Passat (B5) :: Putting A Climatronic System In The Car
I have a passat B5 2.3 VR5 with aircondition and I have been thinking about to build a climatronic system in the car I did have a climatronic in my old passat B5 V6 TDI and I was so happy about it, The refit part are not the hardest thing, but what about the wiring part? do people rebuild their own wiring system, or is there made a wire kit to the climatronic system.
View 4 RepliesPassat (B5) :: 1999 - How To Reset Climatronic
I have a 1999 passat and want to reset the climatronic. I have tried to press and hold econ and air up together but no luck ...
View 5 RepliesPassat (B5) :: Climatronic System Not Blowing Heat
I noticed about a week ago (on a cool morning) that my Climatronic system would not blow heat. I played around with it briefly by adjusting the temp settings and how the blower was working.
If I set the temp to High heat would blow out for like a minute but anything else would just blow cold air.
If I set the temp to High and turn Econ on I would get hot Air.
No other settings would generate heat. I VAG Commed my car and there were not fault codes!!!
I took my car to my normal indie shop and they also were puzzled by this. They re-ran a vag com and nothing for them either. The heater core was flushed recently with the resting of my coolant system when my TB was done.
There is no sign of leakage for the heater core but I'm super puzzled to what the problem may be.
Passat (B5) :: Clicking In The Dash / Climatronic Died
Halfway into a 2 hour trip away from home my climatronic died. The display is blank and no air is moving through any of the vents. This was a big problem since I encountered a heavy rainstorm and my only means of clearing the windshield was my handkerchief. I checked the fuse and it seems fine. There was clicking in the dash prior to this happening. I looked at the relay and it seems fine but I wouldn't know what a "bad" relay looks like.
View 2 RepliesPassat (B5) :: Climatronic Display Blink For 10 Seconds
I have cut of the battery, and when I reconnected it and turned the ignition on the climatronic display was blinking for approx 10 seconds, and after that worked normally. What could happen to it?
View 2 RepliesPassat (B5) :: Subtle Knocking / Popping Sound Under Dash (Maybe From Climatronic)
When car is on , I am hearing a subtle knocking/popping sound I thought was from climate control but not so as even when it's off i hear it. It sounds like a popp noise from maybe passenger side. What component might be doing this?
'02 GLX
Passat (B6) :: 2006 Climatronic - Cold Air Is Just A Little Too Warm To Be Working Correctly
I have a 2006 Passat 2.0T (UK Model), and I'm having trouble with both the outside temperature reading and the climatronic's cooling ability. When I bought the car the air-con was blowing cold and warm air without any problems, but the "cold" air is just a little too warm to be working correctly. I've had the system re-gassed but this didn't solve anything.
As I said, all the features of the air-con work perfectly, it's just the cold air just isn't cold enough - so it seems to me that the compressor is working fine. Also, the outside air temperature reading on the MFD reads about 5-10 degrees too warm. Would this have anything to do with the air-con issue?
Passat (B5) :: 2000 - A/C Work Sporadically - Climatronic Use Outside Temp Gauge?
My climatronic has been goofy since I bought my 2000 v6 4mo. In the winter my heat never got really hot and now in the summer my A/C work sporadically. I had the thermostat changed along with the full timing belt service. I'm hoping I'll get full heat come september. My A/C, however works less and less often. The tech who did the timing belt change etc. said that there was a lot of pressure at the condenser, but that he thought a flap may have been stuck. he checked those and they are fine. The last two things he said should be checked are the external temp gauge(which is way off, reads 22'F when its like 85 out) or possibly I need a new climatronic head unit.
My questions are esentially these; Does the climatronic use the outside temp gauge to determine cabin temp? Do head units fail often? Are there temp sensors in the cabin other than those built into the climatronic head unit?
Passat (B6) :: Climatronic System Trying To Adjust Temps But Motor Making Tick Noise
So the problem seems to be the climatronic system is constantly trying to adjust the temperature but the problem is that the motors or servos are making an annoying ticking noise as it adjusts. I already had the blend door assembly replaced but the noise is still there. My Touareg has climatronic and doesn't make any noise, so don't believe I should be getting this noise in my Passat. Service advisor claims its normal to make some noise since his Passat does the same thing, but I don't buy that. So who has had the same issue and got it fixed properly? What did they replace?
View 7 RepliesPassat (B5) :: Real Bad Vibrations When Braking
I have real vibrations when braking. What could be the cause? I think its a warped rotor. Also.. What are your opinions on cross drilled rotors. I hear they are good with disapating heat but i heard they wear down break pads quickly.
View 5 RepliesPassat (B6) :: Vibration Sound From Real Wheels?
