Golf/GTI VI :: CEL Is On And Code Is P2181
My CEL is on and the code is a p2181 (cooling system performance). My car isn't overheating or taking too long too warm up, so I'm guessing its not a bad thermostat or water pump. I want to replace the ECT sensor, but I haven't found any instructions for doing this on the 2.0TSI engine. Aren't there 2 ECT sensors? One on the lower radiator hose and one on the thermostat/water pump housing.
Lower radiator hose ECT sensor: [URL] .....
Thermostat/water pump housing ECT sensor: [URL] ....
Which one do I need to replace? The radiator hose ECT sensor seems easy enough to access, but I'm not sure what needs to be removed to replace the sensor on the thermostat housing?
I noticed that the temperature isn't always sitting at 190. It will drop slightly below on occasion for short periods of time. Could this actually be a thermostat issue?
Golf IV R32 :: CEL Code Is P2181 For Coolant System
So after 1.5 years of owning my R I got my first CEL. The code is P2181. I did some searching and this is a problem in the coolant system.
In the previous posts about this these were the possible problems:
1) Coolant sensor
2) Thermostat
3) Bad fans
4) Coolant mixture
5) Water pump
I checked my car and I have the updated green coolant sensor. My question is should I just get a thermostat and replace that or should I replace the green coolant sensor with another one? Do the green ones go bad?
Golf IV R32 :: Odd Code Combo - P2181 And Cylinder 2 Misfire
Started happening recently where I can't bring her past 5k without misfiring on cyl 2 and throwing the p2181 code. I changed the coil just to be sure, but I do know my coolant sensor wires were a little snug from the TB being so close.
View 1 RepliesGolf IV R32 :: CEL Code P2181 - Radiator Fans Do Not Turn On
So this seems to be a common code that is thrown when you near 100k miles, I'm at 77k .. This thread seems to be the most organized [URL] ....
"Long story short, there are 5 main reasons this problem can pop up, listed in order of likelihood, least to greatest:
1) Coolant sensor
2) Thermostat
3) Bad fans
4) Coolant mixture
5) Water pump "
My issue is that the only ones I'm (probably) able to rule out is coolant mixture and bad fans. My radiator fans do turn on from time to time, so I thought I'd ruled that out (unless it would throw a code for not turning on at appropriate times?)
I heard of a test to turn on your AC and see if they turn on, but my AC hasn't blown cold air like ever, so I don't know if that affects the test (probably not?)
A couple years ago I had a shop replace the original thermostat with the new one, or was it the coolant sensor, or both (ugh, I don't remember!) That leaves thermostat, coolant sensor, and water pump.
I guess my main question is is there anyway to find out which it is between these 3, without spending so time, money, parts etc? It doesn't seem the coolant sensor is easily accessible for one.
My car has been really slow recently but I also need to change the spark plugs, I'm doing that this week. I cleared the CEL/P2181 code and it returned a few weeks later,
I'm starting to change my mind about this car being easy to maintain/reliable, I'm always on time with maintenance and with only 77k miles on a 2004 car.
Golf IV / Jetta IV :: Code P2181 Come Up Twice - Small Coolant Leak And Some Oil Mix?
Had a P2181 come up twice now... both on startup on a cool morning. Came on again this weekend. Monday morning I noticed a small coolant leak under the front of the car directly in line with the passenger headlight, but it only leaks if I park the car with the front down a slope. I parked uphill on Monday night and no leak in the morning, but I backed in facing downhill on Tuesday and had a small leak when I checked late last night.
So, last night I broke out the UV/black light -- G12 seems to fluoresce yellow'ish. I couldn't see much, so it is a small leak. There is some wetness on the bottom passenger side of the rad that's dripping over the back side of the front bumper/lip. No wetness around any other hoses, thermostat housing, temp sensor, turbo lines. But that's all from the top view. No time yet this week to get it up on stands to pull the bumper/splash shields for a closer look either.
I am little concerned tho as there's some wetness around the valve cover and when I pulled the oil cap my eyes suggested a bit of fluorescence under the cap and inside the valve cover. I'm a little worried oil and coolant may be meeting up somewhere... And to think... I was just in the process of getting geared up to do brakes and plugs before getting a modest tune (stage 1).
Golf IV / Jetta IV :: CEL On For Code P2181 Coolant System Performance
Like the title states, I've got P2181 (coolant system performance) CEL on again. I've had this code before and finally had everything serviced. It was off for 5k miles! I've spent a lot of time diagnosing this on the previous occurrences, and was 99% certain it was the thermostat due to the coolant temp dropping a notch or so when engine braking* on the interstate for more than a few seconds.
The current issue is mainly that the car will not heat up quite as fast, but it will not go lower from engine braking for a good chunk of time. I'm getting fairly poor MPG compared to what I was getting a month or two ago. The major changes are winter fuel blends and winter tires, which I'm sure affect the MPG a little, but I would hope not as much as I am seeing. Old average was around 27mpg combined and 30 or so for mostly highway, now I'm getting 24 tops. This is likely due to engine temps not being up to allow for most efficient fuel burning.
First plan is to change the CTS and see if that will fix it. If the code comes back after that, I'll have to check the thermostat and coolant mixture, but I wouldn't expect it to last only 5k miles.
Current: 105k
Thermostat and coolant changed at 100k
Water pump at 80k
CTS sometime around 70k
Engine braking lowering temp due to no fuel being ignited and coolant still circulating through the system if thermostat open.
Golf IV R32 :: CEL Popped On / P2181 Code - Cooling System Performance
Last night on my way to go get hammered the check engine light popped on...
"Cooling System Performance"
I have read a few different post, and the last one I read referred to his radiator fans. I know for a fact one of them isn't working and I haven't replaced it yet because it hasn't advisable effected my driving.
