Santa FE SM (2001-06) :: Strange Spark Noise Coming From Power Steering Belt Region
I have a 2003 Santa Fe, 2.4L.
Last night, I added some power steering stop leak to my PS system, but I accidentally spilled some below the reservoir. Soon after, that area of the engine starting making a consistent "spark"-type noise. I think it has something to do with the belt, because when I turn on AC, the noise gets a little faster in rhythm.
I say "spark" noise because it sounds like an electrical spark, rather than clicking or whining.
Isuzu - Trooper - Ls :: Sounds Like A Squealing Belt Intermittently
Know that squealing sound a belt makes when it's loose and needs to be replaced? Well what is it when you hear that sound, but you know it's not a belt? It happens intermittently, usually when the car is cold...and it's been happening more and more lately...like whatever the problem is, is getting worse
View 8 RepliesElantra XD (2001-06) :: 2003 - Belt Squealing On Startup
2003 elantra when I start the car the belts squeal for about a minute, then whatever I do they start squealing again- turn on headlights, roll down windows, steer the car, turn on ac, anything starts the squealing again. I have had all new belts including timing belt, water pump, etc and it is only getting worse by the day.
View 2 RepliesElantra XD (2001-06) :: Power Steering Acting Up Like Belt Is Slipping
Well, two years after I replaced the pump bearing and the power steering is acting up like the belt is slipping. Sometimes it works fine, sometimes the steering gets jerky and hard.
The fluid level was fine, but I changed out the old stuff anyway, the belt is fine and not loose. I also pulled the pump apart to inspect it and it still looks as good as new.
When it acts up at a stop, it will squeal, but like I said, the belt is not loose. It's almost as if the rack is bottoming out against the bump stop (it's not) or the valve that lets excess pressure is dumping pressure randomly.
I took the valve apart with the pump and it looks fine, no scratches. Do the rack or valve go bad? If so, what was that like and could my rack have a seal leaking inside?
Elantra XD (2001-06) :: Belt Squealing Noise When Driving On Highway - Overheating
2003 Hyundai Elantra.
Driving on the highway and thought I heard a belt squeal. Looked at temp gauge, overheating in the red. Stopped car. Antifreeze on passenger side sprayed around, hard to tell from where.
Waiting a while, put a good amount of water in it as there seemed to be no anti-freeze left. Drove a bit more and it started going up on temp gauge. Pulled off highway on an exit, temp gauge went back down before I could pull over.
So I continued on the highway. The temp gauge would go back up to 3/4, then I'd put it in neutral to cost to a better place to stop, and the gauge would go back to halfway.. continued this for several miles to get home. Never overheated again, but kept getting "hot"(3/4) and dropping back down to normal (1/2)...
Civic - Honda :: 2001 - Power Steering Intermittently Cuts Out And Wheel Becomes Really Hard To Turn
The power steering on my 2001 Honda Civic intermittently cuts out and the wheel becomes really hard to turn. The belt is tight and the fluid level is correct.
The weird thing about it, is it only happens in cold weather. Everything was fine all summer, but now that the weather has turned colder the problem has reappeared. Same thing happened last year. . .
Santa FE SM (2001-06) :: Power Steering Leak
I have a 2003 Santa Fe 3.5 liter. I have a bad power steering leak and the dealership says I need
pressure hose
return hose
cooler hose
I've tried all the local car part stores and Napa has the pressure hose but for about $180.
Santa FE SM (2001-06) :: Power Steering Won't Working
I am having a power steering problem with my 2006 santa fe, been going on for a couple weeks and I am stumped on what is wrong with it, what I noticed is turning to the left or right and very hard to turn and sometimes it will be fine and other times its the left or right.. What could be going on here? there is no leaks or noises noted, it has 242,000 kms on it. fluid is full but a little brown and smells a bit burnt. I know it will need a flush but would that be the solution or would it be something else?
View 15 RepliesSanta FE SM (2001-06) :: Power Steering Gives Off A Steady Whine
I've got what seems to be a fairly common problem in that my power steering on my 2001 SF gives off a steady whine. I've read in several posts that removing the power steering reservoir and either replacing it or cleaning out the screen solves the problem. I'm ready to give that a shot, but can't seem to figure out how to remove the part. There is a "tab" type of thing on the back of it, but it doesn't seem to do the trick. I'm admittedly no mechanic, but this seems like it should be relatively easy. How to remove the reservoir?
View 6 RepliesSanta FE SM (2001-06) :: Power Steering Fluid Leaking
I noticed that the power steering fluid is leaking bad from a weird spot under the car, it looks like it is coming directly under the drivers seat but I can see any lines. It's an 02 Santa fe ....
