Santa FE SM (2001-06) :: Vibration At 35 - 40 Mph During Acceleration And Deceleration
I just bought a used 2004 3.5l automatic Santa Fe. The vibration is most noticeable from 35 - 40mph during acceleration and deceleration. It's there at higher speeds but the car doesn't physically vibrate as much.
The vibration is there with the car coasting and transmission in neutral. It's there with the car coasting and the motor off.
The tires and wheels have been swapped out with other wheels and tires. No change.
The front driveshaft U-joint has been replaced. No change.
It seems to be in the drivetrain somewhere. I would like to fix it without slowly replacing everything.
Santa Fe (CM - 2007-12) :: 2010 - Vibration From Rear Under Acceleration
We purchased a new 2010 Santa Fe Limited in October of last year, and as it stands today, we've put about 19,000km's on the vehicle (about 12,000 miles for my American friends). About 14,000km's in, we started noticing a vibration from the rear under acceleration. When you reached cruising speed (regardless of the speed), the vibration would go away, but would appear under acceleration. What was more alarming was that at slow speeds when making sharp left-hand turns (turning into the driveway, doing a u-turn, pulling into a parking spot, etc), there would occasionally be a loud bang from the rear end. The first time it happened, we thought that we had run over something... actually not but it sure sounded like it!
We took the vehicle into the dealership, and after an inspection they found a rock in one of the rear springs. They removed the rock, applied the TSB to place covers over the springs, test-drove the vehicle, and said the issue was resolved.
The next morning, I was heading out of town to pick up a friend, and experienced a loud bang when I pulled into my buddies driveway. Problem was NOT solved. Called Hyundai again, and made another service appointment. This time with the requirement of having a tech come with me for a test drive.
I was able to reproduce the vibration, which really shocked the tech. At the same time, I was also able to duplicate the loud bang when making sharp turns (I had actually caused it to happen twice when driving around the dealership, but I was alone in the vehicle at the time!), when he concluded that there was probably some binding going on in the drive train. They took the vehicle in, and after looking at it, determined that the coupler in the drive train was defective, and needed to be replaced. They didn't have the part in stock, so they had to order it in; my concern was that the vehicle was unsafe, but they assured me it would be fine to drive until the part came in. I went on a weekend trip with the vehicle, and experienced some pretty severe binding when pulling into parking spots (no bangs, but imagine driving through a lake of molasses) - I had to really give it gas to get it moving into the parking spot - not nice, especially considering what might have happened had it 'unbound' while under throttle...it was certainly not safe, but I survived.
After THREE weeks, the part finally arrived, and was installed yesterday. I'm happy to announce that the vibration has ceased, and I can only assume that the loud bang is gone as well (although I couldn't duplicate that on demand, so I'll never know for sure that it's gone). The Tech did mention that it was a new version of the part, so they just didn't install a new part, it was an upgraded new part.
Santa Fe (CM - 2007-12) :: 2011 - Vibration With Moderate Acceleration And Only Sometimes
2011 SF. 52000kms.
A little while ago I noticed a brief vibration (felt through floor and steering) with normal acceleration from stand still... I attrributed this to the cold weather and perhaps oil thickening, as the problem went away after the car was warmed up. Since then I have noticed that it's continually happening on a regular basis, but only for a short period.. I was still thinking that it was the cold, but that wasn't the case because I left the car idle at start up for 20 minutes until well warm.
Now.. If I slowly accelerate (not putting much load on the car) there is no vibration at all. When the car reaches a certain speed, the vibration goes away. There is also no vibration after about 15 minutes of driving.
I had a neighbor test it with me to confirm and he felt it, and initially thought differential oil, but then suggested myriad other things from the CV boot to bearings to etc etc.
I need to take it to the dealership so they can experience the vibration but would certainly need to leave it there over night so they can check it out when "cold".
Elantra XD (2001-06) :: Knocking When Turning / Vibration At Higher Speeds
Recently when I was on a longer distance drive (multiple hours) my car was producing an unusual vibration. It seemed to go away after some time. At the end of my drive I was turning left around a bend and there was knocking sound. One of the boots on the cv joint has been leaking grease so I went ahead and replaced both cv axels.
The knocking is still there. Here are the symptoms:
- Knocking sound when turning left when the accelerator is down.
- Knocking sound is somewhat intermittent when turning, not always continuous.
- The vibration is not always there and is only there at higher speeds, and is made worse when accelerating.
- All of this appears to get worse the longer the car is driven (heat?).