So my question is what could be causing this? Also I'm not sure if this matters but my a/c doesn't work either.
Golf IV R32 :: CEL Code P2181 - Performance Malfunction In Cooling System
The code in question is:
18613 - Performance Malfunction in Cooling System
P2181 - 008 - Implausible Signal - MIL ON
Long story short, there are 5 main reasons this problem can pop up, listed in order of likelihood, least to greatest:
1) Coolant sensor
2) Thermostat
3) Bad fans
4) Coolant mixture
5) Water pump
It's a fun catch-all code that can be thrown from any of those. Given that our cars are approaching the 6 year mark, the coolant sensor & thermostat are the most likely culprits. Most of us up on maintenance have already done the green-top sensor, so it's probably the thermostat. In which case, here is the official changing the thermostat DIY: [URL] .....
If you get this code, first check your fans. They're running? Okay, change your sensor & clear it. If it comes back, change the thermostat. If it still comes back, which has been known to happen, investigate further. [IMG] [URL] .....
Passat (B6) :: Engine Light Is On For Code P2181
My engine light is on.I took it to Autozone ,came up with a code P2181.........
#61 FAILED RADIATOR OR WATER PUMP
#62 CHECK ECT SENSOR
No overheating , No Antifreeze leak.....
Passat (B6) :: Code P2181 - Malfunction In Cooling System
I've recently started popping up a random P2181 performance malfunction in cooling system.
It's so random and shows no signs of any other problems that I'm confused. Temp gets hot, stays exactly where it should be, 200. Never gets a tick hotter, or even close to above 200. Air works, heat works fine. No loss of power. It only seems to come on when I really put my foot down.
Passat (B6) :: Code P2181 - Cooling System Performance
Have an '07 2.0T w/92K on it. Check eng light came on over the weekend. Performance is fine etc. Went to AutoZone just to find the general area of the the trouble code since there's no one with a VAG Com nearby. The code is as the title indicates. For the last 5 months the temp gauge has been moving 1-2 ticks to the left (cooler) of the normal 200 degrees, then it will go back to 200 etc. It previously has always stayed on 200 once it warmed up. Does this sound like a thermostat?
If it is, I'm wondering if I could save some money while they were in there to go ahead and change the TB as well? From what I've researched the thermostat is in same area. I was planning on doing the TB at around 100-110k so while it would be earlier than planned I'd do it if it meant saving a bit from the combo work.
Passat (B6) :: Code P2181 - 008 Performance Malfunction In Cooling System
This code came up on my car, what it means or what part needs to be replaced.
008577 - Performance Malfunction in Cooling System
P2181 - 008 - Implausible Signal - MIL ON
Freeze Frame:
Fault Status: 11101000
Fault Priority: 0
Fault Frequency: 2
Mileage: 84971 km
[Code] .....
Passat (B6) :: Engine Error Code P2181 / Coolant System
If I am not mistaken this error code means that I have a coolant system issue. I've checked both of my radiator fans and they both spin, so it makes me think that its the thermostat issue. If I am correct, any link to a replacement part? Or better yet a DIY? I've searched and no dice.
View 12 RepliesPhaeton :: Yellow Engine Warning Light On - Code P2181
My 2006 V8 Phaeton has had its yellow engine warning light on for a few weeks. Around the same time, the cooling fan in the engine compartment stays on after I stop the car - even though its Winter here in Montana. So I got the fault code read: P2181. Seems to be linked to cooling system?
View 18 RepliesGolf IV / Jetta IV :: CEL 2 Codes P0420 And P2181 Came Up At Same Time
I just picked up a MK4 gls 1.8t jetta for a project car.... I wanted to keep the miles off my MK6 gti.... The jetta has 92k miles and the first thing I had done was the timing belt service done as well as a new alternator clutch pulley and oil change... 1 day after I got the car i was driving to work and the CEL came on took it to auto parts store... 2 codes came up
P0420: catalyst system. efficiency below threshold bank1
P2181 cooling system performance
I have the green sensor and I think its time to change the thermostat... My question is is it just a coincidence that both codes came up at the same time or is i possible it is a sign for something else... i just had the thermostat changed 10 min ago...CEL light is gone so i will wait to see if the cat code comes back.
Golf IV / Jetta IV :: 2004 - Getting CEL With Codes P3081 And P2181 - Overheating?
Bought a 2004 Jetta GLI about two weeks ago. Has 80,100 miles. Ran great for about the first week then the check engine light came on for no reason. It is spitting out two codes.
1) P3081
2) P2181
The car still was running good even with spitting these codes so I continued to drive it for another week. Today I was sitting in the parking lot of a store and the car was idling for about 25 minutes while I ran into the store and I come outside from the store and there was a huge lake under my car and the engine was running hot and smoking.
I let it cool down and poured some water into the over flow bubble looking thing and it didn't look like any water was leaking out.
When the water was leaking out it looked like it was coming from the left middle side of the engine.....
Also I would like to add that the car seems to always run a little cold.....it never runs just in the middle like most cars do...
Golf V R32 :: How To Check For The Code
I just bought this car. 41k miles now and I got a solid MIL. How do you check for the code. it idles fine. I read if it's blinking don't drive it.
View 4 RepliesGolf IV R32 :: Code P0601 - MIL On
Car was scanned and this was the result...
16985 - Internal Control Module: Memory Check Sum Error
P0601 - 001 - Upper Limit Exceeded - MIL ON
Can't find a clear answer on this, I was told I need a new ECU....can this be right? Or can I just get a re-flash?
Golf/GTI VI :: DRL Code Lit Up On Dash
Want to get rid of the drl code lit up on my dash... My mechanic said i would have to get some resistors from the local store... Is this true or not ?
View 14 Replies