Nissan - Xterra :: 2001 - Clogged Vapor Canister Vent Valve / Replacement?
My 2001 6cyl 4x4 Xterra is a clogged gas tank vent solenoid, or as it is called now a "Vapor Canister Vent Valve". For the last 2 or 3 years, very infrequently, the vehicle turns completely off while decelerating (sometimes at very fast speeds so I have learned to be calm and put the car in N and turn the key and keep going with the flow so to speak). It also, either during a stop in idle or accelerating very slowly and steadily, makes popping sounds directly under the left back seat--which is where the gas tank is located. It sounds like the tank (or a metal can if you will) is being sucked in until it gives making the popping/banging sound against the car (underneath).
The other issue this problem seems to be linked to is the engine light coming on when the tank pops. I have had that diagnosed too, and it just reads "engine knock sensor". My previous wonderful mechanic, who moved about 30 states away, is no longer available but he did tell me it sounds like a blocked or clogged gas tank vent solenoid. He also said it's not a big problem per se, but at some point I should probably replace it. Sometimes there are 6 months that go by with no popping, stalling, or engine light coming on. So maybe 'bad gasoline' also plays into this issue?? I did an internet search recently and found a replacement part called a vapor canister vent valve. My question is how easy or hard is this thing to replace? Can it simply be 'blown out' with an air hose, or otherwise 'cleaned' instead of replacing it. The only thing scarier for me to fix than home electrical wires would be anything dealing with GAS.
Suburu - Forester :: Leak / Hole In Exhaust - Car Loud During Acceleration
I have a 2000 Suburu Forester the has a hole in the exhaust. I noticed today, the car became very loud during acceleration.
I plan on getting a new car in the next few months, but I was wondering if I could temporarily fix this problem with a sealant or something like that for the time being?? I included a picture of the leak.
Toyota - Corolla :: 1997 - Gas Leaking Out Of Vapor Canister
The fuel filler vent line rotted off so I had the gas tank and fuel pump replaced in September. Drove the car for 2 months without a problem until last week.The car lost power then stalled. I smelled gas and found that there was a large amount of gas pouring out of the bottom of the vapor canister.I bought a new one (very expensive for a plastic can) and put it on. Drove the car a couple days and then it happened again. Someone told me not to over fill the tank but I never did. In fact, this doesn't happen right after I get gas. Its a couple days after I get gas that it happens. I had two different auto mechanics look at it and neither one of them could figure it out.
View 3 RepliesFord - Excursion :: 2011 - Excessive Vapor Smell From Charcoal Canister
I have a 2001 Ford Excursion 6.8L V10. It runs like a champ, gets really good mileage for what it is, but there a strong fuel vapor smell coming from the charcoal vapor canister under the hood. You can smell it outside the truck and the smell gets pulled in through the vents - have to use Max AC recirc.
After checking and testing, I can confirm that the fuel vapor smell is coming from the charcoal canister and not anywhere else on the engine. The smell gets worse as the tank drains: Full Tank - Almost No Smell; Half Tank - Strong Smell; 1/4 Tank - Very Strong Smell.
Here is all that we have tried.-Replaced Fuel Cap (Genuine Ford)-Visually inspected the Evap Lines - Look Good-Visually inspected Fuel Line and Fuel Filter - Look Good-Checked the Fuel System for Leaks - None-Pressure Tested the Fuel System - No Leaks-Ran Multiple Smoke Tests on Evap System - No Leaks-Checked the Computer for Codes - No Codes-Replaced the Charcoal Vapor Canister (Genuine Ford)
We are totally stumped. I searched all the forums and can find issues with plugs, fuel injector o-rings, and leaks, but this has all be checked.
Dodge - Caravan - Gas-tanks - Gasoline :: 2001 - Code P0455 / Vapor Canister Damaged?
I keep getting this code even after fixing hoses with leaks. I am guilty of over filling my gas tank all the time can this have damaged the vapor canister on my 2001 dodge caravan....
View 7 RepliesFord Fuel System :: Reconnecting Fuel Vapor Canister Lines
I am done with this swap (I hope) changed out the 302 in my 81 van for a 351. The only smog spaghetti I am keeping is the fuel vapor canister but I am unsure what the #1 line in the photo is for I have the manual but doesn't state what it does my research suggests its a fuel vapor return line from the carb bowl back to the canister ...... I now have an edlebrock carb obviously w/o this port so my question is
#1 where would you reconnect this "whatever it is" line on carb or manifold
#2 I am going to install that #3 fitting in photo on the edlebrock manifold at the same location & extend #2 hose to it. I am thinking that's ok...
