Prius (2004-09) :: 2009 - Braking Not Working Properly
I have a 2009 Prius base model, and I've been having two different brake problems.
View 8 RepliesPrius (2010-12) :: Brake Fluid Leaking From Rear Driver Caliper
I have a leak from the rear driver caliper, it seems to come from behind the bolts that hold the emergency brake to the caliper (I had my wife push the pedal repeatedly so I could find the issue). I haven't been able to remove the retaining bolts (the allen head bolt doesn't want to play) to see what the issue might be.
View 18 RepliesPrius (2004-09) :: Extra Brake Pedal Travel Before Engaging Properly
I have a gen II Prius 2007 with 115,000 miles on it ...
When I use my brakes at low speeds under 15 mph, there is a bit of extra brake travel before they engage properly ...
Golf IV R32 :: Rear Caliper Seized When Disengage Emergency Brake
My caliper gets seized when I disengage the emergency brake.
View 8 RepliesFord Excursion :: Rear Brake Caliper Line Installation?
Routine maintenance gone wrong.
Installing rear brake line and failed to put on the rear washer and stripped out the bolt hole mostly. Will still unscrew and screw back in but not enough to stop a slow drip. Is there an easy repair or time for a new caliper? Thread tape is not brake fluid resistent.
If no repair, what brand should I go with? Are they all similar or MC better? Can get Fenco for $50 and MC for $100. A1 Cardone and ACD for about $75.
Camry :: 2014 SE - Rear Passenger Side Brake Caliper Frozen Open
So, my right, rear, brake caliper froze in the open position a little while back; I hit the brake hard, it held, heard a clack, then it let go and stayed in the open (uncompressed) position. I lost some braking power but at least have been able to drive. No visible brake fluid leak, other three brakes working fine.
At 125K, I've decided to do a full brake job, and am about to search for some of the parts on the awesome stickied parts reference list up above. I'll hopefully find some parts are available at NAPA, where I'm also ordering the right side cv axle.
So, I'm only finding remanufactured brake calipers at NAPA. Are they decent or should I look for something new elsewhere?
Ford Super Duty (1999-2016) :: Rear Brake Caliper Locked Up?
About a year ago, I had my right rear brake caliper lock up on my F350 dually. The shop said it can happen and replaced both rear calipers. Last week I started to hear something from the rear and within less than a a few days, before I could get to a shop the noise increased and when I looked the rotor had been gouged on the right rear.
I cannot see the left rear rotor to compare as the wheels don't line up on that side to see through. So my question is this. Could it be the caliper failure was a symptom and not the cause. Maybe a proportion valve or something that could affect the pressure on that one wheel.
Santa FE SM (2001-06) :: 2003 - Rear Driver Side Brake Caliper Stuck Roughly
This is my second time posting for the same issue on a 2003 3.5L with 120,000+ miles. Rear driver side brake caliper is stuck again. I have replaced both rear calipers after the driver side stuck a few months back. So most likely the first time was caused by something else.
What else could be causing this? Brake line, master cylinder, or other? I did not replace any brake lines the last time this happened. Just calipers and pads.
Prius (2004-09) :: Brake And ABS Warning Lights On / Braking Rough
I have a 2009 Prius with 73,000.I turned on my Prius after a quick stop at a drug store today to find my brake light and ABS warning lights on. In addition, braking was rough. I have to step on the brake much soon and "deeper" to stop. After a quick search of the net I learned I wasn't alone. Here are the codes I received-
C1241- I just replaced my 12v battery about 1 1/2 years ago so I'm confused about 1241. I checked the levels. The are normal. The battery showed levels of 14 to 14.1v throughout the test. Maybe I don't understand the code?
C1247- Stroke Sensor
C1377- Capacitor malfunction
Before I take my car to Toyota, I would like your opinion on what actually works to correct the problem. I cleared the codes and the car works fine right now. If I continue to clear the codes will the car work? I searched the forum the one person seems to believe the to repair replacing Stroke sensor is the best/only fix.
Prius (2004-09) :: Squeaking Rear And Inside When Braking
Today I started noticing a squeaking sound coming from the brake pedal when braking slowly. After I put the car in park and inspected any noises from the outside, I realized that a squeaking noise was also coming from the rear brake drums of the car. It was perfectly find yesterday and this morning it started.
View 3 RepliesFord Super Duty (1999-2016) :: Replaced 5th Time Rear Brake Caliper And Slider?
one of my f350 super duties has had the right rear brake caliper and slider replaced 4 times in less than a year. it has just gone for the fourth time today. i called ford who, after a long phone call, said it could be the metering valve. i have looked everywhere for this valve.....no luck. so i called them back and he said it was part of the HCU. after a few minutes, he finally told me it was also called the ABS module.
my question is..........can i just replace this metering valve or do i have to replace the whole unit?
Prius (Gen 2) :: Brake Caliper Replaced Now Won't Go Into Gear
My wife was complaining about a metallic scraping noise that was coming from the driver side front wheel. I listened to it and couldn't determine what it was or see any evidence of something loose. I took off the wheel and had a look at the components and after 160K miles, it looked like the pads could use replacing. It didn't seem like that was the root of the sound, but it looked like they needed to be done.
