Golf IV R32 :: CEL Code P2181 - Performance Malfunction In Cooling System
The code in question is:
18613 - Performance Malfunction in Cooling System
P2181 - 008 - Implausible Signal - MIL ON
Long story short, there are 5 main reasons this problem can pop up, listed in order of likelihood, least to greatest:
1) Coolant sensor
2) Thermostat
3) Bad fans
4) Coolant mixture
5) Water pump
It's a fun catch-all code that can be thrown from any of those. Given that our cars are approaching the 6 year mark, the coolant sensor & thermostat are the most likely culprits. Most of us up on maintenance have already done the green-top sensor, so it's probably the thermostat. In which case, here is the official changing the thermostat DIY: [URL] .....
If you get this code, first check your fans. They're running? Okay, change your sensor & clear it. If it comes back, change the thermostat. If it still comes back, which has been known to happen, investigate further. [IMG] [URL] .....
Passat (B6) :: Code P2181 - Cooling System Performance
Have an '07 2.0T w/92K on it. Check eng light came on over the weekend. Performance is fine etc. Went to AutoZone just to find the general area of the the trouble code since there's no one with a VAG Com nearby. The code is as the title indicates. For the last 5 months the temp gauge has been moving 1-2 ticks to the left (cooler) of the normal 200 degrees, then it will go back to 200 etc. It previously has always stayed on 200 once it warmed up. Does this sound like a thermostat?
If it is, I'm wondering if I could save some money while they were in there to go ahead and change the TB as well? From what I've researched the thermostat is in same area. I was planning on doing the TB at around 100-110k so while it would be earlier than planned I'd do it if it meant saving a bit from the combo work.
Passat (B6) :: Code P2181 - 008 Performance Malfunction In Cooling System
This code came up on my car, what it means or what part needs to be replaced.
008577 - Performance Malfunction in Cooling System
P2181 - 008 - Implausible Signal - MIL ON
Freeze Frame:
Fault Status: 11101000
Fault Priority: 0
Fault Frequency: 2
Mileage: 84971 km
[Code] .....
Golf IV / Jetta IV :: CEL On For Code P2181 Coolant System Performance
Like the title states, I've got P2181 (coolant system performance) CEL on again. I've had this code before and finally had everything serviced. It was off for 5k miles! I've spent a lot of time diagnosing this on the previous occurrences, and was 99% certain it was the thermostat due to the coolant temp dropping a notch or so when engine braking* on the interstate for more than a few seconds.
The current issue is mainly that the car will not heat up quite as fast, but it will not go lower from engine braking for a good chunk of time. I'm getting fairly poor MPG compared to what I was getting a month or two ago. The major changes are winter fuel blends and winter tires, which I'm sure affect the MPG a little, but I would hope not as much as I am seeing. Old average was around 27mpg combined and 30 or so for mostly highway, now I'm getting 24 tops. This is likely due to engine temps not being up to allow for most efficient fuel burning.
First plan is to change the CTS and see if that will fix it. If the code comes back after that, I'll have to check the thermostat and coolant mixture, but I wouldn't expect it to last only 5k miles.
Current: 105k
Thermostat and coolant changed at 100k
Water pump at 80k
CTS sometime around 70k
Engine braking lowering temp due to no fuel being ignited and coolant still circulating through the system if thermostat open.
Passat (B6) :: Code P2181 - Malfunction In Cooling System
I've recently started popping up a random P2181 performance malfunction in cooling system.
It's so random and shows no signs of any other problems that I'm confused. Temp gets hot, stays exactly where it should be, 200. Never gets a tick hotter, or even close to above 200. Air works, heat works fine. No loss of power. It only seems to come on when I really put my foot down.
Prius (2004-09) :: Code P0A93 - Inverter Cooling System Performance
I have a 2007 Prius, and bought it used about 4 months ago. I have not had any issues with it until last night. Last night I was driving home and the red triangle with the “ ! “ in the middle and check engine light came on. The car seems to be running fine, but it scared me to see the lights come on...so this morning I called my local Toyota dealership.
NOTE: I recently went to them for an oil change and they informed me that I had three recalls on my vehicle that needed replacing, but I did not get them replaced because I was told it would take 5-6 hrs (which I didn’t have at the time).
