Santa FE SM (2001-06) :: 2004 3.5 Engine Will Die Randomly
Engine will die randomly. After sitting for half hour it will restart. It has been to the dealer, it sets no codes but when it dies all lights on dash come on just like when you first start car. It has 75k on it timing belt replaced new plugs and wires. Dealer kept it 2 days and could not replicate the problem.
View 2 RepliesSanta FE SM (2001-06) :: 2004 - Gurgling Engine At Low RPM
Recently acquired a 2004 santa fe 3.5l w 99K miles on it. at idle/low rpm i hear a slight gurgling type noise from the engine. I can try to get a video. I recently did an oil analysis and they found no trace metals to indicate engine failure (high trace metals indicating bearing failure etc). i was a few PPM high on iron (16 when universal avg is 10) but blackstone explained it may simply be the way this engine runs and not to be alarmed. they stated an overall good report with strong results. I can try to post the report if wanted. The engine feels pretty strong overall. I recently had timing belt, drive s belts, spark plugs done to bring it current on service.
View 5 RepliesSanta FE SM (2001-06) :: 2004 2.4 Petrol Engine Starting Rattle
I have a 2.4 Petrol, 16 valve engine in my Santa Fe which produces a rattle on startup when cold. When warm it starts normally. Oil and filter change makes no difference. Timing belt changed 40K ago. No other effects felt with regard to power or noise once initial noise/rattle has stopped after 2 to 4 seconds.
View 4 RepliesSanta FE SM (2001-06) :: 2004 2.4l Engine With High Idle Speed
2004 2.4l engine has high idle speed aprrox. 1000rpm.
View 2 RepliesSanta FE SM (2001-06) :: 2004 - Engine Jumped Suddenly When Idling At About 20 Mph
I just got a used Hyundai Santa Fe (2004). I was so excited until about 50 miles of driving it. Here is what happened:
I was idling at about 20 mph when all of a sudden the engine jumped (a little bit) - the RPM went down to 0 and the check engine light came on. I pulled to the side of the road and put it in park - then the car went back to normal like nothing happened, it didnt stall all the way. I was concerned and took it back to the dealership and they did a diagnostic test on it and it came back negative, nothing was wrong with it.
My boyfriend was driving up north with it and it happened to him, this time, it stalled. He said that the engine jumps a bit- but all of the lights go on on the dash. I remember it smelling pretty hot when I opened the hood before with it happened the first time, so I asked him to open the hood. He said it did smell hot. He checked the coolant and it was empty. It looks like there is fluid in it from the outside, but that was just the line that previous fluids had. He put coolant in (not in the actual radiator, but in the place where coolant goes) and it still stalled. I didn't want him to drive it anymore for fear of something worse happening, so there it sits.
Is this something that happens with most cars, or this kind of car? I am kicking myself for not purchasing the extended warranty, but I didn't have the extra cash to add over 1k to the price. Could it be just the coolant needing to go into the radiator? Do Santa Fe's typically shut down before they overheat? I was doing some research and it seems that cars stall because of either the fuel system or electrical system.
Santa FE SM (2001-06) :: 2004 - Filling Up Gas Tank Makes Engine Die
I've got a 2004 Santa fe V6 2.7 with a strange problem (145k miles).
On Sunday I filled up the tank and the car would start but not stay running the engine would just peter out and die. Took me a few minutes and a little revving and feathering the gas to get it to where the engine would not die b/f I got it into gear. After driving a mile home I turned off the car and restarted it 3 times w/o incident.
There was a previous episode that was very similar a few months ago. However, this was an isolated incident. I did a little research on the fuel filter and discovered the necessity of pulling out the back seats and did not take any action beyond always buying good gas. I lied to myself that the first freeze and a very cold engine was somehow to blame.
Friday morning I left on a trip (w/o getting more gas) and in route I filled the tank twice and both times it did not want to start. The car stated like normal when I left for the return trip. I stopped for gas once on the way home with the intent of buying just enough gas to get home and leaving the engine running while I pumped. As soon as I removed the gas cap the engine died and was once again difficult to start (the engine seemingly becoming more stubborn with each incident).
Additionally the idle while in gear was not as smooth as it has been but not necessarily to the point where I would have noticed if I had not been watching closely. I spent about 10 minutes on idle and under 10 mph creeping through a construction zone and the rpm dropped sharply a few times. what this could be?
