Jetta - Volkswagen - Transmissions :: 2002 - Won't Shift Past 3rd Gear?
I have the above referenced car with about 65k miles on it. Today I took it for a drive, switched it to tip-tronic manual and found that the car would not shift past 3rd gear. When I switched to automatic, the transmission stayed on tip-tronic (the display indicated I was on 3rd gear). I had to fully stop the car, place it on park and only then did the transmission switch to automatic.
View 1 RepliesGolf IV / Jetta IV :: Speedometer Won't Go Past 70 - 75?
My vw jetta 2.0 mk4 runs perfectly fine till i hit 70mph then it just bounces slightly between 70-75mph and stays there. Everything else on the dash seems to work fine. my rpm is working fine, odometer is working fine, it's just the speedometer that gets stuck once i go past 70mph. I can tell that i'm going faster than 70mph yet it wouldn't go past 70-75.
View 3 RepliesGolf IV / Jetta IV :: Won't Boost Past 4 Lbs?
my car into VAG COM and since then it hasn't boosted past 4 lbs. it has Revo stg 2, K04, aftermarket side mount, full exhaust and a couple other bolt ons. Before the car was spiking at around 23/24 lbs. after pressure testing the system I found that the turbo inlet pipe was lose, so I tightened it. Still no change. I tried holding the battery terminals together for 10 minutes to reset the ecu and I also tried clearing the codes through a handheld code reader. No codes even come up anyways for this. The car is a 1.8T.
View 4 RepliesGolf IV / Jetta IV :: 2001 - Won't Go Past 10mph
I have a 2001 1.8t. Was stock except for exhaust and Cai. This weekend I installed a Audi K04 turbo, Audi exhaust manifold, 3" down pipe to 3" exhaust, 3" maf, front mount intercooler, 3 bar fuel pressure regulator, high pressure fuel pump, 386cc injectors, r8 coil packs, ngk plugs. The car start but sounds like it's going to turn off and can't get it out of first gear. As soon as I put some gas it seems like it chokes and can't go past 10 MPh. I don't have it chipped could that be the reason or should I look at something else that could be causing the problem. I'm wanting to go Unitronic stage 2+ but don't wanna do that and still have the same problem.
View 1 RepliesGolf IV / Jetta IV :: 2001 2.0 Wagon Won't Rev Past 3200 RPMs
The wife's Jetta wagon has been giving us some issue. It is a 2001 2.0 AZG engine auto trans wagon. 195,000 highway miles and well serviced and taken care of.
Here is the symptom : Engine will NOT rev over 3200. It will hit 3200 and stop dead. This is the case either in gear and driving or just sitting in Neutral. The engine seems to take a bit longer to start but does every time. The car seems to run great other then the 3200 rpm ceiling.
Wife has been driving it around like this for a while and I have let the codes accumulate. Here is the codes it gave me.
16727-cam position sensor- I just replaced the CPS with no improvement, issue is still there and code still pops up. I was told this code comes on when the car does not fire on the first rotation anyhow so it could be something else.
16804-cat o2 bank 1
16990-ICM issue
Cleared the codes and restarted the car. 16727 comes on immediately but other codes take a while to come on again.
I am leaning towards maybe an electrical issue? Bad ground, alternator output or something. Any tips on places of ground, connectors etc to clean and check? Also one or two guys keep mentioning coolant temp sensor and crank position sensor...but wouldn't those toss a code too?
I also pondered a plugged cat but I dunno, have had that before and you can usually tell right away...the car runs great until it hits 3200 and it is like a governor kicks in and she stops dead at 3200.
Golf IV / Jetta IV :: 2001 / 1.8t - When Accelerate Boost Won't Go Past Zero And Stutters
Okay I have a 2001 Vw Jetta 1.8t Wolfsberg.