I got the parts for both sides and replaced the left without issue, but when I got to the right side, I found the source of the noise: a pebble between the rotor and dust shield. I continued on with the brake replacement and the caliper piston was stuck. Tried a couple of things to free it and blew out the piston.
Prius (2004-09) :: 2005 - Right-rear Tire Locks And Skids During Braking?
I bought a used 2005 Prius in early February, and have driven about 7,000 miles so far.
Yesterday, I noticed an issue with the braking. When the traditional brakes (non-regenerative) kick in when approaching a full-stop the right-rear tire completely locks up, and skids. The weather has been wet the past two days, but the issue is severe enough that the resulting vibrations feel like they may tear the car apart.
There are no warning lights aside from the skid light, so I assume there'll be no code for a mechanic to easily identify this problem. I'm worried if it's not easy to pin down, this may be a huge expense, and if so, I'll have to hold off awhile, and find some other mode of transportation.
Lexus GX 2004-09 :: Front Brake Caliper Bolts Frozen
Started to change front pads and rotors on my GX470, but couldn't get the caliper bolts loose. Is it safe to use a torch to heat up the area around the bolts so I can loosen the bolts? Any other way to break these bolts free?
View 12 RepliesElantra XD (2001-06) :: 2004 - Resetting Brake Caliper Pistons?
I need to do a brake job on the front of my 04 Elantra, how to reset the caliper piston. I've tried the traditional c-clamp method but can't get the clamp to grip well on the non-pad side because of the caliper shape.
View 4 RepliesFord F-150 (2004-2008) :: No Brakes After Caliper / Brake Pad Change
After a routine brake pad replacement the brake pedal hits the floor when applied with normal force. The pedal feels like a badly leaking master cylinder, but prior to the pad replacement the brake pedal was firm as a rock with no drop at all. If I pump the brakes the pedal will come up to normal height, but if I then maintain light pressure the pedal will again sink to the floor.
1. Truck was braking fine, however pad 3/4 worn
2. Replaced front calipers, rotors and pads
3. Replaced front brake feed hoses
4. Replaced rear pads
5. Started engine
6. Started bleeding from furthest point from MC a) passenger rear, b) Driver Rear, c) passenger front, d)driver front. Did it two times...
Still, brake travels all the way to the fire wall and never develops tension. Moreover, sometimes, when person pumping brake puts pressure and i open bleed, no fluid comes out. Could it be a failed master cylinder??? I tend to think it's not because 24hrs ago, the pedal felt fine and the truck was braking ok.... So much for preventive maintenance.
Prius (Gen 2) :: Pistons In Driver Side Front Brake Caliper Is Sticking
One of the pistons in my driver side (UK) front brake caliper is sticking, so I've bought a second hand caliper just to fix the problem until I come to sell my pri in a month or so.
View 15 RepliesToyota - Highlander :: 2004 - Front Driver Side Brake Caliper Seized?
My 2004 Toyota Highlander with 84K miles has been diagnosed with a seized front driver side brake caliper with worn brake pad (1/32). I had recall work done a few days ago at the dealership and this was discovered afterward during the "complimentary" multi-point check-up. - You know, the long laundry list of recommended work they try to sell you on. Of course the brake work is actually necessary.
Since the vehicle was just inspected 2 months ago at our local shop, my husband suggested I take it back there to verify the diagnosis and see what that mechanic would recommend. That mechanic confirmed and showed me the seized caliper/worn pad, which, by the way, was functioning well in mid January at inspection, and measured 7/32. This mechanic recommends replacing both calipers, pads, turning rotors. There was no indication of a problem with the RF caliper, but he says it's just a good idea to replace it so we would avoid having another problem in the future.
I want to ask everyone's opinion regarding replacement of just the bad caliper vs. both. Are we getting ripped off as far as the estimate and is the flush necessary? Also, is this issue typical in the first place, and what causes a brake caliper to seize? We've had several other vehicles driven many more miles than my Highlander and never experienced a seized caliper.
Ford Excursion :: Stuck Caliper - Squealing After Braking?
I think I have a stuck/sticky caliper. I am getting some squealing while under way after braking. It will fade away after a little while, but it it's bad enough where a friend left a message saying he could hear me coming...
I am also getting a shudder when braking at certain speeds (from @ 20-30 mph).
I replaced my front rotors @ 40k miles/4 yrs ago w/ PowerSlot Cryo's & Hawks LTS pads on all 4 wheels. I greased the pins at the time on the original calipers ('04 4wd 6.0 X w/ 105k miles now). The brakes have been great since, but the squealing/shudder started this spring.
Is it likely I need to replace the whole caliper, or can I get away with a pin kit? I want to order all the parts and be ready to do a weekend job.
Could the shudder be from the caliper, or is it likely i need to turn the front rotors? I'm planning to put new rear rotors on & new Hawk LTS pads all around again at the same time as dealing with the caliper. What rear rotors &/or calipers to get? I'd like to spend a bit less on the rear rotors vs the Powerslots.