I noticed it today when I first started driving to work. The sound would be best described as if you were missing a big chunk of rubber from your tire and you heard the 'thumping' as the tire rotated. It happens when I go into left turns mostly. Sometimes when I go into right turns. And only once when I was driving straight this morning when the car was first started. I am not certain where the vibration is coming from, but it feels like it is the rear of the vehicle somewhere. What this might be? (I checked the tires, no missing chunks )
View 7 RepliesPassat (B5) :: Alarm Went Off For No Reason?
My Passat alarm went off last night for no apparent reason. Car had been parked for a few days. The engine started whilst the alarm was sounding. The interior lights were flashing and the electric window stayed down and wouldn't go up. Needed to drop it to see to get the car in the barn away from the neighbours house as the windows were frosted over. Disconnected battery and the alarm finally stopped. Tonight I reconnected the battery and it locked me out. I realised later that there's a procedure to go through after reconnecting the battery but foolishly I cut the wires to the alarm, which didn't stop it. It was getting the horses in the barn wound up and I needed to stop it. What caused the initial alarm? ECU fault? It's a '99 V6 TDi.
View 6 RepliesPassat (B7) :: Check Engine Light With No Reason
Got in the car this morning and started it up. Other than it being -6 degrees out, nothing unusual. The damn check engine light came on. Nothing seemed unusual driving it. Will be checking it tomorrow.
View 14 RepliesPassat (B5) :: Car Stuck Suddenly With No Apparent Reason
The other day, in sub zero weather I left my radio and lights on as I ran into the store to grab washer fluid. The engine was turned off, but I did leave the radio on for my buddy.... I was in the store for a max of 5 mins. I get back into the car, go to turn it back on...... and nothing.... ZERO juice.... now I've had the radio on before for a much longer period of time without the engine running and have had no problem.
We ended up jumping the car and it started up with no problem. I let it idle for a bit but then all of the light on my dash came on..... I reved the engine a bit and they all went away.
A few days pass and the car starts up with no problem. Then I get stuck sitting in underground parking, so I turn the car off while I wait for the cars to exit the garage... again listening to music with the car off... go to start and nooooo juice! Being that the car is manual I was able to get it rolling and then popped the clutch..
224,000kms and counting.... all OEM
Passat (B5) :: Turn Signal Clicks For No Reason
It is a pretty simple problem, but on a few occasions the "clicking" noise that goes along with the turn signal blinking will not stop after turning off the signal. It does not click at the normal cadence. It erratically clicks on and off and will continue to do so for 3-5 minutes. Neither the turn signals nor the indicator lights blink, but the clicking continues in the dash. Turning the signals back on puts the clicking into normal speed, but once the signal is turned off it goes back to crazy speed. It only happens once every couple months, but it is really annoying.
View 4 RepliesPassat (B5) :: Won't Start And Battery Good - Reason?
Okay so my brother has a v6 passat, he started it drove it got home went to go start it later on an Wouldnt start. the battery isn't dead an ignition switch is brand new. I haven't really looked at it yet just wonder what it could be before I go threw it.
View 24 RepliesPassat (B5) :: Warning Messages Keeps Coming For No Apparent Reason
My wife drives a 2000 passat wagon that's had wacky electrical problems since birth...most common are warning messages for no (apparent) reason -- check engine, brakes, oil, etc...
This morning the car wouldn't start...got it going with a jump and drove it a while to recharge, but when I turned it off, the radio stayed on, as did a fan under the hood and probably other stuff I didn't notice ... I assume this is what caused the battery to die in the first place... I've disconnected it for now but can't keep doing that forever ...
I've seen a lot of Passat electrical problems, I'm guessing alternator, but don't know much about cars.
Passat (B6) :: Engine Shut Off For No Reason And Wouldn't Start Up Again
Here's the story, got in my car yesterday and the AC wasnt working, after driving for about 20 minutes in traffic, the AC came back on, about 5 mins and half a mile later, the engine shut off and wouldn't start up again. Had the car towed to the closest garage (not a VW mechanic). This morning, he tried to start it and it fired right up with no problems. He drove it and let it run and everything seemed fine. He ran diagnostics on it and said the computer didn't detect any problems. Picked up the car, and now the AC is blowing hot air, but the engine seems to be running ok.
View 4 RepliesGolf VI R :: Climatronic Always Defaults To 72F?
Whenever I hit auto on the climatronic after the car has been off it always defaults to 72 degrees. I'm in South Florida, and I realize it's a little thing, but it'd be great if I could make it default to low right off the bat. Is this something Vag-com could be used to alter? Tried searching for this but couldn't find anything directly related.
View 1 Replies