Prius (Gen 2) :: DC Charger To Test Battery Cells?
I found a decent deal on a 2nd gen prius. But I am going to need to repair the battery. I have already known that I can test and only repair the needed cells (since I looked into the situation when I was buying mine a year ago). Looking at the forums and saw there were a couple of chargers being recommended by the users; such as the supermate DC6 or the Hitec 44151 Quad X4.
I will likely want to charge 8 cells at time at least, as I would ideally like to get the car fixed in a couple of weeks.
Prius (Gen 2) :: Check Engine Light Came On - Two Cells In Hybrid Battery Dead
My check engine light came on, I took the car to my usual mechanic, and he said the codes returned indicated that two cells in the batter were bad. (I just called to get the codes, but he's out of the office for about 30 minutes on a test drive...)
View 8 RepliesPrius (2004-09) :: Replaced Dead Cells On HV Battery - Code P0A80
Have replaced dead cells on wife's HV battery over a month ago. Threw this P0a80 code today and will barely move. She idles into dealership and they say it's the battery, really!
View 2 RepliesPrius (2004-09) :: 2007 - Red Triangle Shows Up - Hybrid Battery Cells Overheats?
I have a 2007 Prius and the red triangle showed up. It has less than 50,000 miles. I noticed that almost right after I start it up the hybrid battery fan kicks on. This leads me to believe that maybe one or more cells in the hybrid battery are overheating due to charging problems. Is there a way I can check this out without going to the dealer?
View 3 RepliesPrius (2004-09) :: Just Replaced 2 Bad Battery Cells / All Dash Lights On And Engine Won't Start
Tested and replaced 2 bad battery cells in my 2007 Prius... Got everything put back together and now all dash lights are on and engine won't start... When i try to shift into drive or reverse it goes directly into park... I tested the battery without removing the safety key and the inside terminals are at 220 volts and the outside terminals are at 0 volts as shown by photo... Maybe due to a fuse somewhere?
View 19 RepliesLexus IS 2014+ :: OEM Battery Leaking From One Of The Cells
It was one of the most difficult battery swaps I've ever done...
I chose the Odyssey extreme battery. Purchased from Amazon.
The point of this post is that the OEM battery was leaking from one of the cells... Seems poorly made...
Perhaps this is why some owners are having dead battery issues...
Prius (Gen 2) :: After Replacement 12V Battery Is Not Charging
I just got a 2004, it did have a bad 12V battery which I did replace, still not charging.But First it is making a loud noise under the hood sounds like towards the right side.when I accelerate starts at 18 to 20 miles per hour. Tried sitting still with car in gear and pushing accelerator can not get it to make the noise that way, without the wheels rotating.
View 17 RepliesPrius (Gen 1) :: Manually Charging HV / Traction Battery?
I don't own a Prius, but my parents own two identical 2002 models (each with 120k miles).
My mother's car wasn't driven for nearly a month (hip replacement), and when they tried to start it last week, the ready light would blink 3 times - but no cranking.
After taking it to the dealer, they were quoted $4600 to replace the traction battery and ECU. We did the mandatory research on rebuilt batteries, but with only a vague diagnosis from the dealer, we were not convinced that this was the (only) problem.
So, my brother and I decided to swap the ECU, then the battery from my father's working Prius to my mother's - thereby proving the issue. Upon removing the 'dead' battery from mother's car, I decided to open the module, and check each battery. We measured anywhere from 3.0 to 6.4V on the individual cells - and 7.0V to 11V on the paired cells. It was clear that the batteries had discharged unevenly. The total charge remaining was about 151V - still above the 40% SOC minimum I'd read about.
We then bought 5 x 10A chargers from Walmart, and connected each to a pair of modules. Set the charge to rapid (10A) and waited 30 minutes (or until the charger indicated full). After 2 hours, all 19 pair were charged fully - with each reporting 15.7V +/- 0.5V. The total power was about 295V.
We reassembled the battery, re-installed it, and the car started immediately. We let it sit running, until it cycled off on its own. About 5 min later, the ICE fired again to charge the 12V battery - but it threw a P3006 error code. It showed a PS + MAIN + battery icon on the MFD. Using an OBDII scan tool, we cleared the error, and drove the car for a few miles. The error code did not return during that drive - but did one more time after letting it cycle off/on automatically. After clearing the code a second time, it never repeated again.
My assumption is that the 300V HV charge was above the 80% SOC and it didn't like that. But after a few cranking cycles, and the tendency for the battery to discharge back to it's rated output, the error no longer repeated.
Prius (Gen 2) :: 2009 - Battery Not Charging / Mileage Low
Have a 2009 with 25K on it, purchased in April when they were practically giving them away. Recently did an oil change and got snow tires, then left my husband in car with heat on for 20+ minutes, and now mileage is in the 30's and the battery isn't charging itself or regenerating. What could be going on?
