Ford 6.0L Power Stroke Diesel :: A/C Leak Found - Rubbing Metal To Metal Caused The Pinhole
Getting the RV ready to go for the summer, and no a/c. I started to add freon, and found the leak right away.
It's on the 3/4" pipe that goes right over the upper radiator hose; obviously rubbing metal to metal caused the pinhole. Now I know where that mystery green snot came from all over my radiator hose coming back from Yellowstone last fall.
First thought was to replace the entire pipe. There's an easy threaded connector on the upper end, but way down on the compressor is a strange fitting that looks like a triangle stuck against a cube. I can't see how I'd get a wrench in there very easy anyway. What is that fitting?
I bought a Dorman 3/4" repair kit, but until it arrives in the mail I don't know if I've got enough straight pipe to work with. Do I need to add oil as well as freon once I charge the system again?
Ford Aerostar :: 1989 - Metal Particles On Oil Dipstick
Well, today I was checking the oil in my 1989 Ford Aerostar and noticed that there was more than just oil on my dipstick! I noticed a few small little metal shavings on the dipstick! They looked kinda like tiny pieces of hair, and there were only a few. What this means? I don't hear any noise from the engine (but then again I usually drive with loud music so I may be missing something). I have been trying to listen to the engine recently though. The vehicle seems to drive good, no overheating. The oil itself is quite black, in fact it looks like chocolate syrup.
No doubt the engine could use an oil change, which I'll be doing as soon as I get my paycheck. When I bought the vehicle it needed a quart of oil (which I added) but I've been driving it quite a lot since then and it hasn't been loosing oil. But now I'm worried about these shavings. Has my engine seen better days or is this just normal tear on an engine this old. I'm not sure how many miles are on the vehicle, odometer says it has just slightly over 3000 miles, but its one of these old 5 digit odometers so I have no idea if that's 103000, 203000 or 303000.
Ford 6.7L Power Stroke Diesel :: Metal Particles In Antifreeze
I have a 2011 Ford F-350 with 6.7L I have had cooling issues when pulling a trailer up a grade it heats up where it hadn't in the past. I had it in the shop 4 times before it went out of warranty and they changed the oil cooler and thermostat. The last time it was in the shop was November which it was to cold out to duplicate problem. It's heating up on just about every grade and now it's out of warranty when it should have been fixed last year.
I'm guessing it's the water pump because when I changed the antifreeze there was metal shavings in it. I told my dealer about it and they said it was probably from manufacturing. I haven't called dealer yet because I think it should be covered under warranty since the problem was never fixed after being in the shop last year!
Ford Super Duty (1999-2016) :: Metal Particles In Engine While Drilling Boost Gauge
I may have got a few shavings in the engine while drilling and tapping a hole for my boost gauge on the Y pipe. I am sure I got 95% of the shavings out but am now worried about the 5% that may have fell inside.
View 8 RepliesGolf VI R :: Scraping, Metal On Metal Sound That Diminished A Fair Amount When Brakes Were Warm
I picked my R up three weeks ago tomorrow. I took it in this morning because there has been brake noise from day one. The noise was a scraping, metal on metal sound that diminished a fair amount when the brakes were warm. I only got a very brief conversation with the service agent at the dealership this afternoon, and all he told me is that they had to order in new brakes. I don't know if it's just pads, or calipers or rotors or the whole deal! I'll get the whole scoop tomorrow.
View 5 RepliesGolf/GTI VI :: Screeching / Metal On Metal Noise When Engaging Clutch?
For the past few months, pretty consistently, whenever I engage the clutch from full stop into first gear (it does it when starting in second gear too; and reverse) there is a pretty obnoxious and loud screeching noise that I would liken to a subway/train braking or just metal on metal grinding situation. When I took the car in to Douglas for an oil change and APR Stg 1 flash, they told me it's just the brakes being cold, etc. After driving the car some more, I really doubt that it's the brakes and I can reproduce this regularly by slowly releasing the clutch and get the noise usually just before the gear engages.
That car has just over 16K on the clock and has never been abused. The clutch pedal feels fine and there is no issue shifting into any of the gears other than the noise. No mods other than the APR Stage 1.
Golf V R32 :: Metal On Metal Rattle When Ease Off Brake
I ease off the brake and i hear this rattle coming from my car, like metal on metal. But really high pitched like something got loose or something. Tick tick tick tick. So i give it gas and it goes away. Its only there if i brake and release the brake...So i get home and everything is normal. I go outside and move my car and there's the weird rattle again ...
View 21 RepliesGolf V R32 :: Clunking / Metal On Metal Grinding Sound
This morning on my way to work, pulling into the parking lot around 20mph. I hear a metal on metal grinding noise. (almost to the sound of a muffler dragging on the ground type noise). Then that disappears for a bit, hear a loud metal clunk then some high pitched sound. All within say 30 seconds. Definitely coming from the back, but can not tell from which side.