Subaru - Forester :: 2002 - Turns Off While Driving After Battery Replacement?
My Forester was dead one morning and when I went to jump it off my pick-up in a hurry I did the age old palm to forehead and didn't pay close attention to the posts on my pick-up battery. Crossed the posts.So I began working through the common known issues.Replaced the main fuse. Didn't Start.Replaced the battery. Started... Car shut off while driving. Did not sputter out, simply cut out like turning the key off.Started right back up.Positive battery cable was loose. Replaced it.Grounds are good.Alternator output is good.So here are some more details on the car shutting off.
This last time as I was coming home from the store and the car shut off on the main road through town. I had enough momentum to get off to the side of the road. I tried to start it and it would turn over. Normal turn over sound but the car wouldn't start. I took a minute to check other electrical things in the car with key in the "on" position. Radio worked. Dome/interior lights worked. But then I noticed something strange. None of the dash lights came on (Car is not started but key is in "on" position). The windows did not work either.It started after about 5 minutes time and I made it home, forgot to roll the windows back up. Turned key to "on" again and couldn't roll the windows up. Got out of the car and came back after about 5 minutes, turned key to "on" and the dash lights came on the windows rolled up.
Elantra HD (2006-10) :: 2007 Canister Purge Valve Replacement
I recently got a check engine light. I went and got it checked, the person said its the canister purge valve that needs to be replaced. Where it is located and the difficulty replacing it. The part is cheap and I want to replace it this weekend. 2007 elantra
View 2 RepliesFord Super Duty (1999-2016) :: Hard To Fill Up At The Pump After Canister Replacement
My 06 f250 with the 5.4 has a hard time being filled at the pump. So I followed the tsb and replaced the carbon canister, filter box and solenoid with the kit from my local ford dealer. Before it was impossible to get fuel in. Now it is way better but I have to fill it up with the gas nozzle upside down in order to fill at full speed. I have blown out the vent with compressed air.
View 6 RepliesMazda - Miata :: 2002 Stalls Out On The Highway / Vapor Lock In Gas Tank
My Miata stalls out on the highway but not on residential streets. If I open the gas tank ,it starts up again. This has happened with a full tank, 1/2 tank and 1/4 tank. How can I fix this?
View 9 RepliesVolkswagen - Eurovan :: 2002 - Engine Light On / Sputters And Feels Like Vapor Lock When Rainy
I have a 2002 VW Eurovan, 2.8L V6 Winnebago Vista 21B, 130k miles, my check engine light is on but having a hard time trying to figure out what's causing it and what direction to head without spending a fortune. It started while traveling across country two years ago, several days into the trip, after driving several hours at freeway speeds on a cool rainy day, I stopped for gas and when I turned it back on it sputtered and coughed and ran REALLY rough, I slowly moved the vehicle out of the way, about 50 ft, turned it off and when I turned it back on it was fine, except the check engine light came on. I took it into VW and they ran the test... the codes were: P0118 Coolant Temperature Sensor 1 3 Cylinder Misfires P0305, P0300, P0303 P1151 Bank 1, mixture adaptation, range 1, Lean limit not reached, static
They said it wasn't going to destroy the vehicle, to continue on my trip and I'd need to do some sleuthing to find the culprit. The light came on and off throughout the trip but didn't have the sputtering again ( although I didn't push it as hard when driving it either, kept it around 65 - 70).Got back to Montana and a local shop replaced the ignition coil. That didn't fix the check engine light, which is on continuously now (that's been 2 years with mild use of about 8k miles).
Until now, it hasn't sputtered again so I didn't really worry about it, but it happened in Oregon last week when it was again cool and rainy, I'd been driving hwy speeds for a few hours, I stopped for gas and when I restarted it sputtered, coughed and rumbled like it did 2 years ago. I turned it off for 30 secs, restarted and it was fine.In talking this over with a variety of folk, we're thinking the issue could be a fuel filter, fuel pump, coolant sensor or catalytic converter sensor... I have a fuel pressure test scheduled in a couple of weeks.
Subaru - Forester :: 2007 - Head Gasket Replacement
I have a 2007 Subaru Forester X Sport Model. I just passed 86,000 miles - much of that open road driving. My head gaskets need to be replaced. This seems somewhat early. I recently switched from using regular motor oil to a synthetic blend that the dealership suggested. Is there any history suggesting that switching lubricants might cause the head gaskets to deteriorate?
