Ford 7.3L Power Stroke (1999-2003) :: Removing HPOP Reservoir Cover?
I need to get the HPOP reservoir top cover off so I can drill/tap a gauge probe into it.
I see torque-head bolts, and a few long bolts that go all the way down into the HPOP.
Unfortunately I cannot get two of the torque-head bolts out because they only un-thread several rotations before the heads of the bolts hit the edge of the fuel filter canister/bowl.
Any tips or tricks?
Passat (B6) :: Headlight Bulb Socket Partially Melted
I was changing standard halogen headlight bulbs last night and as I was getting the drivers side bulb out the metal part came off with the bulb and I noticed the black plastic part of the socket was partially melted. Sketchy. Far as I know these bulbs have never been changed I bought the car w 3500 miles back in 06. Is there anything I should do besides replacing the melted socket? A part # would be awesome too...
View 2 RepliesFord 7.3L Power Stroke (1999-2003) :: Lost Power Steering / Refill Reservoir?
I lost a hose in the driver side front wheel well this morning while pulling RV to a campground. By the time I got there and got the RV disconnected, I lost all power steering. I reconnected the hose using a zip tie and have a friend bringing me fluid to refill reservoir.
Is my pump toast now? Can I refill the reservoir and prime the lines and be good to go?
Camry :: 2003 V6 LE - Power Steering Reservoir Return Hose - Fluid Leakage
Just checked out at 2003 V6 LE with 120k miles for $5500. Car seems to be in excellent mechanical condition but I did notice quite a significant power steering fluid leak, seems to be coming from the reservoir. I see that there are two hoses for about $80 each listed on Partsgeek.
Is this a common problem, can the clamps just be tightened, Could it be the reservoir it's self or even the pump too high a pressure?
Seems to be quite a lot of fluid running down the side of the car but after taking it for a test drive I didn't see any signs of it squirting out so perhaps it's a slow leak and been leaking for a while.
Camry :: 07 2.4L - Power Steering Reservoir Empty
I lost my power steering on the way home from work today (40 mile commute). Stopped at a gas station half way. About 5 miles after noticing the problem. Lifted the hood and noticed fluid along the line towards the radiator. Reservoir was empty. So I added a quart just purchased from the station and noticed the fluid level immediately began to drop. Decided to finish commute home. Stopped after 10 more miles, reservoir was empty so I added another quart and finished the drive home.
My camry has 150k miles so I am not surprised. So I parked it at my house and looked under the hood/car, I definitely have one hose leaking in the engine area. It is the hose located near the radiator on the passenger side that comes from the reservoir. The "U" portion is metal and has corroded away. It spits fluid when the steering wheel is turned. The pump actually is pretty clean with no leaks from it.
But when I was underneath the car, there is a hose completely severed. Roughly 2inches of exposed hose before it disappears into a manufactured hole in the car floor with a rubber gasket around it to hold in place. Where this hose is supposed to connect too. It drips P/S fluid, but nothing changed when turning the steering wheel.
Ford 7.3L Power Stroke (1999-2003) :: Unplug Front Side Marker Socket?
I need to replace my FRONT side marker socket.
This is the small 194 bulb socket, NOT the parking/signal socket.
There IS some sort of clip that, for the life of me I can't figure out.
Camry :: Power Steering In Reservoir Going Down - Fluid Leakage
So I've been noticing my power steering in the reservoir has been going down for quite some time. Now its more noticeable than ever. Just about a month ago I topped off the tank to the "max" line and now its at the "min" line. I also notice the fluid on the garage floor. I've always had a lot of grease (I assume the fluid) all around the body and under the reservoir under the hood. It seems to be leaking from the hose where it connects to the actual reservoir. Maybe the clamp is bad or something.
View 14 RepliesCamry :: 2007 - Power Steering Fluid Reservoir Is Little Low
My power steering fluid reservoir is a little low. Which type or brand of power steering fluid should I fill it up with?
I know that I should use Dextron III, but does the brand matter? Or can I mix the OEM fluid with an aftermarket fluid.
Golf IV / Jetta IV :: Power Steering Reservoir Location?
I want to clean up my bay a little bit. How and where can I relocate the power steering reservoir?
View 15 RepliesCelica :: 1994 / 2.2 - Power Steering Fluid Leaking From Reservoir Cap
I have a 94 Celica 2.2. I'm having issues with power steering fluid leaking from reservoir cap. I replaced the cap due to the old ones seal had dry rotted and dip stick was broke off, also replaced the 2 small short hoses and new clamps. The return hose is working right and the high pressure hose seems to be working right. None of the hoses are leaking but pressure is building up and pushing fluid out the reservoir cap. What else could be the problem to cause this??