Santa FE SM (2001-06) :: Hesitation On Acceleration
It'll do okay when I am not flooring it, but when I do floor it there's a pretty noticeable lag and then VROM it'll take off like a bullet... This car has a manually operated throttle control, are there any adjustments I can make to make the truck more responsive? 2.4L 4Cyl....
View 3 RepliesSanta FE SM (2001-06) :: Smokey On Acceleration
My 2006 santa fe diesel 2.2 has started to be be a bit smokey when accelerating not even hard had the egr valve off today and gave it a good clean still the same it's not really bad but can see when moving off from parked...
View 2 RepliesElantra XD (2001-06) :: Vibration In Steering All The Time / Slight Clunk On Acceleration
I have just purchased a 2005 elantra fx and noticed a vibration all the time in the steering and you can feel it in the seat on the floor and peddles, not severe but enough to be annoying. I had the same vibration in my last car a 2001 elantra. Is this normal with these cars, or could it be something like engine mounts as there is a very very slight clunk on acceleration ?
View 2 RepliesFord - Mountaineer :: 2001 - Quick Vibration / Shudder From The Rear After Acceleration
I now have an '01 Mountaineer with AWD and the 5.0. I have a strange vibration that only seems to happen when I accelerate as I get on the highway. I get up to speed and just as I let off on the throttle I get a vibration/shudder from the rear. Almost as if I ran over the rumble strip on the side of the highway. It's a short grrrr, then it goes away.
View 2 RepliesPrius (2001-03) :: Severe Vibration When Turning Hard Right Followed By PS Error Code
This summer my power steering went out. I replaced the steering rack with a remanufactured rack, which failed. I got the replacement rack replaced by the remanufacturer and installed by a different shop. Same problem: SEVERE vibration when turning hard right followed by the PS error code, or just little twitchy motions when driving. I'm having the second shop take a look at it again this monday as I suspect that this is a data processing issue.
View 13 RepliesSanta FE SM (2001-06) :: Lack Of Acceleration On The Highway
2002 Santa Fe 2.7L AWD automatic
She was on the highway this afternoon and was accelerating to merge in with traffic. Apparently the car just reved up without actually accelerating. She said it felt like she was in neutral. I've driven the car a few times over the last week and it has been running perfectly - No hesitation anywhere at any speed. There are no CELs (yet). It is probably worth mentioning that it has been raining HEAVILY here for the last 24-hours and I would not be the least bit surprised if she hit a few puddles on the way. I can just about guarantee the CPS has never been changed and am suspecting it may be a short in causing her problem.
Santa FE SM (2001-06) :: Acceleration And RPM Will Dip And Fall For A Second Then Comes Back
So this happens fairly regularly. only during part throttle, cruising, the acceleration and rpm will dip and fall for a second, then comes back. if i let off the gas when it happens and get back on it, it comes back sooner. about a year ago i got TPS CEL, changed the APS but it didn't fix anything.
Weird thing is, when using cruise i don't see it. at least it's not nearly as noticeable. I had some idle and misfire issues recently and found a broken coil the culprit. changed that out and fixed those issues.
What would cause this issue when using the pedal but not the cruise? I think it has something to do with the accelerator pedal sensor...i do notice the throttle cable going to the APS has a small nut on it and it looks like it can be adjusted, would that cause this issue? research says TPS doesn't fail....
Santa FE SM (2001-06) :: Vibration When Goes Into Gear In Rev
ok, I had quite bit of work done, prob over yr ago All oem parts, timing belt, crank sensor, idler pulley, some other things while in that area. So when he was done I got this vibration when it goes into gear never in park only in rev. or drive but only in cold weather and after it warmed up it was go away. No Trans service was done. He kept it overnight outside, had the timing cover off rolled it in the garage, started it and seen that the belt was flapping crazy. So he thought it was that. well every cold morning I have to wait till it is warm to not hear that sound. it only happens during cold mornings never in summer. He had back in his shop 3 times after parts were installed. and its to this day isn't the same. its unfortunate that I didn't have many cold mornings when he had worked on it. but after I had it and the next cold morning it was there.
View 7 RepliesSanta FE SM (2001-06) :: Shudder During Acceleration At Highway Speeds
My '04 Santa Fe (135K miles) has been doing this for a little while.
Between 65 - 75 MPH on the highway, under acceleration, I experience what I can only describe as a "shudder".
I don't believe it's a wheel balance issue, because if I'm coasting or maintaining that speed everything is stable.
