Sonata I45 (YF - 2011+) :: Gas Leak At High Pressure Fuel Pump
I have a gas leak at the connection of the High Pressure Fuel Pump and high pressure fuel pipe. Gas drips and sprays out from the nut area (see pic). The car take a several seconds to turn over to start.
What is the most likely cause? The car is out of warranty, so trying to repair myself without having to replace any expensive parts unnecessarily.
Ford Super Duty (1999-2016) :: 2010 F250 - High Pressure Fuel Pump Failure
I have a 2010 f250 6.4 About two months ago the truck just quite on me. I am a farmer in south jersey and have a decent background in diesel motors. First thing that came to mind was fuel. I assumed I was having a fuel issue (clogged filters, failed pump, etc.) truck only had 45,000 miles on it so I took it to my local dealership for what I assumed would be a warranty job. I dealer service all my trucks while under warranty. Long story short I was told it was a fuel contamination issue which scared the walls of the hpfp throwing metal pieces into the injectors, fouling them.
I would need all new injectors, fuel rails etc. as well as new filter housings, fuel tank cleaning, etc. I had receipts for every drop of fuel put in the vehicle and fought all the way to through the dealership to Ford who sent out a rep and who denied the warranty work. Fortunately my insurance company covered the ordeal and all repairs were completed. I got the truck back and 2 weeks later the truck died on me again. I called the dealership back who supposedly warranted the repairs but there first words were there is no way it is their problem, they would look at it but I have to consent that if they find it is contamination again I am responsible for the repairs which we all know just to diagnose they have to remove the cab etc.
I of course lost my mind and told them this is there issue and there is no way in hell I am that unlucky that I received 2 bad tanks of fuel from 2 different high volume highway side fuel stations in the same 2 months. it is obvious they missed something or there is another issue that was not addressed. They claim there is no way they missed something. I am at a standstill.
Ford 6.7L Power Stroke Diesel :: 2011 F250 - Water In Fuel / Sighs Of Rust In High Pressure Pump?
Recently my 2011 F-250 Diesel with 21,000 miles seemed to start hard one morning. After starting the truck it ran well that day and started fine. The next morning it would not start. Had it taken to the dealer and they went to work. Started at the fuel filters and replaced low pressure fuel pump. Thought a piece of the defective pump had moved up fuel line. Removed high pressure pump and found signs of rust. All regular service intervals have been met. Didn't see this coming. No water in fuel light or other warning.
View 14 RepliesPassat (B6) :: Loss Of Power - High Pressure Fuel Pump Went Out
My wife was driving our 08 B6 yesterday and suddenly had a loss of power. Check engine light was on. Took it to the dealer and we heard back today that the high pressure fuel pump had gone out. I had heard of the TDI's having this problem and I know BMW had to do a recall on the same issue. I didn't know that the 2.0 TSI had this problem.
I'm a little bit concerned 'cause we leased the car for 3 years and didn't have a single problem. I thought it was very solid so we decided to buy the car last month Now my confidence in the car is a little bit rattled.
The car is under warranty. I just hope that this is not the kind of thing that's going to go out every 20K miles! Out of warranty, this repair would have been costly.
Lexus LS 2007+ :: CEL Code P1235 - High Pressure Fuel Pump Out Of Range
I have 2008 LS460 done 30,000 miles since last few days. I have CEL and when i hooked it to a reader the code came out P1235 "High pressure fuel pump out of range" any one had this problem before!
View 3 RepliesSonata I45 (YF - 2011+) :: Fuel Pump Is Whirring Before Start
I have a 2011 Sonata GLS with ~65k miles. I have an intermittent problem with the cranking, but will not start. It sounds like the fuel pump is "whirring" before start, and this only happens once a week or so. Other times, the car starts fine. The gas tank is ~1/4 full also.
There has been another intermittent issue (not sure if it's related) - with the O2 sensor heating coil. The check engine light comes on for a day or two and goes away wit the O2 heater coil problem. However, I'm not sure a sensor coil problem would cause the car to not start when it's cranking.
Could it be the crank sensor issue? Is that issue known to be sporadic?
Lexus SC430 :: Check Fuel Pressure To Verify If Fuel Pump Is Functioning With Pressure Test Kit?
I need to check the fuel pressure to verify if my fuel pump is functioning. What is the procedure and PSI?
Assume that I open the valve on fuel rail with engine off, then connect pressure tester kit, put key in ignition to "on" position, then pump up to specified PSI???