I have done a few mods:
- Oil catch can
- Boost gauge
- New turbo (5000 miles old)
- Brake booster mod
- PCV system fixed and some hose deletes (that make the intake manifold have one line off of it rather than two)
- Timing belt/ pulleys
- Accessory belt / pulley
- A few other things but nothing to cause this
The car will do this randomly. And I mean once every two weeks of that. I will go to accelerate and the boost gauge says the "boost" is at zero and no matter how much I give it gas, it won't go past zero and stutters. But it stops almost as fast as it starts. I don't get it...
My catch can has 3/4" line to about 1/2" or so, that meets the oil catch can. (Ebay with the blue hose.) I have new plugs, all new (dealership recommended) lubes, all kinds of new small odds and ends. But it's never done this before. (3rd time now in a month..)
Golf IV / Jetta IV :: 2001 - No Power And Won't Go Past 3000 RPM At 20% Throttle
I made an earlier thread about minor low speed crash and airbag deployment that has sense been fixed.
The engine 2.0 (AZG) will rev to 3000 (3200 sometimes) RPM and stop. This is only if you give it about 20% / 25% throttle. If you give it full throttle it spits and sputters. When I had the airbags installed. The codes were read it and also came up for cam sensor and o2 changed that and now the codes are gone. No CEL and it is exact same issues still. I can't tell if ECU is doing it but it feels like it's not getting enough gas or air since full pedal makes it stall.
Ford 6.0L Power Stroke Diesel :: Oil Temp Won't Go Past 140
This is not on my truck. This is on my buddies 04 we just did the egr delete and oil cooler and a bunch of other stuff to.
Coolant temp doesn't go past 170 which I assume a new thermostat will fix this issue no problem.
but, the oil temp never goes past 140 no matter what driving for an hour at 70 and it doesn't change.
Bad sensor? Or would replacing the thermostat bring the oil temp up to where it should be?
Golf IV / Jetta IV :: TDI Has Slow Acceleration Especially When Going Up A Steep Hill
My TDI has slow acceleration, just curious if that was common. How do u check turbo. I can still hear it. its now very loud though. Its especially slow when going up a steep hill. anyway to make that faster???
View 24 RepliesGolf IV / Jetta IV :: Smoke Coming Out Of Vents When Accelerated To Go Up A Hill
I was driving home today when I accelerated to go up a hill and started smelling something burning, pulled over and noticed my flex pipe was completely blown apart and the heat shield behind it smoking. I pulled over and got some water on it and it stopped but after I started driving again the smoke got even worse. This time it was something different than the first time. Could it be the heater core going or the foam inside the hvac system burning?
View 4 RepliesGolf IV / Jetta IV :: Chokes The Power Past 3500 RPMs And Continue Running Rough
I own a 2001 Jetta GLX 12v VR6, lately the car has not been running well. It chokes the power past 3500 rpm's and will continue running poorly and sound sort of like a Subaru boxer engine. Sometimes it corrects itself and runs okay but goes back and forth.
I ran the codes on VAG COM:
6 faults found:
17551 - Load calculation cross check
P1143 - 35 - 10 upper limit exceeded - intermittent
16712 - Knock Sensor 1 (g61)
P0328 - 35 - 10 Signal too high - intermittent
[Code] .....
I ran VAG COM a couple of days before these codes came up and I had a different code dealing with air/fuel mixture, something about fuel running to rich. I'm stumped.
Ford 6.7L Power Stroke Diesel :: Turbo Shuddering While Lugging Up The Hill At Low Rpm In 6th Gear
Just bought my 2013 Platinum 350 DRW 2 weeks ago. 9,000 miles on it. I was cruising along yesterday at around 45 mph in 6th gear going up a slight incline. Truck was fairly low rpm don't remember what exactly. As I'm going up this hill it begins to shudder quite a bit almost seemed like the turbo shuddering while lugging up the hill at a low rpm in 6th. I stepped into the throttle to get it to downshift into 5th and it stopped. I never experienced anything remotely like this in my 2011 6.7.
