Prius (Gen 2) :: ICE Failure - Leaking Water Pump Replacement
My ICE failed to start on a wooded forest road -- after the car had sat under a fir tree for a day or three it ended up starting and all the warning lights went away. I ended up taking it to the dealer though and while they replaced a leaking water pump, never found any cause for the ICE failure.
View 2 RepliesPrius (2010-12) :: Hybrid Water Pump Failure / Replacement?
Had the Check Hybrid System and master warning light come on today. Took it to the dealer, who, after a couple hours, told me that my "Hybrid Water Pump" needed to be replaced.
View 19 RepliesPrius (2004-09) :: Main Water Pump Leaking / Replacement?
I have worked on several minor to moderate engine issues over the years with various brand cars so I was thinking about replacing my leaking main water pump (not the Hybrid pump).
View 9 RepliesPrius (2004-09) :: 2008 T6 Dies During Water Pump Replacement
I have a 2008 Prius T6 that I took in for routine oil change at Big-O tires. They called and said water pump was leaking badly.
Pump replaced 2 hours later, but they cannot "burp" car because it won't start. The hybrid battery is apparently too low (1 purple bar) and after repeated attempts it's dead (one vertical bar on display). I've never seen this happen before... I've seen the car battery die (after leaving lights on) but the hybrid battery has never gone low.
Big-O calls and says,
(1) We've replaced pump before and never seen this happen
(2) We called Toyota and there is only one high-voltage charger in the region... we don't know where
(3) Toyota said nothing is wrong with the car, it just needs a charge
(4) Toyota said we did nothing wrong
Prius (Gen 2) :: Loss Of Fuel Economy After Electric Water Pump Replacement
After my electric water pump was replaced under the recall my mileage went from 45 mpg to about 30 mpg. Part of this might be due to new tires and cold snowy weather (CT !) but I have never seen such a drastic drop in performance (2005 Prius).
View 12 RepliesToyota - Pump - Corolla :: Service Engine Light Came On / Water Pump Replacement
My daughter has a 2004 Toyota Corolla and the "service engine" light came on. The diagnosis was that the water pump needed to be replaced.
View 1 RepliesSonata NF (2006-10) :: V6 Water Pump Replacement?
I am trying to replace a water pump on a 2006 Hyundai Sonata, 3.3L, V6. But I hit a snag. I have removed the drivebelt but I can't get the water pump pulley off due to clearance. The water pump pulley is hitting the engine mounting bracket. All the manuals said I could remove the water pump pulley and the water pump and made no mention of removing the engine mounting brackets. I was wondering if there was a way to remove the water pump pulley, and the water pump, without dropping the engine and removing the engine mounts? If I do have to remove the engine mounts, do I need to remove the mounting brackets on both sides?
View 13 RepliesPark Avenue :: 1992 - Water Pump Replacement
92 PA Base ... Attempting to replace water pump. Is a hydraulic jack required to hold up the engine when removing the engine mount? The engine mount (passenger side front) is covering the right portion of the water pump. Although the engine mount has two holes for the remainder bolts of the water pump, there's no room to fit a ratchet or anything to remove the remaining two bolts. It appears the mount must be removed to replace the water pump. Is this so? How to correctly remove the engine mount.
View 1 RepliesGolf IV R32 :: Water Pump / Timing Chains Need Replacement?
My car just hit 70k miles, I have had no problems with my car since 28,700 miles. I kinda drive it like an old man I know I know I should be ashamed of myself lol. When do you find most 04 .:R's Waterpump/timing chains needing replacement? Just curious if I need to factor this into my budget.
View 7 RepliesRodeo :: 1995 - Overheating After Water Pump Replacement
1995 Isuzu Rodeo. Replaced water pump, thermostat, timing belt & components. Now it over heats & no heat in cab. I was told to "burp" the cooling system but can't find the bleed valve. Is there even one on the V6 engine???
View 3 RepliesAlero :: 2.4L - Large Puddle Of Antifreeze Under The Car / Water Pump Replacement?
1999 Olds Alero with 2.4 L engine...
Everyday when I back out of my parking spot, there is a large puddle of antifreeze under the car, mid point near the firewall. I have to add 1 liter of antifreeze a week/100 kms. I am thinking it is a "low pressure" leak, cause when it is running, there is no major spray noticeable. Weird. So I have done some reading and can only guess that it is my water pump that is shot.
After getting the estimate from the local garage of $ 700.00 (mostly labour) for a $ 100.00 water pump, I am going to tackle this one myself. Can't believe Oldsmobile did just a crazy thing like hiding the water pump so deep into the caverns on a 2.4L.
