Ford Excursion :: Fuel Filter - Water Drain Valve Broken Off
Have had my Excursion for a few weeks now. Took it to the dealer for some maintenance on the brakes. Had them do oil and fuel filters while it was there. Dealer calls to tell me that the water drain valve had broken off when they tried to drain water and the needed to replace the housing. Picked it up today and this is what they found when they pulled off that assembly...
View 11 RepliesFord Super Duty (1999-2016) :: 2002 - Gas Engine Won't Start After Replacing Fuel Filter / Pump Relay / Air Filter?
After replacing fuel filter, pump relay, and air filter for good measure my 2002 f250 v10 gas engine still wont start. What to do?
View 13 RepliesFord Super Duty (1999-2016) :: Low Fuel Pressure - Engine Power Reduced After Fuel Filter Change?
I had my fuel filters changed at the dealership today on my '15, and then I bought fuel and headed home (70 miles). About half way home I got a "Low Fuel Pressure" message and a little while after that "Reduced Engine Power" along with the check engine light.
I pulled over to see if they did something like leave the drain open, thinking it might be sucking air. Of course it was dark and I could not see anything. However I did hear a buzzing sound and could feel a vibration when I touched the fuel line going into the top of engine filter.
While it is possible I got bad fuel, I suspect they did something wrong installing the filters. Even after cycling the fuel pump multiple times they had a hard time getting it started afterwards; I think they finally disconnected the top fuel line to bleed the air out.
I continued home and made it, but not sure what to do now; its 70 miles back to the dealer.
What is the most likely problem? Improper fuel filter installation or bad fuel?
Should I pull the filters in the morning see if there is something obvious like an out-of-place gasket? If so, top or bottom filter?
Is this a tow truck affair or should I drive 70 miles back to the dealer?
What the heck is the buzzing sound?
Chevrolet - Malibu :: 2013 - Wheel Rim Was Broken Off - Tire Is Keeping Air?
I was t-boned at an intersection, (I had a green light) My car was hit by the rear door and part of my wheel rim was broken off. The tire is keeping the air. We are also going to have a guy from the other driver's insurance coming to check out my car, I want to be sure my car is safe, he might want to get repairs done as cheaply as possible.
It's a Chevy Malibu 2013(I'm not driving it btw)
Chevrolet - Malibu :: 2001 - Broken Gas Gauge / How To Check Gas Level
I have been dealing w/ a broken gas gauge for a while and have been monitoring my mileage and fill-ups and have been able to calculate my gas usage pretty well, however sometimes I may get a little lost on where my level is at. I just recently have been using a long plastic tie strap that reaches the end (I think) of the gas intake and I believe hits the gas tank. (Its goes in about 4' and I cannot push it any further at that point)
My question is when it comes up w/ no gasoline on it I am wondering how many gallons are remaining. Looking at a diagram of the gas tank it looks concave, where some of the gas may sit lower that where my tie hits. But I am almost certain that I have at least a few gallons remaining. For safety and other reasons this is not something that I am doing often, its just in this case I am a few miles from a gas station so I do not want to risk it.
Malibu :: 2004 Chevy Maxx Hatchback - Broken Power Seat
I have a 2004 Malibu Maxx hatchback. It has been a solid car since we rolled it out of the showroom. Recently, I noticed when I raise the adjustable driver's seat after my petite wife has driven the car, the seat tilts to the right. After a survey of the power seat mechanics I found a broken front rail. It appears as if the end of the rail where it connects to the hinge is being peeled back as if I were removing the wraper of a crayon. I have only found one other post on the internet. Is this is a common problem?
View 14 RepliesFord 7.3L Power Stroke (1999-2003) :: Fuel Filter Clean Up
I'm checking my fuel filter regular (draining, examining.....basically OCD **** stuff) and I'm spilling diesel around the bowl. I've learned to put a rag around it now, but what's best way of cleaning diesel around that area? I'm tired of my wife complaining about smell. Simple green, purple power, etc???? Also, tell me what to watch out for.
View 14 RepliesFord 7.3L Power Stroke (1999-2003) :: Remove Old Fuel Filter Cap?
just bought this truck and it has a brittle cap and i cant get the cap to turn, its been on there awhile . 99 f250, anyway might have to destroy this cap to be able to remove it. Doing this without damaging the filter housing?
View 14 RepliesFord Super Duty (1999-2016) :: Fuel And Air Filter Replacement?
How often in miles (mostly highway and city) would you change the following:
1.Baldwin spin on fuel filter added with hutch mod
2. Napa diy 6637 air filter mod with no sleeve over it, just the paper element
3. Stock fuel bowl filter after having added a pre-filter (previously mentioned in #1)
Nissan - Frontier :: 1999 - Stumbling Sporadically - Could It Possibly Be A Clogged Fuel Filter?
