Ford 6.7L Power Stroke Diesel :: Turbo Boost Will Jump To 10 PSI At Moderate Acceleration
I'm relatively new to the 6.7 engine , I have a 2014 F-350 SRW with aprox 51,000 miles on it. Normal driving I see about 8 to 10 psi of boost even under moderate acceleration although at times it will go to about 18 psi at WOT and it does this with heavy loads. At moderate acceleration the boost will jump to 10 psi quickly but immediately stop there and sometimes as the RPM"s increase boost pressure decreases. Only issues I have had with the truck was a clogged EGR cooler.
View 2 RepliesPassat (B5) :: Car Seems Surging On And Off Boost After Got Hit
[URL]...........................................................
My wife hit a deer going 60MPH 3 hours from home. Go back up and pick up the car, it's down on power, I feel it surging on and off boost, hard to drive smooth. Roughly a half hour later I get a CEL. Don't have the code handy, but Boost limit Maximum exceeded. My local VW dealer says its a normal wear and tear item so Allstate will not cover it. The car had the radiator, radiator support, condenser, hood, bumper, grill, passenger fender, timing belt cover and timing belt replaced.
Allstate says not covered, like a flat tire, once I leave the shop, its like a flat tire on the road, nothing to do with the repair. BTW I had it repaired at an Allstate recommended PRO shop. I get it back tonight after 8 weeks of fooling around. Will need to check the actuator, hopefully it's bad. The turbo itself is good, boost fine, no smoke.
This is an 04 Passat 1.8T. I have had 14 cars with turbos, still have four and have never had a turbo go bad, full synthetic oil every 3K and 60 second cool down in hot weather.
Passat (B5) :: MBC / Limp Mode / Surging In 4th And 5th Gear Under Boost
I have a 2004 1.8T AWM auto tranny Passat with APR chip. CIA, Bolt down Coil Packs, Bosch F6DTC plugs, OEM cat to straight pipe to magnaflow muffler, N75J, Forge DV (not the 007).
I installed a MBC bypassing the N75 to keep the spike at 16psi and hold (the n75J i spike at 22psi and hold 12~14), When I did that, the car will go in limp mode from 'over boosting'. I have to turn the MBC down to 9 to keep the car limping out. I love the way the MBC have the boost curve (the N75 is too passive for me). would like to fix this issue.
Also, with the N75 and or MBC, while in the APR 93 oct chip mode, I always get surging in 4th and 5th gear. Any time the boost is over 10psi, it is like I have tons of boost, but the engine is not using it. APR said it is the tranny, the tranny shop said it is the engine or computer, the engine shop said it is the tuning.
Passat (B5) :: 1999 Turbo 1.8t / Extremely Low Boost
My passat turbo went out a while back and cant figure out why? The Idle is the same as always was, engine is smooth while driving and changing gears, but the boost is very very low but not completely out. All vaccum lines are connected and cant hear the diaphram releasing like it used to abviously cause there's no pressure.
View 2 RepliesPassat (B7) :: 2013 - Found Code P0299 For Turbo Power Under Boost
Sudden power loss experienced. CEL (Check Engine Light came on) and Glow Plug Light was flashing. Power loss is severe so really can't drive it anywhere. Turbo Failed at 5500 miles.
Mechanic quote: "Found code P0299 for turbo power under boost. Removed upper engine cover and intake hose. Checked turbo shaft and found play near intake side of turbo. Removed lower engine shield and lower hose to intercooler. Checked for metal. Contacted VW and created VTA. Instructed by VW to replace turbo. Did."
Sounds like service manager abbreviated when entering into the computer. In any case a shame that this car was in the shop for more than a week while the dilly dallied and waited for a turbo to be shipped in.
Some earlier turbo-fail threads from last summer stated dealer told them "bad batch" of turbos was being experienced by VW. Believable, particularly if they're banged out in China? Let's all hope it was a bad batch.