Santa FE SM (2001-06) :: 2004 2.4L - Stalled / Engine Cranks But Will Not Turn Over
2004 2.4L Sante Fe Base model. Car stalled out the other night, engine cranks but wont turn over. I have it towed to mechanic who tells me that the ECU is fried and they cant get any diagnostic done, that only a hyundai service can do this. I have it towed to service. Service tells me that they cant get a diagnostic done without a working ECU and that for the ECU alone. Then they could figure out what was going on with the car. The service also told me that the ECU isn't something that you can just go get at a scrapyard because it is specific to the VIN on my car. It just didn't sound right to me but I might be wrong.
View 7 RepliesSanta FE SM (2001-06) :: 2004 - Engine Stalled When Coasting To A Stop
I have a 2004 Santa Fe (4 cyl 2.7 L FWD) with only 42,000 miles on it. Coming home from work I was stopped at a stop sign and after stepping on the gas (halfway thru the intersection) my engine stalled - coasting to a stop (while crossing a very busy intersection I might add). After putting it in park I try to restart it - the engine cranks over as usual and starts but roughly 4 to 7 seconds afterwards it stalls again. I did this 4 or 5 times again with the same results. I'm almost positive the check engine light is on. The next day I popped the hood to see if the belt broke but its fine so I tried to start it again (same results engine starts but after 4 to 7 sec. stalls again). Before this engine trouble I haven't had one ounce of trouble from my Santa Fe. Not to be funny but yes there is a half a tank of gas in it... with plenty of fluids in it. After some research I kind of think its the Crank-shaft sensor (seems to be a problem with them in the Santa Fe's).
View 14 RepliesSanta FE SM (2001-06) :: 2004 - Loud Knocking Sound Coming From The Top Of Engine
My 2004 Santy 3.5L (I am the original owner) just turned 91.4K miles and all of a sudden a VERY LOUD Engine Knocking sound came from the top of the engine. I have been changing my own oil since new with synthetic Mobil 1 and a new filter every time, and I never had any issues. I changed it last week at 90K prior a Spring Break trip (1350 miles).
Then yesterday after I let her rest for 1 day, I took the kids to school and within 10 miles of my house the ticking HARD loud noise started happening. I pulled over near a shop (within 1 block of where the noise started) and they said...don't drive it it sounds like a lifter collapsed, or a rod bearing or something big...
I had her towed to the dealer and the first thing they told me is to gather all the oil change receipts and a "manifesto" and they asked me how often I change the oil... I said every 5K miles. I change my own oil and have done since day 1.
BTW, Timing Belt, Water Pump, tensioners, belts, coolant, spark plugs and coils were changed last year at 77K miles.
The car should still be covered under the 10year/100K Powertrain and I believe they are trying to build a case so Hyundai can cover this or not...
They still need to tell me what's wrong... I change my own oil so I don't have receipts for "oil changes" and I have a log of when oil was changed...
Santa FE SM (2001-06) :: 2004 - Engine Hesitation After Driving For 15 - 20 Minutes And Poor MPG
I've been having some trouble with engine hesitation after driving for 15-20 minutes and poor MPG on my 2004 Hyundai Santa Fe 2.7L. I've been slowly running through some tests as I learn how to diagnose car troubles. I just ran a voltage test on my 4 O2 sensors using a bluetooth scan tool and the Torque Pro app. I ran the tests at idle after warming up the engine. To me, the upstream sensors seem fine but downstream sensors are not behaving like they should. Aren't the downstream sensors supposed to be relatively flat around .45 volts while the upstream sensors fluctuate steadily between .1 and .9?
B1S1:
B1S2:
B2S1:
B2S2:
Santa FE SM (2001-06) :: 2004 3.5L - Howling / Whining Occur Occasionally Once Engine Is Warm
2004 3.5L Santa Fe ... My vehicle has about 156k and has a new problem. Occasionally, there is a howling / whining that seems to occur occasionally once the engine is warm. When this happens, the directional can light but will not blink. Same for the hazard light.
Replaced the alternator only about 2 months ago, Checked the p/s pump and it is good and no fluid loss from the reservoir. Been a great vehicle with only a minimal of issues since new. The first time this happened, the car had been on a 15 mile run. It sat for about 20 min afterward when I returned home. After re-starting it to run another errand, the whining / howling began. This lasted about a mile and went away about 2 blocks from my house on my return.
