Golf IV / Jetta IV :: SAI Pump Cutting On Randomly While Driving
I recently replaced my SAI pump rivets with stainless bolts so everything is nice and tight. However, the pump will randomly cut on and run for a few seconds while driving... i notice it usually when I come to a stop, such as at a stop light. I would assume this is because there is an air leak somewhere in the SAI system... sound likely? Maybe purge valve? I haven't yet had it pressure tested in case there is something I can easily to to rule out most potential sources.
View 8 RepliesGolf IV R32 :: Gas Filler Keeps Cutting Pump Off And Car Runs Bad In Certain Situations
My gas filler keeps cutting the pump off and car runs bad in certain situations. I'm a vrt btw so I have eliminated the Sai crap and have the n80 solenoid detached from the vac lines but still hooked in electrically. EVAP Charcoal canister Delete....
View 17 RepliesGolf IV R32 :: Car Dies Out At 6000 RPM
On my way to work today i notice something unusual. in first gear when i punch it the engine stops or feels like it cuts off at 6000rpm however in any other gear it runs fine and when i slowly go on it in first gear it runs normal.
View 11 RepliesSonata I45 (YF - 2011+) :: Gas Leak At High Pressure Fuel Pump
I have a gas leak at the connection of the High Pressure Fuel Pump and high pressure fuel pipe. Gas drips and sprays out from the nut area (see pic). The car take a several seconds to turn over to start.
What is the most likely cause? The car is out of warranty, so trying to repair myself without having to replace any expensive parts unnecessarily.
Sonata I45 (YF - 2011+) :: High Pressure Fuel Pump Failure
My 2011 has just over 27K miles on it. On Saturday the Check Engine light came on. The next time I started the car, it cranked over for about 5 seconds before starting, which is unusual. Then multiple times Sunday and this morning, it seemed to take even longer to crank before starting. This morning, it barely would stay running. And there was a lot of hesitation driving down the road.
I scanned it with my OBD II scanner and got P0087 (Fuel Rail/System Pressure Low). I dropped it off at the dealer this morning and jut got a call that they are replacing the High Pressure Fuel Pump. But they had to special order it overnight and probably won't have it replaced for another day after that.
Is the high pressure fuel pump the device sticking out the top of the valve cover on the back, driver side of the valve cover, with the multiple fuel lines going into/out of it?
Passat (B6) :: Loss Of Power - High Pressure Fuel Pump Went Out
My wife was driving our 08 B6 yesterday and suddenly had a loss of power. Check engine light was on. Took it to the dealer and we heard back today that the high pressure fuel pump had gone out. I had heard of the TDI's having this problem and I know BMW had to do a recall on the same issue. I didn't know that the 2.0 TSI had this problem.
I'm a little bit concerned 'cause we leased the car for 3 years and didn't have a single problem. I thought it was very solid so we decided to buy the car last month Now my confidence in the car is a little bit rattled.
The car is under warranty. I just hope that this is not the kind of thing that's going to go out every 20K miles! Out of warranty, this repair would have been costly.
Golf V R32 :: Faulty Fuel Float Sensor / Wrong Fuel Pump?
R's at the dealer today for a faulty fuel float sensor, and they just called to let me know my vehicle has the wrong fuel pump in it. Seems mine has the pump for the Golf/Rabbit with the 4 cylinder engine and they need to keep the car until the part is in.
View 16 RepliesGolf IV / Jetta IV :: Fuel Gauge Not Correct After Fuel Pump Replacement
I recently had my fuel pump replaced in my 2005 GTI ... twice. Both times, the fuel gauge no longer shows a full tank, and doesn't show empty tank correctly. Is there some way to reset the gauge? Is the pump somehow tied to the gauge, or did the mechanics mess the float up when they changed the pump? Sadly I had it repaired somewhere other then the dealer.
View 1 RepliesLexus LS 2007+ :: CEL Code P1235 - High Pressure Fuel Pump Out Of Range
I have 2008 LS460 done 30,000 miles since last few days. I have CEL and when i hooked it to a reader the code came out P1235 "High pressure fuel pump out of range" any one had this problem before!
View 3 RepliesFord Super Duty (1999-2016) :: 2010 F250 - High Pressure Fuel Pump Failure
I have a 2010 f250 6.4 About two months ago the truck just quite on me. I am a farmer in south jersey and have a decent background in diesel motors. First thing that came to mind was fuel. I assumed I was having a fuel issue (clogged filters, failed pump, etc.) truck only had 45,000 miles on it so I took it to my local dealership for what I assumed would be a warranty job. I dealer service all my trucks while under warranty. Long story short I was told it was a fuel contamination issue which scared the walls of the hpfp throwing metal pieces into the injectors, fouling them.
