Trans Sport :: 1993 - Oil Pressure Sending Unit / Best Way To Access It
1993 TransSport 3.8: Where the heck is the oil pressure sending unit, and what is the best way to access it? What size of OPSU socket does it take; 1", 1 & 1/16", or 1 & 3/16". Do I need the 3/8" or 1/2" drive; extra deep or other wise? The van has a gauge on the dash.
View 6 RepliesTrans Sport :: 1993 - Windshield Washer Tank Goes Empty Without Any Use
"93 TS. I'm coming again with this mystery: I fill the windshield washer tank full.....and without any known reason, after a long trip...without any use of the washer...the tank goes empty. I've tested everything: disconnect the pumps electric supply, testing the tank for leaks, testing the pump seals for leaks.....all with flying colours. I just know that for no reason (that I can imagine) ...the tank goes empty.
I have theorized that vacuum created by speed at the rear of the vehicle would suck fluid from the rear nozzle !!! ...but have not verified that theory by pinching the rear feed tube....I should try.
Trans Sport :: 1993 - Transmission Fluid Leakage / Hose Broken?
Tranny fluid spews out pretty good underneath. Is it likely a broken hose? Where do I start?
View 3 RepliesTrans Sport :: 1993 - Noisy When Starting Out From Stop / Late Shifting To 2nd Gear
1993 Transport 3.8 L
Starting out from stop it seemed to get noisy and was very late shifting to 2nd. Slowed down and tried again; this time it did not want to shift to 2nd at all. Brought it home slowly.
Trans fluid was right up. I did another road test, running it manually through the gears so I could easily hear and feels the shifting. 1-2-D-OD perfect; did this twice of thrice. Starting out from stop on the highway a couple times, it shifted up perfectly. I did some kick-downs and manual shifting; everything is working fine.
Could this have been a linkage problem? Could running it manually through all the gears smarted up the linkage or something? Could it be related to the 'modulator valve'?
Trans Sport :: 1996 Model With 3.4 Engine - Horn Fuse Keep Blowing
Looking for a wiring diagram for a 96 model with 3.4 engine? The horn fuse keeps blowing and I don't know what else is on that circuit to check. The horn works when the fuse is replaced but the fuse blows at some time afterwards.
View 5 RepliesTrans Sport :: 3t40 - Trans Slips When In Reverse Under Load?
If I press the gas a little hard in drive, my tires squeal but if I'm in reverse I can feel a slipping in the trans. If I try to back a trailer up an inclined driveway, it won't go, the trans slips. I have no crud in the pan. I've replaced the reverse boost valve. I installed a Trans-Go kit which is suppose to eliminate the reverse slip but it hasn't worked. Everything else works just fine and my fluid is red. I have engine braking in 2nd and 1st. The van backs up fine, it just does this in reverse under load.
View 2 RepliesS-10 :: 2000 ZR2 - Smoke Blowing Out Rear At Highway Speed / Smells Like Trans Fluid
It's a '00 zr2, usually after 15-20mins driving I see smoke blowing out rear at highway speed. If I'm driving slow same results with smoke just rolls out from hood. Smells like trans fluid although doesn't seem like the level is any lower yet.... Guessing gasket when under pressure, I would guess passenger side hitting manifold but I haven't seen obvious leaks don't know where to start.
View 2 RepliesTrans Sport :: ELC Exhausts Air When Key Is Off?
My Haynes manual indicates that the ELC exhausts air when the key is off. Is it intended to exhaust all air from the shocks every time I stop? It doesn't make sense to lower the vehicle every time I stop for fuel etc. With over 200k miles on this can it's amazing that the compressor still works.
View 9 RepliesTrans Sport :: 92 TS 3.8L - Car Is Overheating / Fan Won't Come On
I am working on my daughter's TS, it has been overheating. Water pump is fine and the thermostat is working fine also. I did notice that the temp gauge on the dash isn't. I have noticed that the fan isn't coming on either. I don't have a book on this car or a owners manual. So I am unsure of which fuses to check. I did try turning on the AC to MAX to see if that would start a fan, and that didn't work either.
View 13 RepliesTrans Sport :: 1994 - Oil Puddle Underneath The Car
I replaced my '94 TS intake plenum and upper and lower intake gaskets last year, and as part of the procedure I replaced the badly-degraded rubber gaskets that go at both ends of the manifold (at both ends of the "V", one under the throttle body, one under the PCV valve or so).
A little more than one month ago I realized the oil puddle underneath the car contained -besides power steering fluid from a known leak- motor oil. When I investigated the origin of the leak, I discovered the <> rubber gaskets have disintegrated AGAIN.
I don't see how this gaskets could be installed incorrectly, so I have to conclude the gaskets that came with the kit I used (Felpro?) did not withstand the oil as they should. Either way, I need to replace those <> pieces of rubber again
Now: since I don't want to be doing the same thing every 5 k miles, any good brand for these gaskets? Is there a material (neoprene?) that would last longer in contact with the oil?