View 6 RepliesFord 6.7L Power Stroke Diesel :: Antifreeze Spray On Windshield While Pulling And Going Up A Hill
2011 ford f350, 200,000 miles. I was getting an antifreeze spray on the windshield while pulling and going up a hill. It was from exhaust pressure going into the coolant system. It was building over 16 psi and blowing out the degas bottle.
View 14 RepliesFord 6.7L Power Stroke Diesel :: Making Grinding Noise While Turning On Hill
a few times when making a tight turn on hilly terrain or a hill on a road, I've noticed a grinding sound in the front of the truck and a vibration in the steering wheel. I've so far chalked this up to the hill assist feature, but today I was on relatively flat ground in a parking lot with a dip in it. While crossing the dip in a tight turn, I noticed the same thing again.
I've checked the tires/wheel wells and there is no rubbing, etc.
Ford 6.7L Power Stroke Diesel :: Turbo Noise In Tow / Haul While Descending A Hill
In addition to significantly louder noise from the Turbo on start-up, we've started to hear a pretty concerning noise while descending a hill in Tow-Haul. Not sure that the T/H has anything to do with it other than getting the engine in a RPM range that causes the noise. We've taken it in and tech says "That's just normal noise"... What ever that is.
Here is a link to an example : Tow haul making a lot of noise in my F350 diesel. Pulling a very heavy horse trailer. - YouTube
Best next steps for a 64,000 mile 2012?
Ford 6.7L Power Stroke Diesel :: Parked On Hill And Truck Started Sliding Down
Today I visited a buddy who lives on a pretty steep hill. I always set my E-brake while in Neutral to make sure it's holding the truck before sliding it into park. So I got out and unloaded a few things and was in his garage. I heard a skidding sound outside, I was about 40 feet away from it when I looked out my truck was skidding down the hill!
I ran out and to the drivers door, opened it and pressed on the brakes with left hand right when it hit the bottom of the hill and it barely stopped from hitting the blue car parked on bottom of the hill. Next time if I stop on this hill I'll make sure it''s nose up hill and make sure I have 4X4 engaged to have all wheels locked up. I know this probably happened because the lack of weight on the rear wheels but this was a pretty crazy scare with only 7800 miles on her!
You can see the skid marks from my rear wheels, my friend lives in the middle of the block.
Ford 6.0L Power Stroke Diesel :: Cooling System / Temp Gauge Started To Rise Past Normal Before Fan Comes On
I have a 2007 6.0 that this has happened to twice now. It's fine around town but I never hear the can come on. Friday when on the interstate my my temp gauge started to rise past normal operating temperature before fan came on. Is this normal? After the fan came on it stayed at normal temp for the rest of trip....
View 5 RepliesDiesel - Ford - F350 :: 1997 - Grinding Sound Coming From Turbo When Pulling Up A Long Hill
I have a '97 F-350 with a 7.3L Powerstroke Turbo Diesel, I frequently haul a 27ft bumper tow trailer weighing upwards of 6,000 lbs, which by the way it tows beautifully, but if i am pulling up a long hill or have been on the pedal for a while and let off, then there is a grinding sound that sounds like it is coming from the turbo. My dad and i think it may be some sort of exhaust overflow valve from the quick decrease in rpm or maybe an overspeed on the turbo. No noticeable decrease in power.
View 2 RepliesFord 6.7L Power Stroke Diesel :: Shudder When Engine Lugged Down To 1000 - 1100 RPMs On A Hill
I purchased my 2013 F350 PSD July of 2014 and immediately noticed "the shudder" when the engine was lugged down to 1000-1100 rpms on a hill. Sounding like somewhere around the turbo belching air too. At first I was startled but learned to manually downshift to higher rpms and it will stop. Once or twice I tried accelerating out of it and it shuddered as bad as the poster who said it made the steering shudder too.
My truck has 16,000 miles and I never let the rpms drop now. So I figure I have a real problem I'm not imaging. What should I tell my dealer is the TSB or remedy ?