Passat (B5) :: How To Install Boost Gauge
I have a 2001.5 Passat with a TIP and an upsolute chip. I was wondering if there are any write ups with pictures on how to install a boost gauge. I'm having trouble finding where to put one as well as where to T off and get pressure from.
View 6 RepliesPassat (B6) :: Boost Gauge Fluctuating And Does Not Hold
When I give my car some gas my boost gauge fluctuates a lot and doesn't hold, I have an OEM piston style dv revision d I believe, and I have a catch can and also a blow off valve, and I'm stage 2. I was thinking of getting an awe diverter valve?
View 13 RepliesPassat (B5) :: 1999 - Manifold To The DV Is Cut - Boost Gauge?
I just purchased a b5 99 1.8t. The tubing from the intake manifold to the dv was cut by accident (long story, dont ask).I replaced the dv and tubing .I want to check if the psi is correct. I dont have a boost gauge.
What are the ways to check it besides a boost gauge? I think the correct psi is around 6-8 ?
Passat (B5) :: 1997 - Boost Gauge Needle Is Jumping
I have a strange problem, my boost guage needle is jumping like crazy, there is no vacuum leak and the max boost i get is 0.5 bar, when the guage needle is not jumping I get a boost of 1.4 bar. I have mechanical boost control.
97' passat B5 1.8T AEB with FMIC,K04-15,2.75",chip (that was made for the original k03).
Passat (B6) :: Installation Of A Boost Gauge And Steering / Column Pod?
The installation of a boost gauge and steering or column pod? I'm looking at installing the Podi Gauge for the MK5 - but I understand it needs some modifications to make everything fit correctly?
I searched but couldn't find the exact answer I was looking for - besides a retrofit to the pod, is there some drilling / t-fittings required for the actual install of the gauge? As far as I understand, it's a bit more involved than plug and play?
Golf IV / Jetta IV :: Turbo / Engine HP Surging Occasionally
While I'm in the engine troubleshooting the AC system, I figured I may as well get into a few other issues I've noticed.
I have a stock 1.8T and my turbo feels like it's surging occasionally. A few months ago my diverter valve started making the "blow off sound" when I shifted (manual transmission).
Is it possible for a faulty diverter valve to dump the boost overboard and cause the turbo, and engine hp, to surge? It almost feels like I let my foot off the gas for a second or two (i.e., engine power is very peaky).
A second thing that comes to mind is a clogged fuel filter. I know VW does not recommend ever changing it so it's never been done. Is this a possibility as well?
Air filter is clean, by the way. There's a K&N washable one in the stock air box and I can see daylight through it so it's not too dirty.
GTI 337/20th Anniversary :: Rough Idle After Tune Up - RPM And Boost Meter Jump Down Then Up
I did a tune up on my 20th last week, plugs and coil packs and oil change. now i have a strange idle that it wasn't doing before. i checked all the plugs over again and they are gapped fine and i have no CE light on. Every now and then my RPM meter will jump down and then right back up, same with the boost meter at the same time. i had it looked at at the garage i go to and they said they cant seem to find anything wrong. What might be causing the rough idle? keep in mind this only started happening RIGHT after the tune up.
View 24 RepliesFord F-150 (2009-2014) :: Turbo Surging When Cruising Along And Just Slightly Give A Little More Gas
Occasionally, under the right conditions, my turbo seems to surge...meaning I can hear, and feel the turbo kick in and out...kinda like it is right on the threshhold of not knowing if it needs to kick in out not. This usually only happens when I'm cruising along and just slightly give it a little more gas. Otherwise it seems fine...plenty of power etc. What could be going on here...just the nature of the beast??
My truck is a 2011 F150 Eco Screw 4by....
