Ford 6.7L Power Stroke Diesel :: Aluminum Particles In DFCM While Changing Fuel Filter?
I changed the fuel filters today and saw a couple of small pieces of what looked like aluminum or aluminum foil in the bottom. Nothing in the filter itself it still looked good. I will try to post pictures later but I'm not sure it will show up. I don't recall seeing anything the first filter change and this is the second. Is this normal?
View 2 RepliesFord 6.7L Power Stroke Diesel :: DFCM Won't Stop Draining
I am changing fuel filters for the first time. I started by draining the DFCM into a quart container, but after that filled up 6 times I switched to a bucket. So far I have drained over 2 gallons and it shows no signs of stopping. Initially the truck was on a slight incline. That's the way I have always done fuel filters, with the tank lower than the filter. After the first gallon came out, I rolled the truck down to level ground.
View 14 RepliesFord 6.7L Power Stroke Diesel :: DFCM Housing Broke?
I was twisting off the DFCM housing when I heard a pop and alot of fuel leaking. It appears I sheared off the 32mm plastic nut. I know for a fact that I was turning it counter clockwise just like the manual stated. Now what do I do? I cant run my SD can I? The simplest solution is to get another housing and install it but im not sure ill be able to get the remnants of the original housing off with out the nut to twist it. I watched Epics video on changing the filter and his came off with little effort? My same story just different result.
View 14 RepliesFord 6.7L Power Stroke Diesel :: Metal Particles In Antifreeze
I have a 2011 Ford F-350 with 6.7L I have had cooling issues when pulling a trailer up a grade it heats up where it hadn't in the past. I had it in the shop 4 times before it went out of warranty and they changed the oil cooler and thermostat. The last time it was in the shop was November which it was to cold out to duplicate problem. It's heating up on just about every grade and now it's out of warranty when it should have been fixed last year.
I'm guessing it's the water pump because when I changed the antifreeze there was metal shavings in it. I told my dealer about it and they said it was probably from manufacturing. I haven't called dealer yet because I think it should be covered under warranty since the problem was never fixed after being in the shop last year!
Ford 6.7L Power Stroke Diesel :: 2015 - Shaking Under Slight Load Due To A Small Incline And Loud Diesel Sound
So I have just over 14k on my 2015....... I love the truck but have had a few small issues. I had a water leak coming in from the roof that would leak through the grab handle. Nothing major dealer replaced one clearance light seal and they said the windshield needs to be re sealed.
Then I had a god awful irritating squeak in the dash..... It only does it late In the day when it's been hot. The dealer said it was a loose air bag. I have had the truck back a week and it's doing it again.
Those are little issues that will get resolved...... I hate having problems with a brand new vehicle but I understand it happens and that's what warranty is for.
I also reported a bad shake to the dealer...... The truck will shake very violently and have a very loud "diesel" sound. It's very specific at when it occurs. It has only done 4 times in the past 6 weeks including today. The odd thing is the 4 times it has done it has been the same time of day in the exact same spot on the exact same road!!!!
Basically I leave my office sit in some traffic and by the time I get to the parkway it has been35 minutes or so. Only happens in 6th at 60 which is roughly 1,400rpm a slight load due to a small incline and it shakes real bad! The typical "diesel" sound you get when under a load is very pronounced almost to a knock. It will continue to do this as you slowly increase throttle until it down shifts and then goes away. I also caught it doing it and I manually shifted to 5th and it went away.
Because of the rpm at which it happens with slight load only doing it in 6th I lean to a Trans issue and more so a converter problem. It feels like converter shutter. I just don't understand the engine sound.
I gave very descriptive info to the dealer..... Several techs drove it and could not duplicate. I just picked the truck back up last Thursday and the dash squeak is back and the shake happened yesterday and again today. So I am a bit irritated to say the least.
I really hate the fact that I know there is a problem but I also understand if a tech can't duplicate it he can't diagnose it. However today I did get a video of it with my phone so they will know I'm not making this crap up!
Ford 6.0L Power Stroke Diesel :: Small Amount Coolant In Oil?
I have a 2007 F350 with 140,000 miles. I just received my first oil analysis from Blackstone and it shows a small amount of coolant in the oil (296ppm Potassium, 30ppm Sodium). Iron at 47ppm and Lead at 12ppm are elevated as well. This is at the end of a 5000 mile oil change.
I have no oil analysis history to say if this has been occurring for any length of time, and have no runnability issues. Oil/coolant temp delta is 8-10F unless towing, and I have seen no coolant loss since replacing the degas bottle a couple of months ago.
Where to look first. It seems most oil/coolant encounters result in the oil going into the coolant, not the other way around. I haven't done an analysis, but have not seen any oil residue in the degas bottle.
BTW, no coolant shows up on the dipstick either, so it is a small leak at best.
Ford 6.0L Power Stroke Diesel :: Small Puddle Of Oil Under The Truck
I got out of home depot and there's a small puddle of oil under the truck. Open the hood and it looks like oil is shooting out from somewhere on the pass side. The Ac box, pass valve cover, and turbo down pipe have oil on them. The oil looks like its shooting onto the bottom and side of the down pipe. I ordered some new vc gaskets, is there anywhere else the oil could be coming from. I had it idling in the driveway and I don't see and oil shooting out. Is there a way to rev the motor from the engine compartment?
View 6 RepliesFord 6.0L Power Stroke Diesel :: Small Power Steering Leak Where Master Cylinder Bolts Onto Hydroboost
2007 F350... I noticed I have a small power steering leak where the master cylinder bolts onto the hydroboost. Is there a o-ring or seal between the two? or do I have to replace the hydroboost? Been looking online for a schematic but can't seem to find one.
