Ford Excursion :: Middle Wire Of Taillight Broken?
My tail light. The middle wire broke I was thinking of soldering it together?
Is this part specific to the Excursions or can I go to the junk yard and get it from other Fords?
Golf IV / Jetta IV :: 2003 GTI 1.8t Timing Belt Broken?
I recently purchased 2003 gti with a broken timing belt i bought a reman cylinder head did the timing belt, water pump, belt tensioner, cam chain, and cam chain tensioner. I read the service manual and many forums before setting the timing. I got it all set and back together it runs great at the low end but it feels like when it starts to build boost pressure it stops making power. Would i throw a check engine light if the timing was any off? Would it run well on the low end and then lose power if the timing was off or should i be looking in a diffrent direction? I just want to make sure timing is not an issue.
View 1 RepliesGolf IV / Jetta IV :: Rumbling And Clicking At 30+ MPH - New CV Axle Broken?
I have a 2001 gti that I just changed the cv axle on and it feels like it's failing already but there's no play in the axle or place it mounts to the tranny.. Doesn't feel like the last one I removed but rumbles and clicks at 30+mph.
View 1 RepliesGolf IV / Jetta IV :: Downpipe Stud Broken And Code Is P0420?
So I recently bought a GTI and started to fix a couple things. It has a P0420 code so I bought a new downpipe to install. Noticed the stock one was missing 1 of the nuts and the stud had broken off. How get this out? Do I need to remove the turbo? Looks like I do need to remove the turbo to use an extractor set.
View 7 RepliesGolf IV / Jetta IV :: Broken Bolt From Motor Mount Bracket
The other day when i wanted to start the car, I found out my battery was death so i decided to ask my buddy to push me and crank it on gear. Car shakes as normal and engine started, but then i heard a weird noise like if something was rubbing. I turned it off and popped the hood. I found my engine leaning forward and toward the passenger side.
So the next morning, I checked the bay again and i found out that it wasn't the motor mount. Motor mount is ok, but then i found a broken bolt that holds the bracket to the block; the one that goes right next to the water pump to be more specific. Also in the back of the block there is a bolt that hold bracket to the block again and the thread whole was enough weak to break when the other bolt failed. So I did some research and i found that there is a solution for the bolt in back of the block.
What I am concerned is for the on the goes right next to the water pump. It seems that it broke the whole thing including the part where the bolt threads go. I just had a shop install I.E connecting rods, new piston rings, and rebuilt the heads. They put a new timing belt kit and all its job required. I think they might have a bit of fault on this since it had to be removed when they did the timing belt kit. Anyways I don't want to think my block will be a junk now because engine is running like a champ, and that would be a bummer.
-Bolt that is broken in two pieces.-
-And where it is attached to the block-
-Part of the engine where this all goes.-
Golf IV / Jetta IV :: Center Shifter Console Is Completely Broken
I have a 5-speed and my center shifter console is completely broken. I went to the junk yard and didn't find any manuals but plenty of autos. Is an auto console the same? It looks like the only difference is the boot/selector area.
View 2 RepliesGolf IV / Jetta IV :: Engine Bay Fuel Line Connectors Broken
It appears the Engine By fuel line connectors are broken. I searched for DIY'ers on how to fix, but so far I only see those related to fixing other sections on the fuel line, not this upper section. It's on the passenger side. How to fix it?
View 3 RepliesGolf IV / Jetta IV :: Windshield Washer Fluid Hose Broken?
During the removal of my hood. I've broken my fluid line for the windshield washer. Not sure how to replace or if this is able to go back in my hood, I've searched and have fallen short to a decent answer.
View 4 RepliesGolf IV / Jetta IV :: Passenger Side Rear Seat Back Release Handle Broken
I own a 2000 Jetta GLS TDI 5 speed with 501,000 kms on it. The problem I have is the passenger seat back release handle broke off so there is no way to fold down the seat.
View 4 RepliesGolf VI R :: How To Remove LED Taillight Turn Signal
Was wondering how to remove the turn signal bulbs in the OEM LED taillights.. Ordered Some new bulbs and decided to see how hard it was to change out. Removed taillight and located socket the contained the bulb. Looks like it should twist to unlock but only turns a little. looks like it wants to turn counter clockwise.