Anyway, they told me that it would cost $70 to have the codes read...and that did not include parts that may need replaced... I thought that sounded a little high for just having the codes read so I went to my local Autozone and they gave me this code:
P0A93 - Inverter Cooling System Performance
Golf IV R32 :: Got Cooling System Performance Light
So i got a cooling system performance light and haven't had time to change the sensor out along with the housing... But
Last night i was stopped to see if it was still there after a little driving and it was indeed. So i figured i would try and clear the code to see if that work and it did. I cleared the code and almost instantly with the car still idling, the ticking sound went away.
What could have cause the ticking sounds at all in relation to the cooling system?
Golf IV R32 :: CEL Code Is P2181 For Coolant System
So after 1.5 years of owning my R I got my first CEL. The code is P2181. I did some searching and this is a problem in the coolant system.
In the previous posts about this these were the possible problems:
1) Coolant sensor
2) Thermostat
3) Bad fans
4) Coolant mixture
5) Water pump
I checked my car and I have the updated green coolant sensor. My question is should I just get a thermostat and replace that or should I replace the green coolant sensor with another one? Do the green ones go bad?
Passat (B6) :: Engine Error Code P2181 / Coolant System
If I am not mistaken this error code means that I have a coolant system issue. I've checked both of my radiator fans and they both spin, so it makes me think that its the thermostat issue. If I am correct, any link to a replacement part? Or better yet a DIY? I've searched and no dice.
View 12 RepliesGolf/GTI VI :: CEL Is On And Code Is P2181
My CEL is on and the code is a p2181 (cooling system performance). My car isn't overheating or taking too long too warm up, so I'm guessing its not a bad thermostat or water pump. I want to replace the ECT sensor, but I haven't found any instructions for doing this on the 2.0TSI engine. Aren't there 2 ECT sensors? One on the lower radiator hose and one on the thermostat/water pump housing.
Lower radiator hose ECT sensor: [URL] .....
Thermostat/water pump housing ECT sensor: [URL] ....
Which one do I need to replace? The radiator hose ECT sensor seems easy enough to access, but I'm not sure what needs to be removed to replace the sensor on the thermostat housing?
I noticed that the temperature isn't always sitting at 190. It will drop slightly below on occasion for short periods of time. Could this actually be a thermostat issue?
Golf IV R32 :: CEL Came On / P2181 Code
CEL came on yesterday and pulled P2181 which looks like it could be a bunch of different things. Taking it to the shop tomorrow morning so any guesses? BTW I would attempt the easy things first but it is my daily so.....
View 8 RepliesGolf IV R32 :: Odd Code Combo - P2181 And Cylinder 2 Misfire
Started happening recently where I can't bring her past 5k without misfiring on cyl 2 and throwing the p2181 code. I changed the coil just to be sure, but I do know my coolant sensor wires were a little snug from the TB being so close.
View 1 RepliesGolf IV R32 :: CEL Code P2181 - Radiator Fans Do Not Turn On
So this seems to be a common code that is thrown when you near 100k miles, I'm at 77k .. This thread seems to be the most organized [URL] ....
"Long story short, there are 5 main reasons this problem can pop up, listed in order of likelihood, least to greatest:
1) Coolant sensor
2) Thermostat
3) Bad fans
4) Coolant mixture
5) Water pump "
My issue is that the only ones I'm (probably) able to rule out is coolant mixture and bad fans. My radiator fans do turn on from time to time, so I thought I'd ruled that out (unless it would throw a code for not turning on at appropriate times?)
I heard of a test to turn on your AC and see if they turn on, but my AC hasn't blown cold air like ever, so I don't know if that affects the test (probably not?)
A couple years ago I had a shop replace the original thermostat with the new one, or was it the coolant sensor, or both (ugh, I don't remember!) That leaves thermostat, coolant sensor, and water pump.
I guess my main question is is there anyway to find out which it is between these 3, without spending so time, money, parts etc? It doesn't seem the coolant sensor is easily accessible for one.
My car has been really slow recently but I also need to change the spark plugs, I'm doing that this week. I cleared the CEL/P2181 code and it returned a few weeks later,
I'm starting to change my mind about this car being easy to maintain/reliable, I'm always on time with maintenance and with only 77k miles on a 2004 car.
Golf IV / Jetta IV :: Code P2181 Come Up Twice - Small Coolant Leak And Some Oil Mix?
