Santa FE SM (2001-06) :: AC / Power Steering Belt Squealing Intermittently
The AC/power steering belt in my 2004 Santa Fe, 2.4L has intermittently squealed for some time, but lately the squeal has gotten louder. Initially it only happened when the compressor was on, but now it happens when the compressor is off. I have not experienced a loss in steering power but I did notice that the power steering fluid appears to be discolored. I have replaced the belt and re-tensioned it several times hoping this would solve the issue, but it hasn't. I intend to take the belt off again and see if the pulleys all spin freely. When I replaced the belt initially, everything did spin freely. My guess is that the power steering pump may be shot and is putting excessive load on the belt, however, there is no PS pump "whine" and again, no loss of power steering. It looks like I should also check for separated pulleys.
View 3 RepliesSanta FE SM (2001-06) :: Strange Noise Behind Passenger Airbag
I get a strange noise behind the passenger airbag, like parts moving.
Recently I noticed that the a/c does not come out cold. Could these issues be related?
Santa FE SM (2001-06) :: 2004 - Whining Noise From Power Steering Pump
I have a 04 santa fe , which slowly started whining which was diagnosed a power steering pump, when replaced the problem got worse and it became very hard to steer. Steering rack was the next diagnosis, replaced and another new pump. Now its so hard to steer and the whining has returned. Looking in the reservoir the fluid seems to be moving good with no bubbles??
View 3 RepliesSanta FE SM (2001-06) :: Power Steering Noise When Turns The Wheel While Stationary Or Driving
My daughter's 2004 Santa Fe (2.4L standard transmission) is making strange noises on start up which I think is due to a power steering issue as the noise is greater when she turns the wheel while stationary or when driving for the first 5 minutes or so until it warms up.
She came over tonight I she is about an 1 to 1.5" below the MINIMUM line on the Power Steering Reservoir.
Is there any special or proprietary Power Steering Fluid I need to be buying or what should I be buying to top this up?
I know there has been much discussion on using only Hyundai automatic transmission fluid over the years, but in this case it's for the power steering?
Santa FE SM (2001-06) :: Whine Noise Only When Turning Right - Power Steering Reservoir Leaks Fluid
I have a 2004 Santa Fe 3.5L with 85K miles. TB, WP and all belts changed at 75K. Have had this whine noise when I turn right, very high pitch noise. On top of this there is now Power Steering fluid leaking from the reservoir and base and brackets are full of fluid... Needless to say I assume it is the reservoir seals giving up but why the noise only when I turn right? No noise when I turn left.
What could it be? Also where can I find parts online that are cheaper than the stealership? I called them and they quoted me $72.00 for this piece of plastic!!
What else should I change? There is also some "oil/fluid" coming down a pressure hose but I believe this is due to the oil dripping from the reservoir...
Any manuals I could use to view this? I bought the Haynes manual and it's worthless!
Santa FE SM (2001-06) :: Hum Noise When Speed Reduced - Power Steering Fluid Leak From Reservoir
2005 Santa Fe (88K, 2.7 V6).
For a month or two, after the car got warmed up, I'd hear a whine/hum noise when I slowed to turn or reduced speed. The noise was much more noticeable when the car had been running at least 15-20 minutes, but I did occasionally hear it when the car was somewhat cool still. Never had a problem steering during this time, even with the noise... but I eventually figured out that slowing down and/or turning brought it on. So I took it to a mechanic.
They showed me bubbles coming from the power steering reservoir, and said I needed a new PS pump and pressure hose, along with a flush/new fluid. I paid for all of that.
Next day: The car would become hard to turn when I made a tight turn into a parking spot... again, not a constant thing, but only when turning to park and going slow. The noise APPEARED to be gone, but this new issue worried me so I took it back. They put a different pump on (no charge), thinking the other may have been defective.
Next Day: I hear the whine again on my way home from work. When I get home, I park, leave it running, and pop the hood. There's a fast drip bubbling from beneath the reservoir cap and running down to the pavement. First thing the next morning I return to mechanic. He says the first two pumps were the same brand and both "remanufactured" so he switches to a different brand -- this one brand new, not "remanufactured" -- and installs that one.
A half hour later, I get home. Hearing that same whine/hum, I lift the hood. Fluid is pouring out from beneath the cap in a steady, unbroken stream (not a drip, but a stream). So I took it back to the mechanic (who to his credit, has charged me nothing since the initial new pump installation). What could cause the power steering fluid to gush out from the reservoir cap when the car gets hot? I have a brand new pump and pressure hose. What could cause this condition..
Pontiac - Montana :: 2001 - Strange Rubbing Sort Of Noise Coming From Front End
There is a strange rubbing sort of noise coming from the front end. I hear it when I take my foot off the accelerator and/or when I turn the steering wheel to the left. To me it sounds like it's coming from the passenger side of the front end, but I could be wrong. The most recent work done to the vehicle was the brakes, about a month or two ago.
View 2 RepliesSanta FE SM (2001-06) :: 2002 2.4L - Timing Belt Whining Noise?
I just installed a new timing belt, balance belt, idler, and both tensioner pulleys but am getting a little whine. I adjusted the balance belt but the noise does not change. No other belts or items are hooked up yet this was a dry run. Car seems to run fine and idles well. The hydraulic unit seems to be working fine and it's a OEM Hyundai piece.