View 14 RepliesNissan - Maxima :: Power Steering Fluid Reservoir Is Almost Empty
I've a problem with my 2000 Nissan Maxima GLE. Recently I started hearing noise from Passenger side of the car, and I noticed that the Power Steering Fluid Reservoir is almost empty. Looking more closely, I see some kind of leak. Could this problem indicate something wrong with the Rack and Pinion or the Pump itself.
I went to autozone today, and bought a Power Steering Fluid with Stop Leak. I added the liquid, and turned Steering Wheel to the right and the left. After doing this, I checked the reservoir again, and I saw the reservoir level was very low again. I repeated the above steps until I reached the point where the reservoir level was to the high point.
I would drive for couple of days and see if the reservoir level goes down again which point to leak still existing. While waiting on this test, thinking what could have gone wrong here that is causing the Power Steering fluid to leak. I've also attached the picture which point to suspected point of leak.
Corolla / Matrix 2009-13 :: Cannot Locate Power Steering Fluid Reservoir?
I own a 2009 Corolla. Cannot locate where the power steering fluid reservoir is. I googled and also looked under the hood, no luck.
View 6 RepliesCamry :: Leakage In Rubber Hose Attached To Power Steering Reservoir?
So the big rubber hose attached to my power steering reservoir is leaking and my mechanic told me to replace it. I went to a couple of different Autozone stores and they both couldn't identify the correct dimensions of it. They told me to take it out and then bring it to them. This is very hard for me since this is my only car and how to pull the bottom bit of the hose out from whatever it's attached to.
I've measured the length to be about 2.4 feet but I'm not sure on how thick it is. I've taken a pic of the hose here:
Santa FE SM (2001-06) :: 2004 GLS Power Steering Fluid Leaked Out The Top Of Reservoir
I have an issue with my 2004 GLS 3.5 L w/ 68000 miles. After the SUV warms up for a few minutes I can hear a whine or rattle on the passenger side. I noticed a little power steering fluid leaked out the top of the reservoir (a few little bubbles in the oil). Then reading on the HMA website it says the filter in the reservoir can get clogged and restrict the flow. I took the reservoir off and flushed it out then replaced with new oil.
Unfortunately this did not fix the issue the noise is still there. It's most prevalent when you turn but the noise also picks up a little when you hit the gas. I have checked for hose leaks but cannot find one. My next step is to have the steering pump changed out. While the mechanics in there I am going to have him check the hoses/pulleys really close and look around for another leaks anywhere. Noise is annoying but the steering works fine.
Honda - Accord :: Power Steering Fluid Coming Out Of Reservoir When Car Is Shut Off
2000 Honda Accord. Power steering fluid is coming up and out of the reservoir when the car is shut off. I recently had to take the hose off and move it out of the way just to make it easier to replace the belt. Lost some fluid and put more back in. And now this. Also is whining when you turn the steering wheel. What do I do?
View 7 RepliesFord F-150 (2004-2008) :: Lots Of Sloshing Going On In Power Steering Reservoir
I have a new to me 2006 F150. The other day, looking under the hood while it was running, I noticed there was lots of sloshing going on in the power steering reservoir. I thought it was boiling for a minute, but it is seems to be just pumping around pretty much. Is that normal? I've never seen it before, but most of my vehicles either didn't have a transparent reservoir or were too dirty to see!
View 1 RepliesSanta FE SM (2001-06) :: Power Steering Fluid Boiling / Foaming Leaking Out At Reservoir Cap
2.7 Power Steering Fluid boiling/foaming leaking out a reservoir cap!
1) Recently had Timing Belt/Water Pump and spark plugs/wires replaced.
2) Issue started immediately after.
3) Removed most of old PS fluid, cleaned out reservoir w/brake cleaner. NOTE: nothing appeared to be clogging reservoir. Refilled with new PS fluid. Repeated these steps a second time. This appeared to immediately resolve the issues for several weeks.
4) Now the power steering is getting rough and noisy again. Also, the PS reservoir is leaking out of the cap worse than before. It looks like the fluid may be "boiling", but it is definitely foaming up pretty badly.
What my issue(s) may be?
Ford 6.7L Power Stroke Diesel :: Fan Shroud Must Come Off For Changing Belt?
Changing serpentine belt? I have to but was looking for some pointers or tips. I assume the fan shroud must come off?
View 14 RepliesLexus RX 2004-09 :: Remove Engine Cover For Access To Power Steering Fluid Reservoir?
I am trying to remove the engine cover on the passenger side of the engine bay so that I can access the power steering fluid reservoir. What is the procedure for removing the plastic clips, rivets or whatever they are and also how do you reinstall them? This is a hair brained design if I ever saw one!
View 14 Replies