Had a P2181 come up twice now... both on startup on a cool morning. Came on again this weekend. Monday morning I noticed a small coolant leak under the front of the car directly in line with the passenger headlight, but it only leaks if I park the car with the front down a slope. I parked uphill on Monday night and no leak in the morning, but I backed in facing downhill on Tuesday and had a small leak when I checked late last night.
So, last night I broke out the UV/black light -- G12 seems to fluoresce yellow'ish. I couldn't see much, so it is a small leak. There is some wetness on the bottom passenger side of the rad that's dripping over the back side of the front bumper/lip. No wetness around any other hoses, thermostat housing, temp sensor, turbo lines. But that's all from the top view. No time yet this week to get it up on stands to pull the bumper/splash shields for a closer look either.
I am little concerned tho as there's some wetness around the valve cover and when I pulled the oil cap my eyes suggested a bit of fluorescence under the cap and inside the valve cover. I'm a little worried oil and coolant may be meeting up somewhere... And to think... I was just in the process of getting geared up to do brakes and plugs before getting a modest tune (stage 1).
Accent MC (2006-11) :: Code 0496 Popped Up For EVAP System - Constant Bubbling In Fuel Tank
A few days ago code 0496 popped up for evap system problems. The fuel tank is very pressurized and there is a constant bubbling heard in the fuel in the tank with the gas cap removed. Sounds like blowing air through a drink with a straw. I have never had a problem like this with any car in over 45 years.
View 1 RepliesGolf VI R :: Code P2293 - Fuel Pressure Regulator 2 Performance
I've been having this code come up for a couple weeks now off and on. Currently I am stage 2 Giac. I have the autotech HPFP upgrade and was installed a couple months ago. Recently It threw the code and lasted for a couple days then went away. I notice that if i get on it pretty hard for a while the code will come back, im guessing due to lack of fuel. I pulled the fuel pump and checked the cam follower and it looks almost good as new still. Thought it would be the sensor but doesn't seem like it as the CEL turns off after a while of not getting on it.
View 10 RepliesSaturn - Vue :: AC Cooling Performance Appear To Get Reduced When Vehicle Parked
I have a 2004 Saturn VUE, 3.5 L, V6 (212 CI), AWD, with 164,000 miles that I purchased used in Michigan from a GM Dealer about a year back.
The air condition on this VUE works great as long as the vehicle is moving on the road. When in idle and parked, the cooling performance appear to get reduced and soon it will blow not so cold air until the vehicle start to move and gradually the performance will get better and perform well. How did you get it resolved?
Ford Exhaust System :: Position Of Muffler In The System Affect Performance?
Was just mulling over redoing part of the exhaust system on my truck. As it stands the original y-pipe is still intact but some bozo reduced the rest of the system down to 2.25 inch with an ancient glasspack for a muffler. Maybe he thought it would net some kind of benefit, maybe he was just throwing together parts from his backyard. Either way it's going, I'm planning to keep the Y-pipe but step it up to 3 inch with a Flowmaster chambered muffler and I just suddenly wondered if the position of the muffler in the system affects performance. If I put it directly after the Y-pipe the exhaust pulses would hit it sooner...
View 14 RepliesFord 6.7L Power Stroke Diesel :: 2012 - DEF System Fault - Reductant System Performance
Sunday I received the dreaded DEF system fault message on my 2012 CC SRW SB FX4 with 7800 miles on it. Warned me that speed will be reduced to 50 MPH in 50 miles. I have a CTS Insight, so I checked for DTC's. First one was P2200 - NOx sensor circuit (Bank 1, Sensor 1), the second one was P204F - Reductant system performance (Bank 1).
After 50 miles it warned me that speed would be reduced to 50 MPH on next restart. Sure enough, Monday morning speed was limited to 50. I took it to the dealer, but I should have left it running. When the service guy started it, the fault had cleared and it no longer showed the P2200 NOx sensor code, although the P204f code was still there.
My question is, why in the world would Ford make it so that the code is cleared if the fault goes away, especially after putting you through the 50 MPH limit scenario?
Dealer did a reflash and said its OK now, but I'm not so sure. My trucks build date is 10/6/11. I read TSB 11-11-13 which states the NOx sensor module should be replaced for P2200 on trucks built before 10/11/11. Is that only for a persistent P2200?