I have a 1999 Nissan Frontier, 4cy, 5speed. About a week ago, it began stumbling sporadically so my first thought was that maybe a spark plug had fouled. I changed the spark plugs, and the problem persisted. At this point, I begin thinking maybe it's a fuel issue. I went to Advance and bought Lucas Oil fuel system treatment and added it to the 1/2 tank of gas I had at the time. Going home from Advance it ran great. No stumbling. However, it started again the next day. I ran out that 1/2 tank of fuel and filled up again and it is still doing the same thing. It idles a little rough, and stumbles while going up through the RPM range between shifts. Once I get up to highway speed in 5th gear, it seems to do okay. Should I add more fuel injector cleaner or maybe SeaFoam? Could it possibly be a clogged fuel filter?
View 1 RepliesFord Super Duty (1999-2016) :: F350 - Changing Fuel Filter?
Here within the next couple weeks, i am wanting to do some routine maintenance. right now on my list is just an oil change along with the fuel filter.
View 6 RepliesFord 7.3L Power Stroke (1999-2003) :: Fuel Filter O-Ring Blowing Out
My fuel filter lid o-ring keeps blowing out upon hot start, this has happened 4 times now once last week, I replaced filter and all was ok until Thursday it happens again I change the filter allis fine! Now today!!!!! TWICE I have to install new filters because the o-rings are blowing outside the bowl lid! I'm using the same BALDWIN PF7698 filters I've used for years, my reg. Is set at 75psi and holds steady! No spikes but I haven't been able to watch it when the o-ring blows out! Injectors and o-rings are new (<1000miles) no problems during operation at all!
View 14 RepliesFord 7.3L Power Stroke (1999-2003) :: Won't Start Even Installed Fuel Filter?
Shut my truck off for about 15 minutes and wouldn't start back up. Installed new fuel filter. And gonna try changing cps. Torque says Rpm 180
Ipw. Bouncing between 600 - 3000 Hpop. 250 while cranking Voltage 10.9 while cranking. Ipr starts about 15% and slowly climbs to about 88%
Fuel pressure about 65%
Tried unplugging cps. Gonna check oil now though I check it every time I fill up and it never uses any.
Sonata NF (2006-10) :: In Cabin Air Filter Tabs Were Broken
So I've been getting that nasty, musky odor in my 2006 Sonata. I just purchased it used last December, so don't know when the cabin air filter was last changed. I had to do this with my Camry not too long ago, so I still have the spray to try on it if the filter isn't too old/dirty. The problem:
When I lowered the glovebox to get to the cabin air filter, one of the tabs was broken off. I figured no big deal. I pressed on the other three and they all broke off. My husband tried to get it out, but no luck. I'm afraid of damaging it if I try to pry it out and even if I succeed, do I have to do that every time I need to get to the filter? Where I would find a new housing?
Ford Super Duty (1999-2016) :: Fuel Filter Water Separator Freezing
We have been having near zero temps for several days and it occurred to me that there may be some amount of water in the water separator in the rail mounted fuel filter (not enough to send a message, but maybe some amount). I only have 3,000 miles on the truck. So, just wondering if a small amount of water is going to hurt anything in the filter or filter housing if it freezes? Should I drain the filter in freezing weather even though enough water hasn't collected enough to activate a message?
View 6 RepliesFord 7.3L Power Stroke (1999-2003) :: Tips To Remove Stuck Fuel Filter Lid
I am attempting to change my fuel filter - have a new Napa unit complete with new lid.
I can not get the old one off (this alone tells me it's been on there too long). The hex is 26mm and all I have is a 26mm box end. It just rounds the corners of the plastic hex off.
As the new filter has a new lid, I am using a steel chisel and hammer (in a CCW direction) at several places on the top flange. I have also smacked the top flange liberally to get it to let go of whatever is holding it.
I'm about to get out my map torch out and warm up the plastic but would rather not produce a flame on something with fuel directly behind it.
Ford Super Duty (1999-2016) :: Changing External Transmission Fuel Filter?
Any luck changing the external transmission fluid filter, without breaking it or its piping?
View 2 RepliesFord Super Duty (1999-2016) :: 2003 - Tool To Undo The Cap On Fuel Filter?
I have a 2003 Ford f 250 turbo diesel 7.3lt V/8,is there a tool to undo the cap on the fuel filter as i have problems every time i service the truck.
View 5 RepliesFord 7.3L Power Stroke (1999-2003) :: 2001 - Fuel Filter Housing Leaking?
I have a 2001 f250 7.3l 4x4 and the fuel filter housing is leaking real bad from either the back or under it. I need to get info on parts that i would need as well.
[URL]....