Volvo :: Lost Metal Clip Connecting Fuel Line To Fuel Rail - What It Is Called
I have a 1994 volvo 850 turbo wagon. While replacing the pcv breather system, I dropped a little metal clip that attaches the fuel line to the fuel rail with a t25 torx screw. I can't find the clip. What the part is called or where it can be found?
View 1 RepliesFord 7.3L Power Stroke (1999-2003) :: Clogged Fuel Pick Ups In Tank
From diagnosis we are pretty sure we have clogged fuel pick ups in the tank of my 99 7.3 Dually. So in I go to clean and repair or replace depending on what it looks like once we get in there.
We have most of the fuel out of the tank, pumped out just over 30 gallons.
I don't have a lift so this is being done on the ground, any easier way ? The bed bolts look pretty rusty and funky but we have been spraying them down with Kroil, the magic elixir, for a couple days to see if that will ease the removal of the fasteners.
Take the Bed Off and work with the tank in the frame or drop the tank out and work away from the truck ?
Passat (B5) :: 2001 - Engine Light Is On / Lost Power
The light engine is on - I understand that the O2 sensor on bank one is gone, the car hesitates and I would like to understand what is wrong. Maybe other sensors or perhaps the turbo. The car has 62,000 miles. Will the car recup power by replacing the bad O2 sensor?
View 2 RepliesPassat (B6) :: Fuel Line Leak In Engine
As some may remember, I had a new engine put into my B6 about 2 weeks ago. Everything had been great since, no rattles, squeaks, or check engine lights, until tonight.
About half an hour after I get home from work, my wife heads out to a meeting. She opens the door to the garage and is about knocked over with the smell of fresh gas. NOT GOOD.
I tell her to get in her car and go, I grab the flashlight and pop the hood on the B6. Low and behold, the middle gas line of the 3 lines on the front right of the engine had come completely off! It was leaking gas everywhere and directly on to the alternator. On closer inspection, I notice that the tech. when he put in the new engine, he NEVER PUT THE 3 HOSE CLAMPS ON THE GAS LINES!
They were still on the hoses, just backed off from the ends a couple of inches. Needless to say I fixed the situation, but the Service Manager will be getting a call in the morning. This could have been a very very bad situation. I didn't smell any gas on the way home. I hate to think what could have happened.
Ford Fuel System :: Fuel Filter Is Clogged When Turn Over The Engine
Is it fair to assume that my filter is clogged when I turn over the engine and fuel does NOT come out of the filter with the uphill line disconnected. I was able to disconnect the rear line from filter and fuel DID pump out of line when I cranked it over. Been dealing with a crank no start, I'm in the process of trying to test my CPS properly but not sure if I'm testing it right.
2000 f 150 4.2 v6 232,000 miles....
Passat (B7) :: Turbo Failure - Glow Plug Light Blinking And Immediately Lost Significant Amount Of Power
I am new the forum but I wanted to get some information about the apparent turbo failure problem the 2012-2014 TDIs seem to be having. On other forums I have read numerous premature turbo failures. Also how long did it take to get the new parts and complete the repair. My car at this point will be in the shop for over a week. At the point when the car broke down I did not really know what was going on. The glow plug light was blinking and I immediately lost a significant amount of power. Do I need to worry about any internal engine damage from a blown turbo? I was able to get the car to the dealer at a very slow speed in a very short amount of time but this is my first diesel and first turbo so I could use some information.
View 14 RepliesFord 6.0L Power Stroke Diesel :: 2004 F250 - Sputters While Stopping Like No Fuel?
I have a'04 f-250 6.0L diesel truck. There are times when i come to a stop that my truck sputters like if it's about to run out of fuel or want to shut off but the tank is full or half. If i am going at a fast pace and then begin to slow down and stop it will sputter.
View 3 RepliesPassat (B5) :: Lost Of Mileage After Fuel Pump Replacement
I changed my fuel pump cause it died and now my mileage is about 100 less per tank? What could it be.
View 2 RepliesPassat (B6) :: Rough Idle When Stopping For Light?
So far I have only experienced this once (today). I was on the freeway which ends and becomes a State Route. When I stopped for a traffic light the idle became rough. I put the car in neutral and gave it a little gas and it seemed fine. It has not done that again at this time. No CEL or anything came on. What do you think?
View 6 RepliesFord 6.0L Power Stroke Diesel :: Lost Power Now Won't Start - Bad Fuel?
This is a new truck to me 03 Excursion, the owner has done a lot, gave me receipts for a lot of work and cosmetically it just seems taken care of. About a year ago hpop, ficm, oem egr and 3 injectors. He wasn't happy with that mechanic and still having problems so went to a different (supposedly better) shop. This time turbo cleaned, all 8 injectors and passenger head was redone and put back on with oem bolts. Apparently it was found that a nut was dropped down valve cover by the first shop! Somewhere along the way the ICP and GP module has been replaced.
I've only driven it a couple times and seems great until last night. It was loosing power and in about 10 seconds died and wouldn't start back up. Pops but doesn't stay running. WIF dash light on and no CEL codes. Not sure where to start/what to do. I've paid for most of it and was planning to pay the rest and transfer title but I'm not comfortable doing that till I'm confident it's good to go.