Anything common I can look for that should stand out? 2002 Santa Fe 2.4L
Elantra XD (2001-06) :: Power Steering Acting Up Like Belt Is Slipping
Well, two years after I replaced the pump bearing and the power steering is acting up like the belt is slipping. Sometimes it works fine, sometimes the steering gets jerky and hard.
The fluid level was fine, but I changed out the old stuff anyway, the belt is fine and not loose. I also pulled the pump apart to inspect it and it still looks as good as new.
When it acts up at a stop, it will squeal, but like I said, the belt is not loose. It's almost as if the rack is bottoming out against the bump stop (it's not) or the valve that lets excess pressure is dumping pressure randomly.
I took the valve apart with the pump and it looks fine, no scratches. Do the rack or valve go bad? If so, what was that like and could my rack have a seal leaking inside?
Santa FE SM (2001-06) :: 2005 - Ticking Noise / Blue Spark Occurring At Random Intervals On The Balancer
2005, 2.7l. FWD automatic, with 180,000+ miles.
A week ago it started making a random ticking noise I've never heard before. Today was the first chance I got to try and find it and I'm stumped on what could cause this.
The sound is a static or low voltage electrical discharge coming off the harmonic balancer. I can actually see the blue spark occurring at random intervals and locations on the balancer as the car is running.
Do i need to be looking for a bad engine ground? I'm having no other electrical problems. The car runs like a champ other than a minor oil and power steering fluid leak.
Ford 6.7L Power Stroke Diesel :: Strange Noise After Shutdown Coming From Top Front Of Motor
The truck always made a few strange noises after shutdown, but this is new and annoying.
Here's the scenario: Truck is warm and no CEL. A few seconds after shutdown, I hear all the normal(?) noises and then a noise that sounds like a vacume pump running starts and continues for about 20 to 30 seconds. Cycling the key, but not starting the motor will cause the noise to happen again and again on each key on/off cycle.
The noise seems to be coming from the top front of the motor. Could this be fuel pressure bleeding off? Is there a check valve that is maybe not doing it's job??
Ford 7.3L Power Stroke (1999-2003) :: 2001 - Strange Noise At Start Up?
I have a 01 f250 7.3. Every once and a while when I go to start my truck it make a strange noise, very similar to the sound a vehicle makes when you try and start it while it's running. if I let off the key and try again it will start. Sometime it will do it 2-3 times. So far I have never had it not start after a few tries. Can't seem to put a reason behind when and why it does it. Sometimes it will go weeks without happening, sometimes it will happen twice in a day. Starter is year old but put a cheap one in it. Is it my starter or something else.
View 13 RepliesAccent LC (2000-05) :: Power Steering Belt Is Making Squeaking Noise
The steering on our 02 Accent has been becoming more and more difficult. The belt on the AC compressor snapped off recently. Could this missing belt be causing a problem with the power steering belt? The power steering belt is now making a squeaking noise.
View 3 RepliesSanta FE SM (2001-06) :: Power Steering Leak
I have a 2003 Santa Fe 3.5 liter. I have a bad power steering leak and the dealership says I need
pressure hose
return hose
cooler hose
I've tried all the local car part stores and Napa has the pressure hose but for about $180.
Santa FE SM (2001-06) :: Power Steering Won't Working
I am having a power steering problem with my 2006 santa fe, been going on for a couple weeks and I am stumped on what is wrong with it, what I noticed is turning to the left or right and very hard to turn and sometimes it will be fine and other times its the left or right.. What could be going on here? there is no leaks or noises noted, it has 242,000 kms on it. fluid is full but a little brown and smells a bit burnt. I know it will need a flush but would that be the solution or would it be something else?
View 15 RepliesSanta FE SM (2001-06) :: Power Steering Gives Off A Steady Whine
I've got what seems to be a fairly common problem in that my power steering on my 2001 SF gives off a steady whine. I've read in several posts that removing the power steering reservoir and either replacing it or cleaning out the screen solves the problem. I'm ready to give that a shot, but can't seem to figure out how to remove the part. There is a "tab" type of thing on the back of it, but it doesn't seem to do the trick. I'm admittedly no mechanic, but this seems like it should be relatively easy. How to remove the reservoir?
View 6 RepliesSanta FE SM (2001-06) :: Power Steering Fluid Leaking
I noticed that the power steering fluid is leaking bad from a weird spot under the car, it looks like it is coming directly under the drivers seat but I can see any lines. It's an 02 Santa fe ....
View 8 RepliesSanta FE SM (2001-06) :: Power Steering Fluid Disappearing
I have very good question. My 2001 Santa Fe has 200k miles, I think the car is great. Regular maintenance, and the car drives still drives strong and comfortable.
Here is my problem: The power steering fluid is disappearing. There is no puddle under the car, I got under the car and everything is dry. However about once a week (+/- 200 miles) I have to add power steering fluid. I have cleaned the reservoir twice and confirmed that the top of the reservoir is also dry ( so is not bubbling off the top of the reservoir).
I have put newspapers under the car while parked overnight to see if there is a leak and the news paper is dry in the morning without a stain.
Fluids do not disappear. Could it be leaking while driving (high pressure hose) and its leaking from a location that I cannot see? Where is the "banjo connector" that I have heard referred to ?
Santa FE SM (2001-06) :: Low Squeaky Noise When Parking And Turning Steering Left Or Right
My 2006 santa fe drives great,,,except now it makes a low squeaky noise when parking and turning the steering left or right...it does not make that noise while driving at any speed in a line or on bumps...the strut top plates? can i just grease that?
View 2 Replies