Santa FE SM (2001-06) :: Stumble Or Surge On Light Acceleration
On light acceleration, it has a light stumble or surge and is very slow. On hard acceleration it makes a lot of noise, but isn't even fast enough. I can feel it shift through the gears, and can feel the converter lock up when it's supposed to. Any attempt to climb a slight hill or pass a car, it downshifts to what seems like 2 gears down, and has a loud roaring noise, but I don't feel the acceleration. At steady speed, it feels like it's hunting for a steady RPM, but can't find it.
I just had a timing belt replaced. Had the mech double check to make sure marks are correct. He did a cranking compression test and said they were all between 165-170 psi (is that a little high for a 150K mile car?). He smoke tested the intake system and found no leaks.
It does have codes stored for cat converter and a lean code-bank 1.
Santa FE SM (2001-06) :: 2004 - Low Pitched Acceleration Whine
I will try to film the sound and post it later; but for now I have a 3.5L V6 AWD with 85k on it. i get grunting and groaning on colder mornings and sometimes a med pitched whine, more noticeable at higher speeds in town.
View 9 RepliesSanta FE SM (2001-06) :: 2004 - Shudder When It Comes To Stop On Acceleration
Ok here's the situation. 2004 Santa Fe 2.7 AWD 170,000 miles.
I recently had to replace the front passenger side Drive axle. That was a piece of cake. However, since then the car has developed a shudder when it comes to stop (felt like the shudder on acceleration that was fixed by the dealer with a reflash). Suddenly it got so bad that it stalls when put into gear with the brake on. It feels like it is not coming out of converter lockup.
When I drained the fluid I replaced it with Valvoline Import multi-vehicle full synthetic (it says it is spiII). I latter added another half quart of Castrol transmax import multi-vehicle (also spIII). Did I screw up my trans? Will a flush work? Or do I just need to replace the trans and torque converter?
Santa FE SM (2001-06) :: Slight Hesitation During Acceleration Suddenly
Last night i noticed a slight hesitation during acceleration. Today i had driven around in town for awhile and did not notice any hesitation. When i got onto the interstate I pushed down the peddle to pass someone and it did nothing, I let off the gas and back on and the car bucked pretty bad. All the way home it has issues when I pressed on the gas but did fine at cruising speed. I would think a fuel filter would have been a slow progression issue so I am thinking maybe it is a sensor. I sprayed carb cleaner around vacuum hoses today and did not notice any surge so I think I eliminated a vacuum issue.
2004 Santa Fe 2.7 149k
Santa FE SM (2001-06) :: 4wd Binding While Tight Turning Or Backing Up
I have a 2004 Santa Fe GLS 3.5L AWD. Months ago I occasionally started noticing a strange sensation when backing up like the wheels were binding. Since it was intermittent I really didn't think too much about it and I don't drive the SF much except during bad weather or on vacation trips. The issue has gotten much worse and happens every time I drive it. This past week it bound up while turning into a tight parking place.
It binds to the point that the vehicle will just stop under normal acceleration. Backing up it does the same thing. When I finally got pulled into the parking place it felt like someone bumped me (I don't remember if this was before or after placing in park). I also feel it when taking very tight switchbacks in the mountains.
So doing research on this I came across the TSB about the Transfer Case Control Module, however after visually inspecting my module I determined it was made in May 2004 so it does not apply to the TSB.
Is it possible my module just went bad? So I am wondering what I should try? Replace the module with a used one (if I can find one) or foot the $300+ bill for a new one. Either way does anything need to be done to program it?
Santa FE SM (2001-06) :: Odd Vibration At 45 Mph - 3.5 Liter AWD Not Working
I recently purchased a used 04 3.5 liter SF. I don't think the AWD system is working. The car has a bit of an odd vibration at 45 mph but I thought this was due to the new all terrain tires on put on the car. There are no check engine lights on in the car and it otherwise drives straight and well.
It just snowed here for the first time in CT this season. I took the santa fe out and tried to start on some hills and it would just spin the front tires and slide backwards. The rear end would not kick in at all. It didnt matter if I had turned traction control on or off. When I look at the snow there are only two front tire marks that spun down into the snow. The rear tire left not skid marks.
There are no strange sounds coming from the rear differential. I know the Santa Fe 3.5 use the Borg and Werner magnetic clutch system and is usually front wheel drive. Is it possible that clutch system is worn out or is it an electrical issue with the front not sending the rear a signal to engage the rear diff?