Prius (Gen 1) :: Input Vol Error Appears When Charging Battery
I was wondering how I would charge my gen 1 battery cells and balance them with my IMAX b6 lipro battery charger. Every time I try to charge it or hook it up the thing keeps saying "input vol error". Now I don't know if that means I need a different ac adapter since I'm now using a 19.5 v laptop charger and most of the time they use a 12v ac adapter.
Most of the cells have a reading under 6v but we have 38 new cells coming in today. How we can balance them with this charger because I know it has a balance charge setting for the lithium batteries. That has a separate plug though. Should we just put the cells closest to their voltages and have them balanced that way?
Prius (2001-03) :: Got Error Codes P3001 / P3009 / P3000 / P3004 / P3140
I need assitance on the following diagnostic report. My prius shows:-
1. Red triangle with exclamation mark,
2. On the LCD red car with exclamation mark,
3. ABS sign - on and off.
Prius (Gen 1) :: 2001 - Keep Getting Code P3001 With All The Lights / ECU Failure
I have a 2001 prius that I bought from a garage . To get to the point, it had a dead battery pack so I put a good used one in. It will start and run but I keep getting code p3001 which indicates a bad battery ecu. I replaced the battery ecu to the original one that was in the car ,but I still keep getting the code along with all the lights. I did some looking and was told to replace the HV. ecu which I also replaced ,but it did not solve anything. I unplugged a harness while it was running and than got code p3100 which indicates HV. ecu failure.. So I am not sure what is going on ,talked to toyota tech and he said it does not need to be reprogrammed ,but you have to buy a new one as the vin # in the ecu will not match up..
View 19 RepliesPrius (Gen 2) :: Fan Not Working / Battery Overheating - Error Code POA85
VSC, ABS triangle warning! Error code POA85 ... We took the car apart and basically found the error with the fan it's not working. When you connect the battery to the fan it's working perfectly. The fan motor resistor is overheating is this the problem? Or should it be very hot.
View 4 RepliesPrius (Gen 2) :: After Replacement 12V Battery Is Not Charging
I just got a 2004, it did have a bad 12V battery which I did replace, still not charging.But First it is making a loud noise under the hood sounds like towards the right side.when I accelerate starts at 18 to 20 miles per hour. Tried sitting still with car in gear and pushing accelerator can not get it to make the noise that way, without the wheels rotating.
View 17 RepliesPrius (Gen 1) :: Manually Charging HV / Traction Battery?
I don't own a Prius, but my parents own two identical 2002 models (each with 120k miles).
My mother's car wasn't driven for nearly a month (hip replacement), and when they tried to start it last week, the ready light would blink 3 times - but no cranking.
After taking it to the dealer, they were quoted $4600 to replace the traction battery and ECU. We did the mandatory research on rebuilt batteries, but with only a vague diagnosis from the dealer, we were not convinced that this was the (only) problem.
So, my brother and I decided to swap the ECU, then the battery from my father's working Prius to my mother's - thereby proving the issue. Upon removing the 'dead' battery from mother's car, I decided to open the module, and check each battery. We measured anywhere from 3.0 to 6.4V on the individual cells - and 7.0V to 11V on the paired cells. It was clear that the batteries had discharged unevenly. The total charge remaining was about 151V - still above the 40% SOC minimum I'd read about.
We then bought 5 x 10A chargers from Walmart, and connected each to a pair of modules. Set the charge to rapid (10A) and waited 30 minutes (or until the charger indicated full). After 2 hours, all 19 pair were charged fully - with each reporting 15.7V +/- 0.5V. The total power was about 295V.
We reassembled the battery, re-installed it, and the car started immediately. We let it sit running, until it cycled off on its own. About 5 min later, the ICE fired again to charge the 12V battery - but it threw a P3006 error code. It showed a PS + MAIN + battery icon on the MFD. Using an OBDII scan tool, we cleared the error, and drove the car for a few miles. The error code did not return during that drive - but did one more time after letting it cycle off/on automatically. After clearing the code a second time, it never repeated again.
My assumption is that the 300V HV charge was above the 80% SOC and it didn't like that. But after a few cranking cycles, and the tendency for the battery to discharge back to it's rated output, the error no longer repeated.
Prius (Gen 2) :: Charging Of Battery Cells By Running The Car Is Possible?
Is there anyway to charge a couple of batt cells by running the car.
Just replaced 2 packs and there voltage is 2-3 volts lower than the rest of the batt packs? the ones replaced are at 14.5 to 15 where the others are at 17-18 volts.
Prius (Gen 2) :: 2009 - Battery Not Charging / Mileage Low
Have a 2009 with 25K on it, purchased in April when they were practically giving them away. Recently did an oil change and got snow tires, then left my husband in car with heat on for 20+ minutes, and now mileage is in the 30's and the battery isn't charging itself or regenerating. What could be going on?