Ford 6.7L Power Stroke Diesel :: Turbo Surging When Running In Cruise Only At 55 - 60 MPH
I was wondering about same turbo problems that I'm having? When running in cruze only at 55-60mph the turbo will surge from 2-12 psi up and down repeatedly. It sometimes will level out for a couple seconds and then continues to do it. I had it to the dealer and the service manager drove it and said it seems like it's searching for something, but since there was nothing from ford about it he couldn't do anything about it. There was an update for a prior serial number but my truck has the current software. What kind of damage is this going to do. It sucks because alot of my driving is at this speed.
View 14 RepliesVolvo :: 1987 / 740 Turbo Has No Power On Boost
It starts and idles fine and drives fine until the turbo spools and gets past atmospheric.. at this point the acceleration gets worse even though you can clearly hear the turbo blowing (gauge well into the yellow).. checked the ground connections on the head and intake, seemed good, replaced tps, replaced knock sensor, replaced hall sensor, tried another ecu, checked cam timing. Had a volvo mechanic friend looking at it prior to my fiddling with it and he seemed to think the ignition timing was retarded too much.. but I've done everything i can think of to tackle that problem.
View 3 RepliesGolf VI R :: No Turbo Boost - Weird Sound When Hit The Gas
I have a 2012 R with 85,000 miles, APR chip running 93 octane with a HPFP and VWR cold air intake. I was driving my car today (slow driving on highest) and all of a sudden I felt no turbo boost, and heard a weird sound whenever I hit the gas. Car moved but would not get above 3500 rpms and couldn't really get past 60 mph. Again, absolutely no boost (I have a boost gauge as well to verify).
About to drop off the car at a shop but had a couple questions:
1. If the turbo is blown, can I still drive the car to the shop (not too far) without damaging the engine itself?
2. if the turbos needs to be replaced, what are my options besides getting the stock turbo replaced, without getting some crazy setup? This is my daily driver and I don't want to spend money beyond what I need to get it fixed, but it there is a stronger more reliable turbo for about the same as a OEM, I would want to consider... Also price for OEM replacement??
3. Without the mechanic looking at it, I'm just assuming it's the turbo but what else could be the issue? All the lines looks intact and intake is fitted correctly. I did have issues with my cam follower getting damaged at 45,000 miles (there was a hole in it) and I have been replacing it every 20,000 miles since. Didn't have any issues for 40,000 additional miles, but could damage to that cause turbo failure?
Golf IV R32 :: Turbo - Misfire Under Boost / 1k RPM Idle (high)
Car started to do some weird stuff today. Misfiring under high load, as I get into boost.
Idle is around 1000-1100 RPMs. Cold start is fine, idle is normal in terms of going higher a bit, but then it sits at 1kish. This started last night after the car sat for a couple hours. Totally normal running and driving prior to this.
I've seen all the MKV threads about it that suggest everything from battery, to alternator, to grounds, to vacuum leaks, to intake leaks, to MAF.
Golf/GTI VI :: Boost Leak Between Exhaust Manifold And Turbo
I have a leak between the turbo and the exhaust manifold. The golden clamp (c-clamp? v-clamp?) broke, and now there is a gap between the two. The dealership doesnt cover it under powertrain warranty (my car has passed regular warranty) but worst of all they do not sell the clamp on its own.
I posted a link to a picture below, it isn't my turbo.
[URL] .....
Golf IV / Jetta IV :: Turbo Flutter Over 20 Pounds Of Boost
I have an 03 GTI 1.8t with the stock K03s turbo and i used to boost to 25 pounds. Had to put a new motor in and now i when i boost above 20 pounds i get turbo flutter and loose boost. I can boost anywhere up to 20 pounds and the turbo doesn't flutter at all.
I had a spring on my waste gate which i have taken off and it changed nothing. I tried a different diverter valve and it didn't change anything. I unplugged the MAF to see if the N75 or the there was a boost leak and extra air wasn't being monitored but still changed nothing. It has nothing to do with my RPM range just when i boost over 20 pounds. I am planning on doing a leak down test to make sure there isnt a boost leak....