View 2 RepliesGolf V R32 :: Should Remove Taillight To Replace Bulb?
Got the light bulb symbol in the tach this afternoon. After checking it out, the LR inner bulb seems to be out. Am I correct in assuming I have to pull back the carpet, then remove 2 nuts/washers, and then remove the taillight lens/housing to replace the bulb? Any recommendations on bulb or just stay with OEM? My R32 has 88K+ miles and this is the first bulb to go...
View 5 RepliesGolf IV R32 :: Front Driver Side Headlight And Taillight Not Working
So sometimes my front drivers headlight and drivers taillight decides not to work. Sometimes one will work and the other wont and other times they all will be working fine. I've checked the fuses and the bulbs and they both are fine.
View 10 RepliesGolf IV / Jetta IV :: Hood Latch Broken / Any Way To Pop The Hood?
The latch thing that you pull on to pop the hood has broken, any other way to open the hood up?
View 24 RepliesJetta - Volkswagen :: 2000 - Oil Dipstick Holder Broken?
I have recently inherited a 2000 Jetta. The car runs great however the plastic tube that holds the oil dipstick is broken in two or thee spots. It has been previously repaired with electrical/duct tape. Doesn't seem to leak but I'm wondering if I need to get a new one in there. Is this something I can do at home or does it need to go to a shop?
View 3 RepliesJetta - Volkswagen :: 2002 - Broken Sway Bar Links
My mechanic says I need to replace both front sway bar links on my 2002 Jetta....I am, of course, hesitant to do it at this price. How critical is it to replace? Can I get junk yard sway bars to make it cheaper? And can I do it myself (have no experience fixing anything....
View 11 RepliesPhaeton :: How To Remove Taillight From Trunk
I've having difficulty removing the taillights from the trunk. I'm sure it is simple but there must be a trick to do this properly. I've removed the nuts but I can't bulge the "lockwashers" per the instructions. The threaded stud is a special design and has some type of spring mechanism. I tried removing one of these a few years ago and I broke the stud. How is this done? Below are the Bentley instructions which are not useful.
Volkswagen > Phaeton > 2004-2006
Electrical Equipment
94 - Taillamps Tail light assembly in luggage compartment lid, removing and installing
Removing:
-Switch off ignition, switch off all electrical components and remove ignition key.
-Remove trim for rear lid Body Interior - Repair Group 70 .
-Release the latching mechanism - arrow - and separate the connector.
-Remove bolts - arrows - .
-Remove the lock washers and the tail light housing.
Installing: Install in reverse order of removal, noting the following:
-If a new taillight is being installed, remove the protective foil from the gasket.
-Connect the connector.
-Insert the taillight into the body opening.
Note: When installing the taillight housing, pay attention to the gap dimensions.
-Gap dimensions of tail lamp assemblies .
-Move the taillight by hand into the correct position in the body, hold the position and then tighten the nuts.
-Tighten the nuts using 4 Nm torque.
-Coding or adaptation of the taillight is not required after installation.
-Check the rear light function, Rear light function, checking .
Camry :: 2009 / Taillight Indicator On But No Bulbs Are Out?
The taillight indicator on my display is on, but no bulbs are out.
View 4 RepliesPassat (B5) :: How To Change The Driver Side Taillight
I have a crack in the driver side taillight in my 2003 VW passat GLX wagon. I opened the panel in the rear where the audio amplifier seems to be located. I can find 3 nuts to remove for the taillight and that seems to have loosened up the assembly. There seems to be a fourth fastening point. However, I can't find it. I can't seem to remove the black amplifier rack to get a better view.
View 1 RepliesPassat (B6) :: Taillight Falling Apart And Bulb Out Warning?
I got a "Bulb Out" warning but all the bulbs were working...so I go inspect all the lights on the wagon and notice the taillight is melted and falling apart on the inside! Wtf?? Ugh...!! I've never had something like this before. Is this common? The light still works but its all melted on the inside and the plastic ring on the inside is falling down.... Quick pic...
View 9 Replies