Passat (B5) :: Front End Noise / Clunking For A While
I have been chasing this dam noise / clunking for awhile now. i changed the tie rod ends, cv axels and sway bar endlinks so far. (they needed to get done anyway) besides those parts all the other bushings in my front end look good.
The noise I will hear is a cracking noise when starting to move from a dead stop and when changing gears i can feel/hear a clunking in my front end. What to check???
Passat (B5) :: Clunking Noise In Front Right Suspension At 67,000 Miles
My 2002 Passat Wagon (2.8L, FWD) has started developing a clunking noise at 67,000 miles in the front right suspension. Based on forum search here, it sounds like a common problem with the control rods, tie rod ends, ...
I looked at the control arm kits available at ECS Tuning. Is this a DIY job for someone with only moderate mechanical skills? I have never performed front end suspension work before. How difficult is it? Special tools needed?
If I had it done (both sides, upper and lower) at an independent repair shop, how much might I expect to pay?
Lastly, is it best to replace all the parts (as provided in these kits), rather than isolating the part that is currently causing the clunk and just replacing what needs to be replaced?
Passat (B5) :: 1999 - Clunking / Popping Noise From Driver Side Front Suspension?
We have a 1999 Passat GLX 2.8 auto. I recently put on a new inner and outer tie rod as well as a lower forward control arm. The issue that we are experiencing is that when accelerating or braking hard there is a popping/clunking noise coming from the driver front area. When accelerating or braking normally/ smoothly it is fine. But, as I said accelerate or brake hard it will make a single pop or clunk and that is it, just once when braking hard or accelerating quickly.
View 2 RepliesPassat (B6) :: Low Speed Front End Noise
OK, so I'm looking for a little insight before I head back to the dealer. Currently running an H&R Cup Kit (about 6,000 Mile) and been happy BUT:
1. @ install I replaced F&R Upper Strut Bearings & alignment by dealer, also swapped to F&K Shorter Front Sway Bar Links.
2. Front Control Arm Bushings replaced under warranty by dealer about 2,000 Miles after Cup Kit Install.
3. Front Upper Strut Bearings replaced under warranty about 4,000 Mile after suspension install due to a slight clicking noise at low speeds when turning hard to the Left (so only 2,000 Miles on the last set and they were replaced).
4. Installed 26mm H&R Rear Sway Bar about 1,000 Miles ago on softest setting.
So where I am at today is the low speed front end noise is back and worse, I now have noise no matter the degree of the turn. Also sounds like sub-frame is lose when hitting speed bump etc (first time on this VW but been through it with the last Audi). My question is what are different peoples opinions as I think I'm overlooking something before it goes back to the dealer again. Sounds like the front spring is binding a bit as I can hear the clank as the tension releases but this can also be the front sway bar.
Elantra GD (2013+) :: Front End Clunking When Going Over Speed Bumps
Clunk in the front end when going over speed bumps? That is the only time I ever get it, never on bumpy roads or anything like that just at speed bumps. It seems to be louder on the drivers side but I am pretty sure its on both sides. I never noticed it until a couple speed bumps were installed along my normal route, but that could be because maybe I never drove over them previously?
View 3 RepliesPassat (B6) :: Front Suspension Squeaking Noise When Going Over Speed Bumps
2010 VW Passat - Sedan
See the attached videos. The first one (night time) was made before I took the car to the dealer the first time. Dealer said that I was going too fast over the speed bumps, so I made another video (daytime) showing the speed (10-13 mph). Both times you can hear a squeaking noise coming from the front that I just started hearing last week. The car has only 23,000 miles on it. I bought it brand new back in September of 2010. I don't know what to do because the dealer (of course) says that they checked everything and there is nothing wrong with the car.
What was the cause of it. I can take it to a mechanic and check it myself and then bring it to VW for repairs and telling them exactly what's wrong and why.
Video 1 .....
Video 2 .....
Ford 7.3L Power Stroke (1999-2003) :: Front End Clunking Sound Going Over Parking Lot Speed Bumps
I went to check out a '03 7.3 SD the other day. It didn't seem to have a lot of surge when I accelerated to freeway speeds. Kind of lazy feeling. Didn't smoke out the back though. It did have a front end clunking sound going over the parking lot speed bumps. I opened the oil fill cap while it was idling and it blew a plume of vapor/oil about 9' high like a steam engine puffing. Held my hand over it and got a oil wet palm after just a few seconds. I'm hesitant to drop any $$ on it.
View 6 RepliesPrius (Gen 2) :: Strange Clunking Noise When Turning At Low Speed
My 2008 Prius with 105k miles recently started having a strange clunking noise when turning at low speed. Dealership diagnosed it as the steering shaft and yoke to replace.
View 7 RepliesGolf/GTI VI :: 2.5 5 Speed - Clunking Noise When Shifting Gears
Lately when shifting gears, there's this clunking noise as I let off the clutch. It happens more often than not when I'm in traffic and I upshift without giving any gas on the clutch release. Currently got 13k km on my car.
View 1 RepliesJeep - Cherokee :: Minor Clunking Noise Vary With Speed
1990 Cherokee 4.0 ... Well I've got a minor clunking somewhere under there that seems to vary with speed. now I have to figure out what it is. my working theories are wheel bearing, or one of the three hundred odd universals under there. perhaps a brake shoe or the transfer case. This is my first 4wd, so I don't know about transfer cases.... there is also some kind of weird double universal under there, I can t remember the name off the top of my head.