I would need all new injectors, fuel rails etc. as well as new filter housings, fuel tank cleaning, etc. I had receipts for every drop of fuel put in the vehicle and fought all the way to through the dealership to Ford who sent out a rep and who denied the warranty work. Fortunately my insurance company covered the ordeal and all repairs were completed. I got the truck back and 2 weeks later the truck died on me again. I called the dealership back who supposedly warranted the repairs but there first words were there is no way it is their problem, they would look at it but I have to consent that if they find it is contamination again I am responsible for the repairs which we all know just to diagnose they have to remove the cab etc.
I of course lost my mind and told them this is there issue and there is no way in hell I am that unlucky that I received 2 bad tanks of fuel from 2 different high volume highway side fuel stations in the same 2 months. it is obvious they missed something or there is another issue that was not addressed. They claim there is no way they missed something. I am at a standstill.
Ford 6.7L Power Stroke Diesel :: 2011 F250 - Water In Fuel / Sighs Of Rust In High Pressure Pump?
Recently my 2011 F-250 Diesel with 21,000 miles seemed to start hard one morning. After starting the truck it ran well that day and started fine. The next morning it would not start. Had it taken to the dealer and they went to work. Started at the fuel filters and replaced low pressure fuel pump. Thought a piece of the defective pump had moved up fuel line. Removed high pressure pump and found signs of rust. All regular service intervals have been met. Didn't see this coming. No water in fuel light or other warning.
View 14 RepliesHyundai - Elantra :: Pump Nozzle Keeps Cutting Off When Filling Gas Tank
Having trouble filling gas tank, the pump nozzle keeps cutting off. Have to fill by dribbling the fuel in until filled. What the problem might be?
View 5 RepliesGolf IV / Jetta IV :: VR6 Not Getting Fuel At All From Pump
Recently I bought a aem fuel pump only to find out it was for a vr6... go figure. so i said no big deal took it off and put my old one back on. Everything worked fine before now but now that i have put the old fuel pump back in i am not getting any fuel at all.
View 6 RepliesGolf IV R32 :: Can Upgrade Fuel Pump Only?
However, my fuel pump seems to be having a small issue intermittently. So I was wondering if you can upgrade the fuel pump without upgrading anything else? Is that acceptable or would it mess things up? I plan on getting the DTM kit in the future.
View 3 RepliesGmc - Yukon :: 2002 - Cutting Off At High Speeds
Have a 2002 Yukon 5.3 ltr engine (155K miles) that likes to cut off at highway speeds. Usually happens after 4 or 5 hours of running at 70 to 80 mph. Strangely if I set the cruise control and do the same speeds, nothing... When it happens I end up coasting to the side at the roadway and sitting there for 15 or 20 minutes and it'll start right up and usually go the rest of the way. I've talked to a couple repair shops and they have checked service bulletins and have never been able to find anything. Will be driving to Connecticut for the 4th and not looking forward to being on 95 with the possibility of this happening again.
View 2 RepliesGolf IV R32 :: How To Test Stock Fuel Pump
I need to test the stock fuel pump. Best way of doing so?
View 8 RepliesGolf IV R32 :: Fuel Pump Fuse Keeps Blowing
My R32's Fuel Pump Fuse keeps blowing. This started after driving my car in a bad rainstorm. I think water may have gotten in the door which could be causing the short, but I am not sure. This car has two fuel pumps as it's been modified. I know for a fact the main fuel pump works as it did prime after replacing the fuse (then letting the car sit over night then opening the door). Right after the fuel pump primed though, the fuse blew. I decided to replace the fuse and start the car. The car started and ran for maybe a second or two before the fuse blew. I took a look at this thread in regards to the fuel pump not working as I thought the fuel pump was dead till today. I was wondering what are the possible problems that could be causing the fuse to blow? Could it be the relay? Could it be the switch in the door shorting? Also, where would I find the relay? I know it's under the dash, but is it under the panel on the passenger side or driver side?
View 1 RepliesGolf IV / Jetta IV :: 2003 - Symptoms Of Fuel Pump Going Out
So lately have had few symptoms of fuel pump going out and all that but tonight randomly wouldn't start and I mean no power, no lights, no turn over, no anything like my key fob won't even set my alarm or unlock car is this another symptom.
View 12 RepliesGolf V R32 :: Fuel Pump Doesn't Always Prime In The Morning
My R is garage kept, and every morning when I open the door, I can hear the fuel pump make a quick priming run. Well, not "every morning"; sometimes it doesn't do it's two second prime, and when that happens the car usually takes two cranks to start.
(I know that there is a timer. If you have been driving the car, shut the car off, close the door, and then open it, it is not going to prime, but I'm talking about after the car has been sitting all night.) This issue could be related to my door-lock-craziness issue.