Prius (2010-12) :: Clunking Noise When Turning The Steering Wheel - Replaced Intermediate Shaft 3 Times?
Our 2012 Prius with now 17,000 miles in 8 months has developed a clunking noise when turning the steering wheel, especially far to the right at low speeds.
The first time the dealer identified it as a failed intermediate shaft and replaced it under warranty. Shortly after we told them it was starting to make the noise again, but they claimed they couldn't replicate the sound and anything they heard was normal 'linkage' (whatever that is). Shortly thereafter the clunking progressed so we took it in for now the third time, and they confirmed the problem, spoke with Toyota who said we must have had a bad part, and replaced it again.
Ford F-150 (2004-2008) :: Intermediate Steering Shaft Replaced - Hard Steering
Replaced the Intermediate Steering Shaft at 114,000 miles. Symptoms felt like power steering going out but no pump noise or low fluid. Steering became hard to turn and it sometimes felt like a tie rod was letting go.
Temporary resolution was to spray the two steering shaft joints with penetrating oil (PB Blaster). That freed them up pretty well. Then I ordered Dorman part 425361 (425-361) from Rock Auto. Simple enough job. Lots of good vids on YouTube.
I don't recommend spraying the steering shaft joints as preventative maintenance. Penetrating oil will get into the needle bearings and break down the bearing grease. That will cause the joints to fail over time.
Two side benefits, the truck steering is much smoother and small road bumps and potholes are much less noticeable. Feels like it was when new.
Dodge - Durango :: 2002 - Steering Noise In Park And Move Wheel From Side To Side About An Inch
I have a 2002 Durango 2WD about 115000 miles. I have steering noise and some play. I can hear the noise when the truck is park and move the wheel from side to side about an inch. I had the upper ball joints replace, outer tie-rods and wheel bearings some time ago. Could this be the gear box. I now this trucks are notorious for ball joint problems if it says Durango in the back yeah your ball joins are bad. At the moment I am parking the truck and have it check over the weekend.
View 2 RepliesCamry :: Knock Heard From Intermediate Steering Shaft
It appears the knock I heard isn't from the suspension, its from the intermediate steering shaft. You can actually feel it in the steering wheel. The vehicle is out of warranty. I still don't understand why toyota wont fix this since its a known flaw in the design of the car.
View 9 RepliesDodge - Durango :: 2002 AWD - Clunk Noise When Put In Reverse
My 2002 durango when put in reverse makes clunk noise and I went under truck it looks like its coming from transfer case by rear shaft....
View 8 RepliesCamry :: 2009 - Steering Shaft Making Loud Noise
I have a 2009 Camry 5Speed Manual and have had a noise and loud thud coming from my steering whenever i turn the wheel when I am accelerating out of first gear when disengaging the clutch and turning the wheel. For example, if I am in a parking lot and am traveling at extremely low speeds and turning the wheel while in first gear I can hear and feel a thud in the steering wheel.
View 2 RepliesCamry :: 2006 XLE Has Steering Wheel Clunk / Shaft Making The Noise?
Not a huge deal, but my '06 XLE has a steering shaft clunk, I'm assuming that it's the collapsible shaft making the noise. I notice it, I don't dare mention it to my wife who drives the car. I'm at about 60K and I have read about the problem before, I was just wondering if there was ever a TSB on it.
View 8 RepliesDodge - Durango - Heating :: 2002 - Hot Air Coming Out Of The Vents
Ok, so, my heater works, I can feel the hot air coming out of the vents, but no matter what setting I use, I can't get the blower to kick on. The hot air just trickles out. What might be wrong, and how much, or how hard it would be to fix? The weird part is that sometimes the fan will work.
View 2 RepliesDodge - Durango :: 2002 - AC Only Blows Cool Air When Going Down Road At 25+ Mph
I have an '02 Durango, and the AC only blows cool air when going down the road at 25+ mph. I thought I'd try putting some refrigerant in, but when I hooked up the gauge on the can it buried the needle, so it's over 100 psi on the low side, and the pressure was high enough that no refrigerant would flow in. Up where the lines attach to the expansion valve, when idling the in line is HOT - like too hot to keep your hand on and the out line is about air temp. The guy at the parts store thought the expansion valve was bad. As stated, AC works okay (but not excellently) while going down the road.
View 6 RepliesPrius (2004-09) :: Front End Shakes After Having Intermediate Shaft Replacement
My Front Suspension NOW SHAKES; After Having the Prius Intermediate Shaft Replacement Recall done!!