Santa FE SM (2001-06) :: 2004 - Momentary Loss Of Power / Engine Management Light Came On
I have a problem with my 2004 Santa Fe, 2l diesel. Will try to keep this short!
When driving it suddenly 'heaves' (not sure how else to describe it), then it cuts out. I wait about a minute and then it restarts.
At first there was no 'heave' but there would be a momentary loss of power (I thought it was the clutch). Then it progressed to the 'heave' and then cut out, this happened now and then. Very quickly it started to do it every time I drove it. My neighbor mechanic blew down the fuel line, said the fuel pump in tank sounded ok, seemed to do it more when below quarter of tank.
So I kept tank topped up, it seemed ok, then on one 11 mile journey it did it 3 times, the last time the engine management light came on, crawled it home, after which it would not start at all. The computer said it was either fuel rail or coolant sensor. Neighbor replaced coolant sensor, it started ok. Tried it next day - 6 miles and it heaved and cut out again. This time no light coming on.
I've read about cam sensor, crank shaft sensor, fuel pump at back of engine...
Santa FE SM (2001-06) :: 2004 - Check Engine Light Is On / EVAP Canister Solenoid
I have a 2004 Santa Fe 2.4L the check engine light is on and says about the evap canister solenoid. I am trying to located it but I can't find it. So, where would it be located at so I can take it apart and where is the Canister located as well...
View 1 RepliesSanta FE SM (2001-06) :: 2004 - Power Loss With A Check Engine Light On / Intermittent Misfire
I have a 2004 santa fe with a 2.7 v6. I have had a little misfire issue lately. I had a major power loss with a check engine light on it lasted for just a minute before it settled itself out. Had the code pulled at a local parts store. P0301 so I checked the plugs and they looked worn out. I pulled the upper intake and replaced the plugs and wires plus the upper intake gasket. I cleared the code and that seemed to correct the problem. Two days later, same thing happened. The engine seems to be running fine now. I wiggled the wiring harness to the injector and to the coil, no change in the way it runs. I was thinking it could be an injector or a coil pack.
View 6 RepliesSanta FE SM (2001-06) :: 2004 2.4L Engine Running Rough And Shakes After Timing Belt Replacement
I recently replaced timing belt and balance belt on my 2004 santa fe 2.4l and now the engine runs like crap and shakes badly. I went over all timing marks again and again and I am at a loss.
View 9 RepliesElantra XD (2001-06) :: Coolant Temperature Fluctuates / Sometimes Rises Rapidly From Normal To Red And Back
About 4500 miles ago, I had the timing belt, water pump, thermostat, and all the accessory belts replaced and now, the water temp gauge sometimes rises rapidly from "normal" all the way to the "red" and back within about 15 seconds! This is on a 2006 Elantra GT
Should I replace the "coolant temp sensor" or do I have a real problem that needs repair?
Prius (2004-09) :: Outside Temperature Gauge Fluctuates
Something strange started happening to my '04 Prius yesterday and it happened again today. We are experiencing unseasonably warm temperatures here in Western Oregon for October and when I left my house this morning at 6:30 am, it was about 55 degrees. I have a half hour drive to work on a mixture of expressway, freeway, expressway again and then the two-lane highway.
Anyway, yesterday (and today) when I'm almost to work, my temp. gauge drops down to 37 degrees. This causes that yellow light to start blinking indicating that the engine will not shut off because of cold temps. It will warm back up to 45 degrees a minute or two later. Why is this happening? It for sure is not 37 degrees outside. Is my temperature sensor going bad? Is this exhibiting the behavior of a sensor going bad?
Santa FE SM (2001-06) :: 2004 2.4L - Turn Ignition Key Get A Click And Engine Will Not Turn Over
We have a 2004 2.4L 4 cyl Santa Fe. Turn ignition key get a click and engine will not turn over. Push key in harder and engine may start fine. If it is the key ignition switch or something else. is there somewhere I can look to see how to remove the ignition switch?
View 4 RepliesNissan - Sentra :: Speedometer Fluctuates Simultaneously With Engine And Tachometer
My speedometer shows 15 mph at idle stop in Drive gear. Sometimes it fluctuates simultaneously with the engine. Then tachometer also fluctuates. I took it to the dealer, and they wanted to replace an instrument cluster (under the dashboard), but I declined. If it is a cluster, why does it fluctuate with the engine and tachometer? I took it to the shop, but it did not do it then.
View 4 Replies