Trans Sport :: 95 TS 3.8L Misfire When Reverse Is Applied
My 95 TS 3.8L is misfiring on #4cyl ONLY when reverse is applied. When car is in reverse with parking brake applied, consistently misfires on #4. In drive with brake applied and engine load no miss. Neutral no miss.
Car drive ability is great in drive no misfires. 100% misfires on #4 only when in reverse. Is there any vacuum change or assist utilized with this trans? Possibly vacuum leak? I do not have a vacuum gauge. I changed to a different plug wire and same problem. New plugs installed. Have not swapped coils yet.
I am not familiar with this trans, other than the vacuum servo for upshifting I replaced when it was sucking up trans fluid like my old Powerglide in the OLD days.
Trans Sport :: No More Front Ventilation When Engine Is Hot
These super-hot days our TS had started to develop a very strange problem:
- when you first start the engine the A/C works normally and cold air blows from the front vents on A/C or MAX as usual
- if we shut-down the engine and try to engage A/C or MAX again the cold air would only come-out through the top (windshield) and low vents - no more front ventilation
- all solenoids appear to be working (moving)
Trans Sport :: CEL Started Come On Then Shut Off - EGR Fault
Just recently the CEL started acting...first, would come ON then after some time would shut off....but now it is ON and stable. I was almost sure it had to do with EGR....checked codes and indeed, 55 , large EGR port failure and, accordingly, 56, QUAD driver faulty voltage...obviously because of large EGR port solenoid control. I have not verified the EGR coils yet....will come back later as I'm going out for 2 days.... This is a rather new EGR valve...6 or 7 year old.....and in fact, no more than 25000 miles...probably less...
View 8 RepliesTrans Sport :: 1995 TS 3.8 - Slow Cranking When Hot
Our 95 TS 3.8 runs hot. I dislike the 195 Thermostat, but winter is coming. Temps can soar to 230 on gauge, with no air.(Now I remember why I had a 180degree thermostat).
I recently replaced a rebuilt delco starter that was about a year old.(faulty solenoid). I cannot recall if the Slow crank problem was there prior. When 230 degrees, intermittently I get a slow crank with dimming of dashboard lights, but bright headlights.
1. I know that the temps are supposed to swing a lot with this vehicle, but 75 degree days, 230 degrees when in heavy traffic is pushing it.(gauge). Is this normal for 195 thermostat?
2. Possible bad windings on new rebuilt starter? Armature drawing excessive amps when hot? Battery cables look okay, but original.
3. Considering a NEW starter and a heat reflector wrap for starter. New battery cables-thicker cable if possible(used welding cable for my old 421S.D.
Trans Sport :: 1992 / 3.1L Started Quitting While Driving
My 92 transport 3.1L had started quitting on me while driving. After sitting for about 15mins I could get it started and then continue on driving. Now its doing it more and I can't take the chance of going anywhere in it.
Got a CEL so I flashed codes 34, and 45. Where to start troubleshooting with what these codes are saying that I should do?
Trans Sport :: 1994 TP 3.8 - Overheating In 2 Minutes From Cold
I've replaced the drain plug, filled up the radiator with proper coolant/antifreeze, turned on the engine then closed the cap to see the needle going fast to near the red mark. I turned off the engine and touched the cap with my finger but it was cold so I did the same with a hose, not hot.
Well, it seems the problem was not all circuit was filled. I did add more after a while running and now it is working normally (knock wood).
Trans Sport :: 3.1L V6 - Misfires / Hesitation And Lack Of Power When Hot
Here is one of the nicest-running van we ever had with a 3.1L V6 TBI Chevrolet engine that always ran too good to be true.
Few days ago it developed a misfire condition that is very pronounced when the engine is hot/at operating temperature - under load it hesitates like it's running in 4 cylinders out of 6. When cold it starts right away and runs good & smooth.
Now the van can't go anywhere - it misfires so severely that the engine stalls and dies at idle.
What we tried so far, to no effect, was:
- changing the spark plugs & wires
- replace the distributor cap & rotor
- replaced the EGR valve
- replaced the IAC valve
- replaced the MAP sensor
We had a lot of 3.1L Chevy TBI engines and none ran so smooth like this one and, all of a sudden, none ran that bad in such a short time...
Trans Sport :: Slow Transmission Response Before First Engagement
From time to time, the first time the car is started in a day, the transmission (4T60E, 1993) may take several ............ seconds before first engagement, either in forward or reverse. Fluid level OK, color OK, filter changed 2/3 years ago. This began just a few months ago. After that, everything will work flawlessly for all the day , no problem at all, all shifts OK, all subsequent starts OK.
View 4 RepliesTrans Sport :: 1995 APV 3.8 - Vibrations Coming From The Puller Fan
I have a 95 Lumina APV 3.8 and have vibration coming from the puller fan (passenger side front of radiator). Inspection shows fan and motor good, the rubber mounting grommets are hard as nails.
Is there a secret source for these parts?