View 6 RepliesPrius (Gen 2) :: 2004 - MFD Not Showing Battery Charging
I have got Prius 2004. I have got a problem. With MFD. It's showing the screen where it should show that the battery is charging but it's not showing the charging at all. Car is running fine and starts as normal. I have changed the 12V battery but it's still not showing the charging.
View 6 RepliesPrius (Gen 2) :: Battery Only Charging Downhill And Braking
Right now my husband and I are driving from San Luis Obispo Ca to LA and back in a day. We noticed right before the grape vine on the I5 that the engine was really working, even on flat ground. Looked at the battery and it was purple. We have been driving for about 2 hours averaging about 70mph on mostly flat land. The battery finally charged itself on the big downhill of the grapevine (I5) but we're noticing we're running right through it again unless we start to break more. So, it's not getting any recharge during driving, just breaking. Can it be the generator? What causes this?
View 5 RepliesPrius (2004-09) :: Engine On But Battery Not Charging?
Recently we went on trip requiring a 3 hour ferry ride. Decided to keep it in READY to listen to the stereo and maintain a minimal level of heat. I noticed the engine kicking on and no arrows from or to anywhere. The HV battery gauge was mostly down to 2-3 bars but still no arrows. There were times that it kicked on and the arrows showed the batteries being charged too. Was the engine kicking on without charging just to maintain the engine coolant temp to provide heat for the cabin, or what?
View 4 RepliesPrius C :: Arrow Going To Charging Battery Nearly All The Time?
Meant to post this for a while but on both the Prii C's I have owned, I mostly only see the arrow on the HSI going towards the battery and not the other way to assist the engine. My wife watched it while I drove the last 2 days and it never went to the engine except when driving in EV.
On my regular size Prius I had, I saw it going to the engine way more than the C,
Prius (2004-09) Fuel :: Engine Keep Running But No Charging / Driving?
why the engine keep running but no charging and no driving? the car was down hill, the battery was fully charged (green), I did not accelerate ( my foot was not on the paddle), but the engine sometimes keep running with a very low gas consumption. this become more often in winter, even when car stopped. I would like to know is this normal for Prius or there is any I can do to improve this?
View 11 RepliesPrius (Gen 1) :: Input Vol Error Appears When Charging Battery
I was wondering how I would charge my gen 1 battery cells and balance them with my IMAX b6 lipro battery charger. Every time I try to charge it or hook it up the thing keeps saying "input vol error". Now I don't know if that means I need a different ac adapter since I'm now using a 19.5 v laptop charger and most of the time they use a 12v ac adapter.
Most of the cells have a reading under 6v but we have 38 new cells coming in today. How we can balance them with this charger because I know it has a balance charge setting for the lithium batteries. That has a separate plug though. Should we just put the cells closest to their voltages and have them balanced that way?
Prius (Gen 1) :: Error Code P3001 - 12V Battery Not Charging
My 01 Prius is not charging the 12V battery and I have error code P3001. Everyone on here said P3001 is the HV battery ECU. (which I replaced with one from the Junk Yard and still get the error code)
I charged the 12V battery over night and Autozone says that its ok. They tested it with a little machine. The only other thing I can think of is that the Inverter DC-DC converter part is bad. How I can test that? (is there a way other than replace the inverter?)
Prius (2010-12) :: Charging A Dead 12 Volt Battery
My dad's Gen III has been sitting garaged for almost a year now, and of course the 12 volt battery is dead. Firstly, it's sitting in a one car garage, and secondly I have a Gen II so a straight jump isn't possible. I have a trickle charger that should be able to bring the 12 volt back up in 15-19 hours, but here's my question:
Maybe I'm being lazy, but I'd rather not deal with climbing in the back to release the hatch and running an extension cord so I can get the charger close enough to hook straight up to the battery..
Prius (2004-09) :: Mild Jerking When ICE Charging The Battery
I have an 05 prius with 108k miles that I bought about 3 months ago. I had noticed some times during phase 1 warm up where prius is in park and ice is charging the battery there will be mildly violent jerking of the car.
I was messing around the other morning, after driving the car about 30 minutes then letting it sit for about an hour in 40 degree f weather. I readied the car and it started charging the battery. While still in park i pressed the gas pedal to see what would happen. The mfd showed no arrows which I assume is normal. But when I let off the gas pedal there was a abrupt jerking as the mfd showed power flowing from the ice to the battery again.
Experienced jerkiness while in phase 1? After phase 1 is complete I do not notice any more of this behavior.
Prius (2004-09) :: Fan Kicked On And Battery Not Charging Warning
First a little background on the car , it has 217,000 miles. The battery was just replaced with a used one. While taking it through the carwash, she put it in neutral and a minute or two later she got a warning that the battery was not charging and to put it in gear. Sounds like the battery is having issues to me. She has a 60-day warranty.
View 10 Replies