I took my PRIUS to the dealer this past week and had the Prius Intermediate Shaft Replacement Recall done.
Golf V R32 :: 2004 - Intermediate Shaft Outer Gear Just Worn Completely Out
My 2004 r32 has 160k miles, cam positioning lite wouldn't clear-outer (small) chain intermediate shaft gear just about worn completely out. Are timing specs for cams,crank, intermediate shaft available, also torque specs? Iread the 12v chain diy thread, but I doubt they are the same.
View 1 RepliesDodge - Durango :: 2002 - Rear Passenger Air Blows Cold Only / Heat Failure
I have a 2002 Dodge Durango and the rear passenger air blows cold only - was fine last winter. Neither the passenger or the driver controls will get warm air to the rear via the overhead vents. Warm air comes out under the front seats to the rear only.
View 1 RepliesDodge - Durango :: 2002 - Hot Metal And Rubber Smell After 40 Minutes In Stop And Go Traffic
2002 Dodge Durango 6.9 R/T... I had my bearings replaced 3 weeks ago. And about 1 week later after 40 mins in stop and go traffic I started smelling this hot metal and rubber smell. Then my breaks got really tight when I pressed the paddle. Is this related to having my bearings replaced, what could be causing this to happen every time I am in the car 40 mins or more. It's happened 4 times now and the first time it started smoking. I'm really nervous to drive my truck in stop and go traffic.
View 3 RepliesFord Super Duty (1999-2016) :: 2001 F350 - Intermediate Shaft Upgrade
Looking for an aftermarket intermediate steering shaft for my 2001 f350 since the original has some play at the slip joint and u joints.
View 1 RepliesCamry :: 2003 XLE L4 - Grinding Type Noise When Turn Steering At Low To Intermediate Speeds
I have a 2003 Camry XLE L4, and there is a grinding type noise when I turn the steering wheel at low to intermediate speeds, and when I go over a bump. I can also produce the noise when the car is parked and I bounce the driver's side up and down by placing my hands on the left fender. The struts, steering rack, and CV axels are all new. Also when the car is cold, turning the steering wheel produces a squeak (a different noise) from just behind the steering wheel.
View 11 RepliesDodge - Durango :: 2000 - Driver Side Outside Latch Won't Open Door / Shifter Loose / Knuckle In Steering Wheel?
I have a nice 2000 Durango 4x4 SLT, automatic. I have some problems.
1) The drivers door outside latch will not open the door, the inside latch works fine.
2) The shifter on the transfer case is loose, it appears that the drive was left in 2wd since I have been able to use it. But it will not shift?
3) The steering wheel feels like it has a lot of play in it, also feels like a knuckle is in it when I turn it. It sometimes slips on turns at speed?
Dodge - Durango :: 2006 - Clicking Noise From Under The Hood When Driving
I have a 2006 Dodge Durango! I have noticed a clicking/knocking noise when I am driving coming from under the hood. The noise used to diminish somewhat the longer that I drove. Now the noise is getting louder and doesn't seem to lessen as my drive time increases. What this could be?
View 5 RepliesCamry :: 2002 Steering Making Noise After PS Fluid Flush?
I have a 2002 camry and I flushed my power steering fluid today using the following procedure:
- emptied the reservoir
- connected return hose to a bucket
- added new fluid (ATF dexron III - from toyota dealer)
- jacked front wheels
- turned steering wheel side to side till new fluid came out of return line (my reservoir did get empty couple times in the process so air may have went in)
- lowered the vehicle
- reconnected the return line to reservoir
- ran the engine and turned side to side couple times (did not see bubbling and fluid level did not drop)
I took the car for test drive and noticed that my steering wheel was still making noise when turning. Also, when i was turning the wheel side to side with hood open, I noticed a change in the sound. There was a sticking sensation and steam pressure release noise when I locked the wheel on either side.What could be the problem?
Ford 6.7L Power Stroke Diesel :: 2011 - Drive Shaft Making Clicking Noise?
My buddy has a 2011 250 and is having some weird issues with a clicking noise. It started out when you put the truck in gear (D or R) and touch the gas it would click. Seems to be coming from the middle to rear part of the truck. Now it clicks when he's driving. This all started after he got 35's and a leveling kit. It's taller springs in the front and added a block in the rear. It has less than 15k on it.
View 14 Replies