Golf IV / Jetta IV :: Sticking Left Rear Caliper
So I just did my rear brake pads and rotors a few days ago. For the last few months, my e brake hadn't been working well (have to pull it way up, and still weak).
While doing the brakes, I noticed the park brake arm was more or less seized on the left rear. I worked it a bit, and then my park brake worked perfect - 4 or 5 clicks, right on.
Then I noticed it isn't disengaging (brake smoke). I figured the ratcheting mechanism in the piston must be kaput.
So today I got a new (reman) caliper & bracket, installed it, and... still sticking. Cables are fine, the arm is moving fine. I'm now certain that the problem must be hydraulic, but what?
I would think that a master cylinder or booster would cause all the brakes to drag, or at least one axle worth, but that isn't the case. After a short spin on the freeway with little brake use, 3 of the brakes show 40 - 45C or so, and the sticking one shows 150C. (with an infrared thermometer).
During the brake job I noticed the left side was harder to turn in than the right, so I guess that could have been hydraulic back pressure somehow. Didn't seem to notice any damage to the hoses, they look pretty mint. master cylinder still?
I did the rear bearings at the same time. The bearing on the left was bone dry, probably from overheating in the past - I'm sure this POS stuck at some other time too, overheated and lost its grease. right side was fine but I figured might as well do them both.
Golf IV / Jetta IV :: Front End Squealing / Squeaking When Turn Left
2 days ago I changed my driver side wheel bearing and put in a new cv shaft
The axle nut may have been somewhat over torqued but nothing crazy over the spec.
Everything else is as per spec.
My problem is that every time I turn left slow fast sharp not sharp it's making this good awful noise.
It is not a constant squealing. It's every rotation. On off on off on off. No bearing humming or anything when driving straight or turning right. Just left. I'm pretty good at solving pretty well anything with my gti but this one has me stumped
2000 GTI GLX VR6
Golf IV / Jetta IV :: Left Front Tire Hitting Coilover And Making Car To Vibrate
I installed 2 new axles and replaced the upper motor mounts in my car. Now when I turn to the right the left front tire is running against the coilover and making my car vibrate. I put a 5mm spacer to give it some clearance but it didn't make much of a difference. What could be wrong?
View 2 RepliesGolf IV / Jetta IV :: Clunk From Left Front Wheel When Turning At Slow Speeds
I have a 2003 Jetta Wagon with 49000 miles on it. I noticed that when turning at slow speeds (like taking turns in a parking lot) I hear a klunk coming from the area of the left front wheel, and I think I feel it through the steering wheel. Yesterday I was going around a hairpin turn at a shopping mall and heard two clunks. Driving straight it doesn't happen.
View 8 RepliesGolf IV / Jetta IV :: Knocking Noise On Front Left Side When Clutch Pressed
So, I'm having this weird knocking noise on front left (drivers) side. It appears when I'm accelerating and stops immediately when i press clutch.. The noise gets stronger if i accelerate fast and gets faster, faster i go. Surprisingly the noise stops when i lift my car up and starts again at my drive height. Could it be driveshaft joints? And which one more likely? Outer maybe?
View 5 RepliesGolf IV / Jetta IV :: Grinding Sounds Coming From Front Right Area On LEFT Turns
When I turn LEFT at medium to low speeds I hear a "gravel-ly" grinding noise coming from the Right Front area. What could this be? Wheel bearings?
View 1 RepliesGolf IV / Jetta IV :: Right Side Rear Is Set Back Further Than The Left Side Rear
I Have had my 99.5 jetta for 4 years now, car drives straight, no tire wear issues, but from day one I have noticed by looking in the wheel wells of both rear tires that the r/s rear is set back further than the l/s rear, l/s rear looks centered in the wheel wheel and the r/s rear looks to be back further and not centered, no evidence of any rear damage from a previous owner, car drives straight as an arrow , I'm stumped, all four tires have worn even in the past 3 years.
View 1 RepliesGolf IV / Jetta IV :: ASR Light Came On / Running Rough And Smoking With Codes
I was driving along the highway cruising at around 100 km/h when out of nowhere the car started driving a little rough so I look down and the ASR (traction control) light was on. I got off the highway, shut it down and fired it back up. The ASR light was off and car running like normal. When I got home I scanned it and these codes came up:
The catalyst code if from my catless turbo-back exhaust which I plan to fix next month with a tune. Anyway I cleared all codes and continued on my way without any other hiccups. So is my MAF sensor dying/dirty? ECU? N75 valve? Boost leak? I'm making a boost leak tester today just to 100% eliminate that variable, though I'm fairly certain I'm good there.