View 10 RepliesSubaru - Forester :: 2003 - Leaking Struts / Replacement?
The other day my 2003 Subaru Forester was getting its oil changed and when it was done the mechanic informed me that my struts were leaking and needed to be replaced. He didn't seem to think it was urgent or anything. He mentioned something about roll overs and the wearing of the tires, but I'm not entirely sure what this means for the car. It has 140K on it, and I drive it a lot on the high way. I'm also planning to go on a trip in Mid July that's about a thousand mile drive. So, how soon should this be done? What do leaking struts mean for a car?
View 14 RepliesAvalon 2005-12 :: CEL Error Code P0440 Error Code / Charcoal Canister Replacement
So of course it has to happen 3 weeks after my warranty expires. My CEL comes on and I have it read and the result is P0440. I find out that my wife has a habit of topping off the gas tank and so I am thinking that she has probably ruined the charcoal canister. It is something easy to replace?
I have an 06 limited edition... Yes, she will not be topping off any gas tank anymore.
Subaru - Forester :: 2003 - Hesitating When Shift And Accelerate / Clutch Replacement?
My car is hesitating when I shift and accelerate, and revving up the tach after I shift into 5th but the speed doesn't match.Also, in order to start the car I have to press the clutch practically all the way to the floor.
It has 53,000 miles on it. I took it to the dealer, and they said I need the clutch and possibly flywheel replaced.
This seems low mileage to me. I have driven a stick for over 31 years. My previous car was a Honda CRXsi and it was over 110,000 miles before I needed a new clutch.
Is a clutch replacement this early normal for this car? Or is it me? I don't think I ride the clutch.
Subaru - Forester :: 2005 - Excessive Oil Burn After Replacement Of AVCS Solenoid
I have a '05 Forester XT with 135,000 miles, I purchased the car new and have always performed regular maintenance and oil changes. The car is my baby.On a recent freeway drive I heard a "pop" followed what sounded like a shredding accessory belt. This went on for several miles with diminishing power. There was zero smoke from the exhaust. I managed to coax it into the nearest Subaru dealership. They diagnosed a bad AVCS solenoid, with P0011 error code. They charged me $2200.00 to change the solenoid and clean all the oil feed lines! While they were at it, I had them clean the banjo bolts to the turbo, as this had never been done. The engine was removed from the vehicle for them to complete the work.
Today I went to pick it up, it started right up and idled fine. When I pulled onto the highway and accelerated TONS of blue smoke billowed from the exhaust and it had zero power. Before this the car burned one quart of oil every 3,000 miles. I turned around and the car is now back at the dealership.I'm at a loss as to what to do. The car is not driveable at this point.I hate to point fingers, but what could the dealership have done to cause this excessive oil smoke? Again, the car NEVER smoked before the dealership got a hold of it.
Subaru - Forester :: Driver Side Rear Wheel Bearings Replacement
Have a 2000 Forester with 114K. Had to replace driver's rear wheel bearing at 100k & again at 110k; when replacement bearing started to fail, ABS light came on because wheel was not spinning true! Replaced passenger's rear wheel bearing at 105k (this one is getting noisy now).
Hard to believe I got 2 "bum' bearings! Not a difficult repair, but this will be 4 bearings in less than 2 years. The car's driven on paved roads & with little load, so it's not from harsh road conditions or heavy loads.
Subaru - Oil - Forester :: 2002 - CEL Came On - Bad Catalytic Converter?
On my 2002 Subaru Forester (137,000 m), the check engine light came on. They diagnosed and repaired O2 sensor. About 300 miles later it came on again, this time they said the catalytic converter was cooked, and they blamed whatever caused the O2 sensor to fail (or the O2 sensor failure itself). After the repair (about $1300 and 30 miles later), I discovered that the engine oil was so low that it was not showing up on the dipstick (tho the oil light was not yet on). The shop (after admitting that they did not check the oil while it was in there) said it was related to catalytic converter failure. Does this make sense? I have only gone another 60 miles since the oil was refilled, but so far it looks OK. Should I be on the look-out for anything else?
View 16 RepliesSubaru - Forester :: 2002 - Check Engine Light Is On?
Engine light came on two weeks ago. Had the code read at Advance Auto Parts. Code = P0420. The only performance issue was that it stalled when I started it the other day for the first time since I bought it last fall. Are there any other clues to tell what it could mean (catalytic converter vs. 02 sensor vs. anything else)? Is it really worth trying some kind of catalytic converter cleaner product?
View 1 Replies