View 10 RepliesLexus IS 2014+ :: 8 Speed Tranny Has Clanking / Clunking Noise When Shifting To P
With 8 speed tranny has the clanking/clunking noise when shifting to P? When I park my car and shift from R to P there is a clanking/clunking noise and I feel small vibration on shifter itself when the noise occurs. It happens all the time and the noise loud enough. Is that normal? Up to this moment I thought it is normal (it still very well maybe) until I drove my friends Audi that does not have any noises when playing with the shifter. My Audi did not have that either.
View 2 RepliesFord 7.3L Power Stroke (1999-2003) :: Clunking Noise After Speed Dropped To 20 MPH
2001 ford excursion 7.3l diesel.
So I tried to go to work today but the truck said no. it started out fine then out of no where it felt as if someone slammed on the back brakes engine still revved up like normal just didn't want to go. speed dropped to 20mph then i heard a clunk. after that it was fine until it hit 20 mph again. it did the same thing again.
So I got mad at it thinking the trans went out gave it the beans and it shifts into all gears but did not feel like it had power. i did pull over and check the fluid looked a little orange. when got back in the truck i did notice the od off light blinking?? drove the truck home was shifting fine but hear this awesome sounded like a hand grenade rattling around underneath. when i got home notice fluid coming from the bell housing(out of the bottom).
Passat (B6) :: Clunking Sound Occasionally On Front
Getting a sub-frame spacer and bolt kit tomorrow... Hopefully that will resolve the clunking sound I occasionally hear up front.. Everything is tight and solid up front, suspension-wise, so we'll see if this fixes the issue. If nothing else, it's a cheap 'mod'..
View 8 RepliesPassat (B5) :: Front Suspension Clunking Vibration At Low Speeds
This just started happening on the driver side. Going over bumps and slight road wobble type imperfections make a medium pitched clunk sound. The sound stops as soon as I press the brakes ( which I just replaced last week). I do have a worn out bushing on the curved lower control arm. Could that be it? Do I need to replace all control arms or can I do just the curved set? If thats the issue.
View 13 RepliesFord Super Duty (1999-2016) :: 2003 F350 - Clunking Noise Only At Low Speed On Very Light Bumps
What this clunk could be?? in my truck in signature, 2003 F350 CCLB 4x4, 4" lift. its only low speed, on very light bumps. really does it when the truck flexes, like turning into an elevated driveway or something. driving me absolutely insane the last few months. it sounds like its coming from right under my feet
-removed front shocks and drove
-removed front sway bar and drove
-front wheel bearings are new and tight
-front leaf spring, rear upper shackle bushings are new (thought that was problem..no)
-front leaf springs and bushings are new, although i suppose its possible to have a bad bushing already
-removed traction bars and drove
-removed front track bar and drove, but going to try this again.
-all cab mounts look ok
-took out cab mount under drivers foot, and cut down the metal piece a little...read about it on another thread on here. no change
-made sure my gooseneck ball couldn't rattle
-steering box is new...thought that was it
-steering shaft is solid
-transmission mount bushing and crossmember feel tight
-lubed front driveshaft slip joint and it doesn't have any u joint play
-rear shocks seem ok but haven't removed them yet
-fuel tank is solid
-rear driveshaft has new carrier bearing and u joints, all is tight
-exhaust is not hitting anything
-u bolts all tight, spring bolts are tight
As you can see, I've been through damn near everything. my only thoughts right now is a possible bad cab bushing, or bad leaf spring bushing...as it sounds like its right under my feet. and when you flex the truck, it makes all sort of popping and clunking noises. i had the truck on my buddies lift and we went under it for an hour yesterday looking around with no luck. only thing i found was a bad traction bar bushing but we removed them and it still does it..
Most noticeable at the end of the video...it sounds exactly like a bad sway bar bushing but that's not it...
Front end clunk - YouTube ....
Passat (B5) :: Clunking When Braking Coming From The Front Driver Side
Every time I brake I hear a clunking noise, it happens right before I stop completely. For some reason it does not make the noise when it has recently rained or the car is wet, the noise is coming from the front drivers side. I had a mechanic check out my suspension, and he said everything was fine. I am thinking it could be a bushing, but am not sure.
View 10 RepliesGTI 337/20th Anniversary :: Clunking Noise In The Front End
well what are the chances that all in one week.. I would get my front end hit in the same spot that i just fixed.
get a crack in my windshield.
get a flat tire.
Have the tab that holds the passenger sun visor in place break off.
Have a new "clunking" noise in the front end.
Ford Excursion :: Front End Clunking Noise?
I've had a front end clunk best felt on the floorboards at very slow speeds on uneven ground. I've read for a month on this site on this issue and have replaced the ball joints and sway bar end links with Moog parts. New shocks also. Well I've improved but its still there. I cannot budge the trac bar bolts with breaker bar. The axle u bolts seemed loose so I tightened them but I'm not sure of the torque specs on them. What are the torque specs on the u bolts and where to go from here?
View 14 RepliesCherokee :: 96-XJ 4WD - Clunking Noise From Front On Driver Side
started to get a clunk noise, it would correct itself if i kept driving but now it seems to last longer.
[URL]...