I am not overly concerned with this bigger puzzle, but want to be sure before I get it all apart and tie up the prime spot in the garage called the "wife's parking spot". Got to get it in and out quick. Will I need any specialty tools, for things like removing the timing gears or anything else that is goofy on this repair job.
Passat (B6) :: 2006 2.0t - Timing Belt And Water Pump Replacement?
How to change the timing belt and water pump on a 2006 2.0t passat?
View 3 RepliesPickup - Nissan :: Air Trap In Coolant After Water Pump Replacement
Have air trap in coolant after water pump replace.cannot get it out. Do I need to drain coolant again and start over. 1997 nissan pickup 2.4 liter.
View 3 RepliesElantra XD (2001-06) :: 2002 GT Not Starting After Water Pump Replacement
Just finished installing a new water pump on my 2002 Elantra GT when...
I went to start it, and it started for half a second and died. Further attempts to start were strained.
The battery is showing 12.58 volts on the multimeter so this was likely not the cause. I checked the fuses under the hood which all looked good. I don't know if it could be a relay or anything else electrical.
Other than the electrical side, there are two things I can think of that may be the cause.
First, being in a hurry to finish(which is probably the biggest mistake of all) I reconnected the battery too soon and wound up connecting the ground(I thought) wire to the alternator for a second causing an arc. I immediately removed the wire and followed proper procedures to reinstall it.
The only other thing I can think of is that one of the water pump bolts required removal of the idler pulley. The idler pulley demands the loosening of the timing belt tensioner in order to be reinstalled. Before removing anything I marked the position of the timing belt on the camshaft sprocket as well as the crankshaft sprocket so I'm really hoping I haven't lost timing.
Could it be something electrical? Did I over-tighten a belt or pulley? Is it timing?
Caravan/Voyager :: 2006 - Engine Light Is On After Water Pump Replacement
I had to replace the water pump on my dodge Grand Caravan, which was challenging, but I got it done. But now the engine light is on.... why would that happen? I did take off the filter hose, and unplugged the cord to move the air filter housing, but I plugged it back in when i re-hooked everything up. So now I am nervous that i did something wrong. Why the engine light would come on and stay on? water pump works, put coolant in etc.... no leaks.... so now i just need to figure out the engine light.
View 9 RepliesToyota - Camry :: 2006 - Water Pump And Serpentine Belt Replacement
Is it possible to change the water pump and serpentine belt in a 2006 Toyota Camry with 4 cyl. engine in less than an hour?
View 4 RepliesAudi - A4 :: 2002 - Still Overheat After Replacement Of Water Pump / Thermostat And Timing Belt?
I have a 2002 Audi A4 1.8T with 85,000 miles. Recently my car started overheating, I replaced the water pump, thermostat, and timing belt. The mechanic also ran tests to make sure there were no issues with the head gasket, those tests came back saying the head gasket was a-ok. Yet, my car is still overheating but only on days when the outside temperature creeps above 90 and I am in stop and go traffic. I have to re-fill the coolant tank about once a week depending on how much I drive. I find no coolant puddles under my car when it is parked, so I do not believe it is leaking. What else could be causing my car to overheat?
View 2 RepliesDodge - Intrepid :: 2002 - Overheating After Replacement Of Timing Belt / Water Pump?
I have a 2002 Intrepid ES with a 3.5L V-6 with 264,000 miles on it. I have recently had the timing belt and water pump changed. Three weeks later I am driving home and the temperature gauge starts climbing. This is the first time this car has ever overheated. Well, I call my buddy who is a certified mechanic and he tows the car to his shop. I have him check the water pump to make sure it hasn't prematurely failed. He tears the front of the engine down and inspects the pump. He finds nothing wrong with the pump but he discovers the timing belt tensioner has failed and it has caused the engine to jump time, I tell him to go ahead and replace the tensioner.
After he put the engine back together he started it and it ran cool while it was sitting at idle for about 45 minutes. Then he took it for a test drive and it overheated again. He checks the thermostat and finds that it has also failed; he replaces that also, still overheating. New radiator hoses, upper and lower, new radiator, new thermostat, new water pump and it still overheats. He put dye into the coolant to check for a blown head gasket and it tested negative for a blown gasket. The exhaust doesn’t smell of burning coolant or producing white smoke. My mechanic friend and I both have run out of solutions…
Toyota - 4runner :: 2005 - Need Replacement Of Timing Case / Oil Gasket / Water Pump?
We have a 2005 4runner with 75,000 miles that we recently took to the dealer because the coolant level was low. Turns out we need a new timing case cover, oil gasket, and water pump.Question 1 - is this normal to happen on a 2005 4runner with 75,000Question 2 - How much is a reasonable amount to pay for this repair? Evidently, it is a laborious repair.
View 4 Replies