Things I've checked in the parking lot:
Nothing hanging low, exhaust seems in-tact
It doesn't look like the brake shields behind the rotors are bent or touching
Sounds still happening if on or off brakes , on or off throttle.
It seemed to happen only at lower speeds. Disappeared once I got up to 50mph
Just took it out for a drive, that loud metal clunk happened when I put it into reverse, drove around, no other sounds. I just don't have a warm fuzzy feeling that this will just disappear.
Golf VI R :: Random CEL - Code P0036 Found
Threw a random CEL, took the car to Pep Boys, Code P0036 was found "Oxygen Sensor Heater Control Circuit Bank 1 Sensor 2. What I should do and risks involved if I do not take care of it soon?
View 3 RepliesGolf V R32 :: Oil Found Inside Coolant Reservoir
I always check the fluids, every 2 weeks or so just to make sure everything is fine, yesterday I found oil inside coolant reservoir.
The last oil change was performed 2 weeks ago and the oil that came out of the engine looked normal to me, no coolant in it.
I want to keep this car because is more than a car for me, I have a lot of plans to do with it but damm it getting annoying.
Golf/GTI VII :: Found Insulation Material Under The Steering Wheel
I just touched some weird insulation material under the steering wheel and took a closer look at that area, to find this. Very weird. I don't remember the fuses exposed like this in my old mkV, at least nothing like this ugly.
View 20 RepliesGolf/GTI VI :: Found Stain On Floor, Might Be Coolant Leak
Yesterday I noticed nice fresh pink stain on fresh new concrete after a 20 minute ride, after coming back to the car an hour later. When I open the hood you there was distinct smell of wetness and dampness. I'm at 16k. Also visible at the bottom, under the pulleys dried stain on the plastic shroud. The coolant level is about quarter of an inch below min.
Furthermore I noticed oil build up around plastic intake tube just next to the firewall. So far no CEL and other issues, except my compartment lid in the middle console refusing to close and fully open.
Golf IV / Jetta IV :: Oil Disappearing / Not A Single Indication Of A Leak Found
Our Daughter has added a 3rd Jetta to the family, A 2002 2.0 5 Sp with 123K. Runs like a top...looks great and figured a deal @ $2300... The man used it as a daily driver with about 3 mile run to work.... Oil was black, a little low, and the white sludge on the cap....Oil changed with synthetic (not sure what he was using) added thermostat and temp sensor to fix the cold running codes...and 2000K miles without a flaw.....
Until her oil light flashes and chimes....and she is 2 qts low....
Not a single indication of a leak found, overflow tank is clean, no smoke and the exhaust pipe appears normal, so I'm scratching my head now....
Camry :: White Particles Coming Out From AC Of 2007 SE (2.4L)
When I turn HVAC, doesn't matter fan or A/C, white parts (very similar to salt grain) are coming out from vent grilles and spread all - over the dashboard
I took the car to the dealer Mechanic says the a / c evaporator has to be replaced They have to keep the vehicle for the whole day, disassemble dash completely and replace the part. He didn't mention anything about cabin filter
Prius (2010-12) :: Noticed Black Particles Inside The Car
I see black particles inside the car whenever i drive, i don't know if this is coming thru vent or from outside, or something gets burnt inside which is throwing this . I don't smell anything burning.
View 5 RepliesFord 6.7L Power Stroke Diesel :: Small Particles In DFCM
This is my first personal diesel so first one I've done maintenance on.
Bought the truck with almost 15k miles, it now has just over 16k and I changed the filters when I noticed the underhood filter was the original 3 port style.
There were some very small particles in the DFCM. Maybe dirt from dirty fuel nozzles?
Guessing this is nothing to be worried about?
Prius (2010-12) :: Metal On Metal Grinding Noise At High Speed Above 75mph?
I commute 180 miles a day, 6 days a week. I noticed metal on metal grinding noise(more noticeable) at high speed above 75mph especially on asphalt road. I'm sure noise is there at low speed but not enough to notice. My car has 50,000 miles. Tires? Electric motor?
View 7 RepliesSonata NF (2006-10) :: 2007 - Metal On Metal Sound When Turned Right - Wheel Bearing?
I have a 2007 hyundai sonata, this car is my daily driver. I put 180 miles on it a day around trip. Currently has 180,200 miles on it. Last Friday on my trip home when i turned right I heard a metal on metal sound. I slowed down went straight and it went away. Talked to a few people and I think it may be the wheel bearing. Even if I hit a road reflector it starts up. It's the front left wheel. Get on the breaks it goes away.
So my question is... Wheel bearing??? And can I replace the whole hub and fix the problem or do I have to try and press the bearing out?
Sonata NF (2006-10) :: Metal Hitting Metal Noise From Front Driver Side
I got some coilovers installed last night, they are ksports. i have them on fairly low height as of now but i have noticed every time I hit bumps, I hear a kthunk (metal hitting metal noise) from my front driver side. is it from the coilover nuts itself or something wrong with my control arm? the sound ONLY comes from the front DRIVER side.
View 4 Replies