View 8 RepliesSanta FE SM (2001-06) :: Power Steering Fluid Disappearing
I have very good question. My 2001 Santa Fe has 200k miles, I think the car is great. Regular maintenance, and the car drives still drives strong and comfortable.
Here is my problem: The power steering fluid is disappearing. There is no puddle under the car, I got under the car and everything is dry. However about once a week (+/- 200 miles) I have to add power steering fluid. I have cleaned the reservoir twice and confirmed that the top of the reservoir is also dry ( so is not bubbling off the top of the reservoir).
I have put newspapers under the car while parked overnight to see if there is a leak and the news paper is dry in the morning without a stain.
Fluids do not disappear. Could it be leaking while driving (high pressure hose) and its leaking from a location that I cannot see? Where is the "banjo connector" that I have heard referred to ?
Santa FE SM (2001-06) :: Power Steering Pump Pulley Broken
My Santa Fe has a broken power steering pump pulley. Darn thing broke right around the spindle! I can not find a replacement anywhere. I've tried to find a one new, used and at the upull lots (only one Santa Fe in at Pick n Pull dang thing was stripped clean!). The pump is easy to find but this pulley is a ghost!
View 3 RepliesSanta FE SM (2001-06) :: New Power Steering Pump Worked For 5 Minutes
My power steering went out a few months ago. No warning, whining, or hiccups. Just stopped working. Installed a new pump today, and it worked great for about five minutes. Bled it out, put fluid in, etc. Took off on a test drive and a mile up the road I went to turn into a street and power steering was gone.
Fluid is still full, belt is still there, no visible leaks. 2004 3.5L V6.
Santa FE SM (2001-06) :: 2004 - Power Steering Fluid Leak From Cap
I have a leak coming from the top of my reservoir from the under the cap for some reason. I bought a new cap and it seem to stop for a day and now it leaking out from under the cap again. What is the reason it would be coming out of there. Am I going to have to replace the reservoir??
View 1 RepliesSanta FE SM (2001-06) :: Power Steering Return Line Replacement
I have a 2003 Santa Fe that had a corroded leaking power steering return line. I want to replace both the high pressure and the low pressure lines coming from the steering box. The high pressure removed quite easily. I cannot get the low pressure out. Everything is broken free. Is there a trick to this? I want to see how it comes out so I can put the new one in same way.
View 3 RepliesSanta FE SM (2001-06) :: Power Steering Fluid Slow Leak
2004 XG350 with the Sigma engine, 133,xxx miles.
In the picture I attached, the large silver bolt is leaking. Its a slow leak: yesterday morning I wiped it off, and then we I got home from work there was a bead of power steering fluid, but not enough to drip.
What is the best way to fix this? Is it as simple as tightening it?
Santa FE SM (2001-06) :: Smoke In Engine Bay - Might Be Power Steering Leak
Going up my driveway (its kinda steep) after 4 or 5 inches of fresh snow fall- smoke in the engine bay and inside the car. Its a 2003, Santa Fe with the big V6. Driving on level ground it doesn't smoke. I thought it must be the 4WD which I guess only kicks in when needed, driveway hadn't been snow blown yet. Saw a couple dots of red in the snow afterward. Didn't notice it before. But on the way to work tonight (same day) the power steering was not a 100%. The reservoir is down, right on the minimum mark. So now I'm thinking I have a leak and the smoke is from the PS fluid hitting the exhaust. Though why it only smokes in my driveway beats me. It looks as though the exhaust on this engine (big V6) is directly underneath the pump. I think I can verify it tomorrow. Would a PS leak in the vicinity of the pump fall onto the exhaust? Think this is the smoking gun? I can't even see the pump. But the manual says its on the left/rear.
View 3 RepliesSanta FE SM (2001-06) :: Power Steering Lower Return Line Replacement
Looking for the instructions on how to remove the lower power steering belt and replace it. We recently discovered the leak and I can't find any information on it.
View 1 RepliesSanta FE SM (2001-06) :: Power Steering - Pump Making Whine At Idle
I have a 01 santa fe 2.7 motor. I have read several threads in here regarding the famous pump whine. my pump is making a whine at idle, I have cleaned the bottle and made sure the screen has not restrictions, drained all the fluid, and have inspected the lines for leaks.
With a stethoscope have pin the noised to the pump, the noise travels in the reservoir when I race the engine the noise is more evident on the bottle. I am tempted to replace the pump, but the steering has no issues and operates fine, also no change in the whine noise when moving left to right.