Golf VI R :: DSG Tune - Unable To Set Launch Control Over 4000 RPM
DSG tune was supposed to set launch control for 4200, 4300 or 4500 rpm launch but the gearbox will not go above 4000 rpm? My tuner has tried 3 different files (4100, 4500, 4600) on my 2009 S3 but the actual launch control rpm is still 4000.
View 19 RepliesGolf IV R32 :: ABS Control Unit Bracket Part Number?
What is he abs unit bottom bracket part number...
View 3 RepliesGolf IV / Jetta IV :: Beep On Startup - Control Unit Improperly Coded Faulty
Every time I start my Golf there is a beep, the EPC light and ABS light come on and stay on, and the brake warning light starts flashing and continues to flash.
I have had the fault codes read and it came up with the following:
0414 Control unit improperly coded Faulty
0606 Yaw rate sensor Circuit defective.
What these faults actually mean and what might cause them? I'm quite keen to resolve the issue as anything brakes related makes me nervous, plus I do drive the car hard and use the 4Motion system, which I believe utilises the ABS system?
Probably worth mentioning that the car is fitted with a Series 1 Blue Haldex controller, in case that makes any difference?
Golf V R32 :: AC Not Working Due To ECM Tune?
AC would blow cold from time to time and not work other times, I tried a recharge and it did nothing to fix the issue so when I took it in for the 40k service I had them take a look at it and they told me that the tuning of my ECM is causing the AC to not work properly! I have the UM tune for flex fuel.
View 1 RepliesGolf IV R32 :: UM E85 Tune Malfunction
I have the VF-stg II s/c kit with a UM E35 tune, it seems to have a problem mapping or something when in Launch control mode. If I don't turn off the Launch control before I start driving it will cut rpm's around 3k then kick back in after it thinks for a second, also the engine light comes on/ flashes when the power cuts out. It does this especially hard when going from first to second. It does have no lift shift, but not lifting off the gas when shifting doesn't stop the engine cough.
Should also mention that the launch control doesn't seem to work all the time, only once in a while, will the engine max the revs at 3k on start like it's supposed to when LC engaged.
Currently I have a warning light for Performance malfunction in cooling system, which is also confusing because I have replaced both my CTS and Thermostat , however whether or not the MIL is on the LC doesn't work correctly (I clear the code when it comes back) seems intermittent as I can drive a week or so before it comes back on.
Golf/GTI VII :: Downpipe Without Tune CEL?
If I were to install a downpipe on the mk7 and not tune it, will my cel trip. Also if the cel trips is there any damage long term to the car having it on and second if I go to the dealer will I void warranty with a downpipe.
View 14 RepliesGolf/GTI VII :: Remove Tune When Going In For Oil Change
Would you remove the tune for just a regular Oil change? Its not the 10.000 mile service, just made an appointment for the oil change at 6k miles.
I try not to flash as much as possible.
Note: In the future I am planning to change the oil myself with an extractor but not enough time and I plan to do a road-trip of 4k miles by the end of the year, so wanted to let them check everything prior.
Golf V R32 :: Getting CEL On After UM Tune And USP Catless Downpipe?
As the title says I currently have the idiot light on but I can honestly say the ECU might not be adapted yet. what the solution longer O2 spacers etc...?
View 10 RepliesPrius Plug-in 2012-15 :: Front Switches Failed To Control Rear Power Windows
I found this issue today after using my PIP for about a month. Front driver side's windows switch can not open/close the rear windows ( With un-lock button depressed), It can control front passenger side windows.
View 3 RepliesPassat (B6) :: How To Remove Standard AC Control Unit From Dash
How to remove the standard AC control unit from the dash? I tried unscrewing all the visible screws. It gets loose but wont come out. I have a rattle. I am trying to solve.
View 6 RepliesAvalon 2005-12 :: Automatic Volume Control - No Navigation Unit
How to turn off automatic volume control on a 2012 Toyota Avalon with no navigation unit. I just purchased this Avalon and noticed this morning as I drove and listened to music that the volume keeps going up and down as I accelerate and decelerate. I cannot find anything in my owners manual on how to turn off the automatic volume control.