Passat (B6) :: Fuel Pump Failure?
I am curious as to what are signs that a fuel pump is about to fail?
View 11 RepliesPassat (B5) :: 2003 - Fuel Pump Quit / Failure
So at 55,200 miles, the fuel pump on my 2003 decides to quit today. I never got a Recall Letter and when I called VWoA in the past about it they said that my car was not one of those affected, even though it was within the years affected. So what do I do now?
View 6 RepliesFord - Escape :: 2004 - Fuel Pump Repeated Failure
Got this 04 Escape 3.0 FWD for my son's first car. It was his mom's and she drove it for years and parked it when she got another car.
I charged the battery and it is holding a good charge. Car would crank but not start. Fuel pump was not coming on. I pulled it out and applied 12V to the connector terminal and it started running so I put it back in and it worked fine.
Drove it home and cleaned it up, pulled out the bad window regulator, put it in the driveway till the next weekend.
After it sat for 3 days it would not start again. The fuel pump was not coming on. I assumed that the old pump that I revived had died again so I bought a new one and put it in and it ran fine.
Went for inspection but OBD2 was NOT READY so I drove it about 60 miles until it threw 3 codes. P0136, P2270, P2271 (O2 sensor problem).
I parked it again to wait till my next chance to work on it. 3 days later I was going to replace the O2 sensor but when I tried to start it the new fuel pump was not coming on again. (2nd fuel pump to die while sitting in the driveway).
So I figured the new fuel pump was a dud maybe, so I returned it and got another new one and put it in and it worked fine again. So I replaced the O2 sensor. Didn't have time to drive it 60 miles again to READY the OBD2 system for inspection so I parked it for a couple more days.
2 days later I was going to drive it around to make the OBD2 READY for inspection and again the fuel pump does not come on.
3 dead fuel pumps doesn't make sense to me so I have been considering it could be the Fuel Pump Driver Module but have read that's not an issue on the Escape like it is on the trucks. Plus I have been unable to locate where it is on this vehicle.
Ford Aerostar :: Fuel Pump Secondary Circuit Failure
I got a code for Fuel pump secondary circuit failure, how do you fix it? 1990 Aerostar 4.0 2wd with A/T and A/C
View 14 RepliesChevrolet - 1500 :: 1997 Chevy Truck V8 Fuel Pump Failure
Several years ago I had to replace the fuel pump - truck had about 100,000 miles. Within the last 4 - 5 months I have replaced the fuel pump twice and just today (about two months since the last replacement), the fuel pump has failed again. That has been the pattern now for the last several months. I have had the work done by one of the reputable car repair shops in town - they have also done work on my 2004 Impala with no issues with the repair. There must be something else going on besides just the fuel pump going bad. What would cause so many fuel pump failures.
View 16 RepliesFord - Explorersporttrac :: Power Steering High Pressure Hose Failure Leak
Just had dealer repair shop complete power steering fluid flush in Jan 2013. Vehicle now has lost all power steering fluid (April 2013) and dealer repair shop has told me it is due to high pressure hose failure - need to replace & then verify pump condition (dealer repair shop not sure if pump bad until hose replaced to test) for repair bill.. I was told this was not related to repair shop power steering flush because this hose not removed for flush or part of that procedure (at which time a transmission flush & spark plugs replaced (minor tune-up) . Just wondering if any pro mechanic can respond with advice about the relative close time frame these two events & if there may be a probable related reason?
View 4 RepliesTiguan :: 2012 - Loss Of Power / EPC And Check Engine Light - Fuel Pump Failure
Well I had the dreaded loss of power and EPC/Check Engine light happen on Monday. Was driving down the Interstate and all of sudden we just lost power. It did not go completely dead, but it ran like crap. Called the local VW and they advised to bring it in, still under warranty (27k, 26mths) and it turned out to be the high pressure fuel pump. They replaced the pump and the replacement was bad! Luckily they tested it before they got it out the door back to me. Provided me with a loaner and the dealer had to get a replacement pump overnight. Picked up the car yesterday and everything drives the way it should again.
I had already had the software update, but according to the service advisor that was for the fuel pump in the tank, not the one on the engine. Not sure if that is correct, but that is what the advisor told me..