View 6 RepliesPrius (Gen 2) :: 2004 - MFD Not Showing Battery Charging
I have got Prius 2004. I have got a problem. With MFD. It's showing the screen where it should show that the battery is charging but it's not showing the charging at all. Car is running fine and starts as normal. I have changed the 12V battery but it's still not showing the charging.
View 6 RepliesPrius (Gen 2) :: Battery Only Charging Downhill And Braking
Right now my husband and I are driving from San Luis Obispo Ca to LA and back in a day. We noticed right before the grape vine on the I5 that the engine was really working, even on flat ground. Looked at the battery and it was purple. We have been driving for about 2 hours averaging about 70mph on mostly flat land. The battery finally charged itself on the big downhill of the grapevine (I5) but we're noticing we're running right through it again unless we start to break more. So, it's not getting any recharge during driving, just breaking. Can it be the generator? What causes this?
View 5 RepliesPrius (2004-09) :: Engine On But Battery Not Charging?
Recently we went on trip requiring a 3 hour ferry ride. Decided to keep it in READY to listen to the stereo and maintain a minimal level of heat. I noticed the engine kicking on and no arrows from or to anywhere. The HV battery gauge was mostly down to 2-3 bars but still no arrows. There were times that it kicked on and the arrows showed the batteries being charged too. Was the engine kicking on without charging just to maintain the engine coolant temp to provide heat for the cabin, or what?
View 4 RepliesPrius C :: Arrow Going To Charging Battery Nearly All The Time?
Meant to post this for a while but on both the Prii C's I have owned, I mostly only see the arrow on the HSI going towards the battery and not the other way to assist the engine. My wife watched it while I drove the last 2 days and it never went to the engine except when driving in EV.
On my regular size Prius I had, I saw it going to the engine way more than the C,
Prius (2010-12) :: Charging A Dead 12 Volt Battery
My dad's Gen III has been sitting garaged for almost a year now, and of course the 12 volt battery is dead. Firstly, it's sitting in a one car garage, and secondly I have a Gen II so a straight jump isn't possible. I have a trickle charger that should be able to bring the 12 volt back up in 15-19 hours, but here's my question:
Maybe I'm being lazy, but I'd rather not deal with climbing in the back to release the hatch and running an extension cord so I can get the charger close enough to hook straight up to the battery..
Prius (2004-09) :: Mild Jerking When ICE Charging The Battery
I have an 05 prius with 108k miles that I bought about 3 months ago. I had noticed some times during phase 1 warm up where prius is in park and ice is charging the battery there will be mildly violent jerking of the car.
I was messing around the other morning, after driving the car about 30 minutes then letting it sit for about an hour in 40 degree f weather. I readied the car and it started charging the battery. While still in park i pressed the gas pedal to see what would happen. The mfd showed no arrows which I assume is normal. But when I let off the gas pedal there was a abrupt jerking as the mfd showed power flowing from the ice to the battery again.
Experienced jerkiness while in phase 1? After phase 1 is complete I do not notice any more of this behavior.
Prius (2004-09) :: Fan Kicked On And Battery Not Charging Warning
First a little background on the car , it has 217,000 miles. The battery was just replaced with a used one. While taking it through the carwash, she put it in neutral and a minute or two later she got a warning that the battery was not charging and to put it in gear. Sounds like the battery is having issues to me. She has a 60-day warranty.
View 10 RepliesPrius C :: 2012 - Does Battery Need Charging After Several Days Of Not Driving
I just bought a 2012 Prius c. There are oftentimes when I don't drive my car for a few days. When this happens, I have heard that the car might not start, especially in the winter. Is this true?
View 7 RepliesPrius (2010-12) :: Disable HV Battery Charging Or Regeneration?
2010 gen III bought Aug 2009.
Would it be possible to disable HV battery charging or regeneration (with torque pro regen coop)? This way I could use battery and ICE power when going up a long mountainous area, and end up with 30% charge at the top instead of 60%. Then on the way down I could use regen to build back up the battery.
Prius Plug-in 2012-15 :: Still Charging When Battery Was Full?
My wife plugged in to the EV charging station at work for the first time today. She was supposed to receive an email when the charge finished but wasn't notified because there was a still a trickle charge being registered by the EV station even though the battery was full.
View 13 RepliesPrius (2004-09) :: 2005 - 12v Battery Not Charging While Driving
195k miles.... I have charged the battery, I have bought a new battery, I have Charged the new battery... All with no avail.. Slowly but surely one at a time the abs trac control and stability control lights come on and eventually the triangle of death... Meaning when I shut it off its not going to restart.. If i drive it sparingly it might take a week if i drive it all day then it takes one day... when fully charged there is no warning or sign that there is a battery issue or draining untill the voltage is starting to get low. I have an ultra gauge hooked up and shows 14.14 while driving, I am lost as to whats the issue. also no codes or pending codes... I have taken the new battery to auto zone and had a functional test done.. said checked good... signed befuddled
View 19 Replies