View 2 RepliesLexus SC430 :: AC Control Unit Display Cracked Lens?
Well I cracked the clear plastic lens on the AC control unil while removing it to replace the factory radio. Where I can just get the minimal parts to fix this? Seems all I can find online thus far is only replacement of basically the whole control unit.
View 7 RepliesSanta Fe (CM - 2007-12) :: Climate Control Unit - Blower Won't Work
Have an 07, currently i have the dash all apart and replaced the climate control unit because the blower wouldnt work. Plugged it in and it tested it. Still no blower. What more do i need to check?
View 2 RepliesFord Excursion :: 2004 - AC Control Unit Has Randomly Gone Dead Twice
I have a 2004 Eddie Bauer with 16k miles. The AC control unit has randomly gone dead twice. When I turn off the truck and let it sit for a while (20 min last time) it will come back on and work fine. I took it to the Ford dealer while it was dead so they would see it. They told me however, that if it works when I bring it back they wouldn't be able to work on it. What was the problem? I'm going to Parker AZ this weekend and Phoenix next weekend. I don't want it to be intermittent or crap out all together when I am there.
View 14 RepliesFord A/C :: 1997 - Climate Control Unit - Wiring Harness?
Looking for wiring diagrams for a 97 gran marq. Specifically I want to hotwire, the climate control , to give me heat and defrost for more then 2 minutes an hour. I've got the climate control unit out of the dash, and the relays click just before the heat comes on for a few minutes. Of course that was an invitation to smack things with the screw driver. OOPS If there are no heater fuses hiding, besides the ones over the parking brake, I've now also destroyed the unit. Blocks of wood on the vacumm actuators, and wiring the fan direct will work with my unemployment check just fine. BRrrrrr it cold in the car...
View 2 RepliesGolf IV / Jetta IV :: Losing Power And Boost At 4k RPMs After Tune
I have a 2002 gti with an apt software tune...
Whenever I'm on the interstate in 5th gear for a while. And I'll start to speed up. Once 4k kicks in. My boost no longer works when it normally pushes like 22psi
Then after slowing down. No matter what gear I'm in. It limits back to 10psi of boost and once I hit 4k. It goes super slowe and boost won't work
The guy told me that I should get a smoke test done (idk where or how to do that)for my vacuum lines and that I have a cylinder 4 misfire. It may be a bad coil or spark plug. But I'd like to get some performance out of my car and I don't know what else or where to start. I am new to this.
Ford Aerostar :: 1993 - Airbag Light Blinking / Horn Doesn't Work And Cruise Control Failed
I have a 93 Aerostar 4.0 and it is displaying the blinking airbag light (3-2) and the horn doesn't work and the cruise control failed. I believe it is the clockspring ...
QUESTION: Can the clockspring be repaired or must it be replaced. I do not have a schematic of the electrical components of the clockspring ...
Lexus SC430 :: 2002 - Climate Control Head Unit Don't Work
I know this is a weird post but I am looking for a climate control head unit that does not work. I need the silver covering plate that is part # 55901-24030 that is not damaged.
View 8 RepliesFord - Taurus :: 2001 - Automatic Temperature Control Unit / No Heat
The car is a Taurus Wagon. It does not put out any heat. It is a flapper door issue. I tried changing the blend door actuator as the old one did not move when the temperature was changed from cold to hot. Unfortunately the NEW one doesn't either, nor does it move when left hanging, not in the dash. It is an automatic temperature control unit. When I had the actuator out from under the dash, I could move the blend doors easily with the little lever, and get excellent heat, so I know it's not a heater core issue.
Everything on the dash unit, which includes the stereo/radio controls and buttons to shift the air from floor to defrost seems to work fine. It shows the desired temp, but won't go to it. I have checked two fuses that are supposed to feed the HVAC system. I have even installed a different dash unit from another Taurus to see if it made any difference. That included a second temperature sensor, the "Y" shaped thing near where the white hose connects to the back side of dash unit.
I admit, I'm lost. I don't have a good wiring diagram, and don't know if I could read it well enough if I did.
Is there a relay or something in the system between the controller and the actuator that I don't know about?
Which wire or wires in the multi-pin connector that plugs into the blend door actuator are supposed to be hot at what point?