Ford F-150 (2004-2008) :: Code P1237 - Fuel Pump Secondary Circuit Failure
ok i was just driving my 2004 ford f150 truck and it stopped running. I turned the key and it started back up again and then while on idle it stopped again. I took it too auto zone and it showed a code of p1237 which as far as i can see says fuel pump secondary circuit failure. does that mean i need a new fuel pump and how hard is it to replace.
View 1 RepliesElantra XD (2001-06) :: TPS Failure Symptoms And High Fuel Consumption
I'm experiencing some TPS failure symptoms and high fuel consumption.... I've unplugged the ecu harness to measure the voltages, measured a constant 6v on the return signal wire while it should be about 0v. While the input voltage is normal 5v. A strange reading as well is that signal reading with both battery terminals is 6v!!
Would this be a short on the ecu cable or is it a corrupted ECU? Also today I had tough hesitation in the morning while the engine was cold, after warm up it was normal! Is this related or its idle sensor?! ( Plugs and their cables are new)...
Ford 6.7L Power Stroke Diesel :: Whining Sound / Low Fuel Pressure And Reduced Power Warning - Fuel Pump Just Died
So, I just had the fuel pump replaced on my '15 6.7 a month ago and it just died again. (next day edit: it didn't actually die, it showed all the same symptoms)
Same symptoms: whining sound, low fuel pressure warning, reduced power warning.
This time I'm 50 miles from home so I pulled off the road before it shut off. Interesting, I was in a hilly area and my low fuel warning came on too. We are waiting for a tow. I was considering trying to push on but don't want to get stuck in a dangerous spot on the highway. We're in a church parking lot.
So, last time this happened I was on flat road with about a half tank of fuel on a lunch break. I ran a mile after the warnings came on to feel out the issue and to see what would happen. I happened to be only about a mile away from my dealer so I drove that way. I got reduced power warning and then it cut power on me (limp mode). I made it to about 100 yards away before it cut off.
This time, I was in a hilly area at night on a windy two lane road with no shoulders in the woods. I was miles from civilization and was showing below a quarter tank of fuel. ~100 miles to EMPTY. I got the low fuel pressure warning first and then the reduced power mode before the whining noise started. I was climbing a hill on a curve at the time. I drove a quarter mile and then pulled off the road into a parking lot so I wouldn't be stuck on the shoulder. It didn't actually go into limp mode.
I let it sit a few minutes, talked it over with the wife and decided to call for a tow. After talking to the tow truck driver who said he would be an hour because he had to go find a bigger truck, I decided to see what I could do while I wait. I fired it back up and the fuel level dropped to below 1/8 and I was now showing 33 miles to EMPTY. I was parked on a hill with the back end up. I had backed the truck into a space to make it easier for the tow truck driver. I let it run a minute, checked for leaks and it seemed to run fine with no studdering or additional warning lights.
CEL was on but no new warnings. I put in my code reader and pulled the P0087. Just one code. I revved it a bit to see if there were any issues. It seemed fine so I decided to try my luck. I started driving towards home with the intention to stop at the first diesel station to fill up. Truck ran fine. After two minutes of driving gently, heart racing, my fuel level came back up and it now read 88 miles to EMPTY. I drove 11 miles to the nearest station and filled up. No issues. I shut it down. I fired it back up. Still no issues so with a full tank, I drove home the remaining 30 miles without issue.
Planning to take it in to the dealer Monday to get it checked. Could this be from an air pocked due to low fuel level and hilly terrain? Is my new pump dying already? Is there something else going on inside the tank or elsewhere?
Celica :: 90 Fuel Pump - Can Hear Buzz But No Pressure
I've followed steps 2-6 from this image
I don't feel any pressure in the hose from the fuel filter. I can hear a buzz (guessing its from the fuel pump) but no pressure.
I've checked both fuses, the efi main relay, and swapped out the circuit opening relay with a known good one and all checked out good. Only thing left is the fuel pump or the writing and electrical connectors.
Car has pretty much took a dump one morning and has almost no power. I can't find anything else wrong with this car besides this. Is the fuel pump the problem even though I can hear the pump?
Ford - Explorer :: 2003 - No Fuel Pressure / Pump Will Not Run
I have a 03 explorer sport trac that has no fuel pressure the pump will not run. It is a bew pump just replaced it amd drove 4 miles cut it off filled up with gas now it wont run I replaced the pump again thinking I might have got a bad pump but it still wont run. I've checked the relay and inertia switch I have the 5 pin connector on the fuel pump module. 1 wire has good power to it but the pump won't run...
View 6 Replies