View 13 RepliesFord 6.0L Power Stroke Diesel :: Wrench Light Comes On - Small Oil Leak
I have a problem when I have been on the road for about an hour or more the wrench light comes on. There is no change in how the truck runs, and when I run a systems check it says that all of my temps are good to go. The one think I have noticed that the next morning I have a small oil leak on the ground on the days that the wrench has come on. The egr valve was just cleaned. I am getting ready to make a trip across the country with a 10,000 lb trailer so I am a little worried about this. Can I take it in to a shop and have them get a code when the light isn't on? Also I am replacing all of the glow plugs this weekend but from what I have read it shouldn't have anything to do with the wrench light.
View 9 RepliesFord 6.0L Power Stroke Diesel :: 2004 - Small Stud On FICM Bracket
Late 04 6 liter, I'm in the process of putting my engine back together after doing studs. head gaskets ..etc. Its been awhile since I took it apart, and my memory isn't quiet what it use to be. There's a small stud on the ficm bracket, nearest the firewall and I honestly don't know what mounts to it. Ground wire maybe?
View 5 RepliesFord 6.0L Power Stroke Diesel :: Small Leak At The Rubber Coupling Between EGR Tube And Oil Cooler
I am doing the usual upgrades on a 2005 F250. What started as a small leak at the rubber coupling between egr tube and oil cooler turned into doing everything else while motor is down this far.
I am curious what the difference in the upgraded oil cooler is? Well besides not prone to failing as early.
Ford 6.0L Power Stroke Diesel :: Small Leak On Upper Secondary Fuel Filter
(E350 van)... I smelled diesel fuel inside the van tonight and used my flashlight to investigate the leak. The cover around the blue spring is damp.
Before I remove every again to gain access to the filter housing to fix the leak, what I am may encounter. Seems like a good time to do the blue spring upgrade. Can I access the egr valve to inspect and clean?
What are the possible areas to check for the leak? Sometimes finding little problems leads to finding big problems. When my FICM went out I discovered the battery terminal clamp was broke.
Ford 6.7L Power Stroke Diesel :: Primary Radiator Leak / Small Drip From Front Driver Side
I have approximately 66,000 miles on my 2013 F250 truck and noticed a small drip from the front drivers side around 40,000 miles. That random drip is now a leak and the truck will be going into the shop to replace the Primary Radiator.
I absolutely love this truck, but what a disappointment that this isn't a recall. What scares me is that my buddy who has a 2014 F250 will be going in for his second primary radiator in 3 years of ownership.
Ford 6.0L Power Stroke Diesel :: Small Black Smoke Puffs And Intake Popping Noise When Accelerating
Title says it all... Starts & idles pretty good. No codes. Has decent power on mild acceleration, any time you step on it more than 1500rpm it lets out little black puffs of smoke and intake makes that popping sound and truck jerks a little...EGR delete. HPO pressure is good. Injectors are fresh as of a year ago. Valves? Lifters? Turbo?
View 14 RepliesFord 6.0L Power Stroke Diesel :: Small Coolant Leak Coming From The Passenger Side Near The Back Of Engine
I have a small coolant leak coming from the passenger side near the back of the engine that forms a spot about the size of a dinner plate if it sits for a few days.
One thing I noticed is if I turn off the AC selector switch when I park I will get the drip but if I leave the switch on MAX AC when I shut the truck off I do not get any leaking.
It is definitely coolant and not just the condensation from use of the AC. If I haven't used the truck for a few days or if I have run it with the AC off I will get the drips.
If I run with the AC on and leave the switch in the on position when I shut the truck off it won't leak. I have tried to locate it from looking above and below but can't determine where it is coming from.
Ford 6.7L Power Stroke Diesel :: 2015 Small Drip Of Coolant Coming From Corner Of Radiator Near Drain Valve
Have a 2015 King Ranch with 72k miles. I noticed today a small drip of coolant coming from the corner of the radiator near the drain valve.
The truck is deleted however before it was deleted I did purchase an extended warranty through Flood Ford. What are the chances they will deny a warranty claim on this because of the dpf and egr delete?
Ford 6.7L Power Stroke Diesel :: 2012 F250 - Small Leak Puddle Under Front Driver Side Frame
I dropped the F250 (30k miles) off at the dealer yesterday- in the last several days I've noticed a small leak puddle under the front drivers side frame member. I asked the service writer if they had had many trucks in for the radiator leak and he said "no". He has heard the waste gate solenoid buzzing the last two times I've stopped in for routine service and had said they would fix it when I left it with them.
View 9 RepliesFord 7.3L Power Stroke (1999-2003) :: Small Oil Leak Around HPOP?
The leak drains into the first valley of the block. This is after a cleaning and about 300 miles driving. I thought it may be the IPR but, it's looking pretty dry:
Some more pics .....
The HPOP line fittings are dry too. Where else do there the HPOP's tend to dribble a leak of oil from?
Ford 7.3L Power Stroke (1999-2003) :: Switched To Red ELC Now Small Leaks?
I switched to red ELC back in September , bought a billet thermostat housing , and did the "dual alternator " upper hose. now i seem to be getting small leaks around my hose connections and thermostat housing. I don't have any pics yet but I'll get some. It looks like it barley leaked. Then dried up
I re tightened everything again but no difference. My coolant level hasn't dropped or Anything that's why I haven't been too concerned. Here's when it first started happening