when in drive at a light. My Ultragauge shows the RPM are very low when it vibrates. Sometimes it drops to around 425-450 rpm when at a stop light in drive (automatic car). Then it sometimes moves up to around 625-675 rpm and that is when the vibration completely disappears and it is nice and smooth. This issue is intermittent but happens everyday.
Most people think it is due to a bad engine mount and spend money doing that and get no results.
I have done a lot of research and feel it is due to a dirty throttle body and IAC valve and want to test my theory. I will post results once I do the job. What is the easiest and most thorough way to clean both?
Prius (2001-03) :: Check Engine Light - Replace 4 Fuel Injectors And Clean Throttle Body
I brought my Prius, 128,000 miles, into the dealer with the check engine light on. Runs fine, and checked the gas cap. Toyota dealer said they need to replace 4 fuel injectors, replace oxygen sensor, and clean the throttle body. Check engine light needs to be off so I can pass emission test.
View 8 RepliesCamry :: Throttle Body Valve Was Stuck Open
About, one month ago my car shut off while driving(pretty scary at the time). I pulled of the road and attempted to start it again. Everything looked good there, but as I was making my way home from work it started to act funny. It would not acknowledge me depressing the accelerator. When I got home, I ate supper, then went to have a look.
The car would turn on, but not acknowledge me pressing the accelerator at all, It did however go up to 30 mph at a snails pace as if it was coasting down a hill. I plugged in my code reader, and it read that the Throttle Body Valve was stuck open. I took it off and tore into to it a bit. I noticed the gears inside the TB itself were corroded and the butterfly valve was locked up.
I replaced the part, and tried to turn my car on with the new TB. All the dash lights are in working order, however upon turning the ignition to crank the engine, the whole car system shuts down. No lights no nothing, besides the car door open sound. The car will remain like this regardless of the key position until I have reset the batter(take off the terminals and put them back on) to which the process repeats itself.
The code reader says no codes are stored because I obviously reset the battery. So now am at a standstill.I believe the old TB froze up, because I had to run in through 3 ft standing water during a storm, and then deployed shortly after(I'm in the service) for a few months while letting the car sit.
Honda - Accord :: 2008 - After Cleaning Throttle Body Getting Code P0507 - High Idle?
08 Accord. After replacing the starter and cleaning the throttle body I keep having a CEL and the P0507 code.
Checked for leaks around intake, vacuum lines, etc. found none.
Tried the relearn procedure and still no luck. Car idea higher than normal ( just over 1000 rpms warm). Also feels like it wants to pull even when stopped.
So I figure I have either:-damaged the throttle body somehow cleaning it- Have incorrectly implemented the re learn procedure- missed a vacuum leak ( possible but doubtful)- or something else I don't know about
Civic - Honda :: 1998 - Throttle Getting Stuck Open
We have a 98 Honda Civic that recently developed a problem with the throttle getting stuck open. With the engine off, the throttle will return to the idle position. However, with the engine is running, when the accelerator pedal is pressed, the engine revs increase, but then do not decrease when the pedal is let off. The same thing happens when the throttle is manually opened (not using the cable) with the engine running. The valve for the air intake doe not seem particularly dirty. I cleaned the spring assembly which I initially thought was the problem. The car is sitting the the driveway with both of us moderately terrified of driving it?
View 12 RepliesGolf/GTI VI :: 2010 - EPC / CEL Came On - Throttle Body?
So while driving yesterday I had a EPC and Check eng light come on and go away shortly after... maybe 1hr of drive time. Any way I took into dealer today to have them scan and they stated it was an issue with my throttle body.
Now as soon as he told me that he also said he can not do any work under warranty on my engine due to Stage 2 software and intake/down&mid pipe...... no big deal as I figured he would say something like that anyway. Should I take it apart and try to get it cleaned..... or what?
Its a 2010, with roughly 21k miles.... Had APR stage 2 for a few months now and this is the first thing that has come up.
Jetta - Volkswagen :: Check Engine Code P0106 / Clean Throttle Valve
VW Jetta SE 2.5L... Took my car to the dealer for a check engine light, the code came back P0106 which states I need my throttle valve cleaned and the dealer also said I need my brake vacuum pump replaced.. Do these go hand in hand? How should I proceed with the dealer? I have only 60,000 miles on my vehicle was there a recall on this issue? The dealer already updated the software in the technical bulletin.
View 2 RepliesF Series :: 6.4L - Low Power / P0488 EGR Throttle Plate Codes
Ok so with age we are starting to see this code more and more and I figured it was common enough to do a video on just what it is all about. It has to do with the Egr throttle plate sticking in its bore and upon the sweep the pcm does it does no return to the full open position. In the video I show you exactly why it is flagging that dtc and how to replace the egr throttle plate with a few tips.
View 2 RepliesCamry :: 2003 LE - Grease Or Oil In Throttle Body
So i recently bought a used 2003 camry le 4cyl with 72k miles on it. So it's still in good condition. Previously I had a 92 camry 4cyl which is run with throttle cable. The new generation camry's now are drive by wire or driven electronically. So I decided to check out the whole car and looked into the throttle body, the out side of the butterfly plate, and notice some thick black substance. It seems like grease or oil. I don't know if its there to lubricate the motor to run the plate or just oil.
View 8 RepliesSierra :: 91 GMC 5.7 - No Fuel From Throttle Body When Cranking
When cranking there is no fuel from the throttle body. Dropped the fuel line on both sides of the filter that was replaced last fall and have good flow before and after the filter. If I spray starting fluid down the throttle body it will fire. Switched out the throttle position sensor and idle air control valve to no avail. It used to die after warming up every so often at a stop light but would start right back up, now it just quit and wont start ???
View 1 RepliesSilverado :: Throttle Body Causes False Code?
Would a corroded throttle body cause a false code P0332 knock sensor.
View 4 RepliesCamry :: Mileage Changes After Cleaning Throttle Body
I cleaned my throttle body this afternoon.
My car started fairly easily, and I continued with running it to 4k RPM a few times, then took it for a ride. I floored it a few times, as suggested, to clear everything out.
Now, my 2004 J-VIN Camry is running around 1200 RPM, it was at about 650-675 before the cleaning. Is this normal? Do I need to d/c the battery to reset the ECU so the car can re-learn with a clean TB?
Prius (Gen 2) :: Coolant Leakage From The Throttle Body
My prius has a coolant leak, which look like it's coming from the throttle body. The stealership recommends a new throttle body. The mechanic said he has not seen coolant leak from the throttle body before. Is this the only fix to replace the throttle body?
View 8 RepliesElantra XD (2001-06) :: Gas Smell Next To Throttle Body
What Is that little hose for? I can Smell the gasoline whenever i start the car in the morning. It is cracked But i recently heard a z-zzing Under the hood. Is it an expensive hose? What about the hose clamp.. it looks weird.. is its special for that application ? I wanna replace it myself but I don't want to do it wrong and turn my car on fire.
View 4 RepliesCamry 2012+ :: Throttle Body Cleaning?
I have a 2012 Camnry I4 and want to clean the throttle body.
Is this throtte the type that I can manualy open valve by hand without damage, or does the pedal need to be pushed to open, to prevent computer or throttle timing issues?
Camry :: 04 LE 2.4 Car Start Vibrating - How To Program New Throttle Body
The rpm with the A/C on are 550 , I was told to replace Throttle body, I did, rpm continue the same,when im driving and I stop the car start vibrating, some one told me that i have to program the new throttle body , how can i do that?
View 3 Replies