I drained the separator and seemed to gush out like it should and don't think I saw water. I'm planning to take the sensor off the filter there, inspect and clean it but I don't imagine that's the problem. I do see oil coming on the back of the engine and front of tranny on the drivers side... maybe ICP is all oily and failed? I don't know much about these, just been trying to read. What should I do as some first steps? Do I need some sort of scanner? It seems like it's starving for fuel. It was about 1/4 of fuel when I bought it and filled it up the night I took it home and have put about 80 miles on it since. Is it possible it's got bad fuel or water?
Ford 6.7L Power Stroke Diesel :: 2011 F250 - Spitting And Sputtering And Lost Power / Fuel Leak
We got "bad" gas in Feb, 2016, had to replace entire fuel system. Haven't driven the truck but 4000 miles. Last week, she started spitting and sputtering and lost power. We could see fuel pouring out. NO CEL. Towed (AAA has paid for itself several times over with this truck) to dealer that replaced the fuel system, still waiting to hear from them. Does this sound like it should be under the warranty for the work they did? We have averaged a huge repair bill about every 3-4 months on this truck, 2011 F250 Lariat, 8cyl, 6.7L, since we bought it 2 years ago.
View 1 RepliesAurora :: 95 - Lost All Power To The Fuel Pump And At Relay
My 95 aurora 4.0 lost all power to the fuel pump and at relay. what could be my problem. Is there a fuel shut off ?
View 2 RepliesFord 7.3L Power Stroke (1999-2003) :: Rear Fuel Line Removal?
Having trouble figuring out how to remove the rear fuel line from the fuel pump. Doesn't seem to be the type that uses the quick disconnect tool like the front line does.
View 5 RepliesFord 6.0L Power Stroke Diesel :: Leaking Fuel Line To Pressure Gauge
Couple of years ago I installed a fuel pressure gauge. I wrapped the fittings with teflon tape. Well within about a year it started leaking. So I shopped around and used Permatex Permashield fuel resistant sealant on the fittings. It says diesel resistant on the package. Couple months later leaking again. So I take it apart again, clean every fitting and follow the instructions to the letter. Well its leaking again. What will resist diesel fuel under 55 psi pressure. All the fittings seem to be pipe thread.
View 7 RepliesPrius C :: Fuel Gauge Not Working And Lost Power Suddenly?
My Prius C got a faulty fuel gauge and suddenly lost power in the middle of the road. Very dangerous situation.
View 13 RepliesPassat (B5) :: Check Engine Light Blinks / Burning Oil Smell After Stopping When Driving
So I have 69,500 miles on my car. I leave it parked on a small hill for 3 days and when I turn it on after 3 days of sitting it sounds like it is going to stall and the check engine light blinks. I roll it to the bottom of the hill and turn it on and the light doesn't blink but just stays on. On top of this, randomly but always after stopping when driving i smell a really strong burning oil smell. The smell is so bad i have to open the windows.
I don't think it has anything to do with the CEL but it has been happening for some time. It only smells after you have been driving (mostly Highway) and then stop. It wont happened if your in traffic or driving around town, you have to be on the highway then get off and stop and you smell it. It can happen once a month or twice a week, it is completely random.
Ford 7.3L Power Stroke (1999-2003) :: Return Line Leaking At Fuel Bowl
New to me early 99 (4/98) f350 7.3 6 speed. Truck started acting up a few days after I bought it. Return line at fuel bowl was leaking, so started there and found a bad seal on the Fpr (unrelated to the fuel leak due to disentegrated compression sleeve). Fast forward through a bunch of parts swapping that still resulted in miserable lift pump pressure readings, I pull the sending unit out of the tank, expecting to find a plugged screen.
Well, there was in fact a plugged screen... Attached to the bottom of an in-tank pump. How did that get there?!? Everything I've read says there should only be a pickup tube??? Should I get a new sending unit from a junkyard and do the hutch mod or???
Ford 6.7L Power Stroke Diesel :: Misfire - Smoke - Fuel Injector Supply Line?
Went to go and start my truck this morning and noticed after it was running that it sounded like a misfire, then i seen the smoke... I shut the truck down and lifted the hood and seen that somehow i had a high pressure fuel injector supply line on the Lh side break off. The line that goes from the fuel rail to the injector port on the valve cover (theres 4 of them on a side). There doesn't seem to be an o-ring or anything on them, they are just pressed over and tighten down.
View 6 RepliesFord 6.0L Power Stroke Diesel :: 2006 F250 - Draining Water From Fuel Line?
I have 2006 ford f250 6.0 diesel. I was changing the fuel filter on the frame rail and noticed a lot of dirt in the housing . I tried to remove the plug to drain water to see if i could get out some of the dirt. But the bolt just turned and wouldn't come out. It wouldn't tighten either. I went ahead and cleaned as much dirt as i could and changed the filter. How to get the bolt out....... I just bought the truck so i don't have any prior maintenance history...
View 4 Replies