The car is mostly stock except for a few bolt-ons, all of which I've had installed for thousands of kilometers now. Here is what isn't stock, not including suspension, wheels, etc:
Forge 008 diverter valve
034 Motorsports PVC silicone hose kit
Samco boost hose kit
Forge silicone turbo inlet pipe
Eurojet SMIC
custom built 2.5 stainless, catless turbo back
AEM Dryflo short ram intake
GLI MFA cluster
Golf IV / Jetta IV :: Horn / Left Side Turn Indicator (blinker) Light Not Working?
I realized my horn is not working. I also realized that the left side turn indicator (blinker) light is not working and when I popped it out I saw the wires were chewed up, I am not sure what happened. Do you think I need to remove the wheel well liner to try to access that area? What to do?
View 14 RepliesGolf IV / Jetta IV :: Temp Light Comes On With Keys In - Engine Cold And Not Running
So my temp light comes on in my 2002 gti 1.8t. The light comes on with the engine cold and not running, just keys in. I replaced the temp sender and the fan switch. I already checked the fuses, still good. The only thing i can think of now is the relay. There is plenty of coolant in the system as well. And I am not getting any CEL.
View 5 RepliesGolf VI R :: LED Tail Lights With Rear Fogs - Only Outside Left Light Worked With Brake Depressed
I just installed the lights and found that only the outside left light worked with the brake depressed, the outside left inside left and inside right worked with the light switch in the on position. Also both blinkers work.
I switched my byte 18 to 04 already and am not (as of now) using my euro light switch (I didn't think this would be it but I'm at a complete loss) ...
Golf IV / Jetta IV :: 2001 1.8t Stopped Running - Check Engine Light Blinking Because Of Misfire
So last Thursday I started my car up in the blistering cold and it ran fine for about a minute and started to misfire so I shut it off. It hasn't ran since. When that happened the check engine light was blinking because of the misfire. I didn't have a code reader at the time to read it. now that I got a code reader the damn thing isn't throwing any codes. it spits and sputters sometimes. I've had no previous problems with the car. Thinking It might be a weak fuel pump or bad coils and in not sure how to test them.
View 1 RepliesGolf V R32 :: Whining Noise From Rear Left Side When Driving Around A Left Hand Corner
I am having a problem with my 2007 R32 manual,over the last few weeks its developed a whining noise in what seems to sound from the rear left side,more so when driving around a left hand corner (weight is off the noisy side),or when i let my foot off the gas and let the car run,ive jacked it up and when I grab the back left drive shaft and shake it, I found there's a bit of play on the side going into the diff, there's 70000 miles on it and no problems to date, looking for some info on what problem could be?
View 6 RepliesGolf IV / Jetta IV :: Rear Right Tail Light Not Working
My mk4 the right rear tail light isn't working. So what I swapped the light board from the left side and the issue followed. What can I check to get it going again? The rest of the lights on that panel are working.
View 1 RepliesGolf IV / Jetta IV :: 2004 - Right Rear Tail Light Is Not Working?
2004 VR6
my right rear tail light is not working. I tested the tray on the left side and the brake light works, so the problem must be from the right connector or right wiring back somewhere.
any tips on how to find the problem from here?
Jetta - Volkswagen :: 2011 - Making Noise On Front Left Side While Turning?
Jetta starts making a noise on the front left side when I turn sharp rights like in parking lots. There is no VW dealer within a 2hr drive. Take it to local auto repair shop. The guy says it's the wheel bearings on the front left. The Jetta makes a different sound originating from the left front than originally still when turning right sharply.
BTW this sound isn't very loud and is not grinding or popping more of a whoopwhooopwhoooop Go home take off tire. One lugbolt twists off with fingers. First bad sign. Rotors on front not pretty but pretty smooth brake pads look brand new. Still really thick no uneven wear.
Do a sharp left u turn to get to auto parts store. Afs/bulb failure pops on. Solid warning light yet all the bulbs are working fine.
Turn car off. Go buy rotors. Ask about light no one knows. Go back out start car. Light is gone.. okay that was weird.
Replace rotors anyway so they are nice and shiny lube up the important parts. Put everything back together.back out of garage stupid bulb light is back on... restart jetta Its off.
Start driving everything sounds fine... parking lot test left turns quiet right turn SAME FREAKING NOISE. It has never made any noise when driving straight or on curvy road just sharp right turns.
Elantra XD (2001-06) :: Rear Left And Front Right Windows Do Not Roll Down
The rear left window and front right windows do not roll down. I have replaced the master control assy. and door switches. I removed the panels and tested the motors with external voltage. +12 v rolls the window up, -12v rolls the window down. Tried the sw and windows only roll up. Master control did not work. Ohmed out wiring appeared to be fine.
After reading the manual it says that everything goes through a bcm, Body Control Module. The manual does not say where it is located. I'm staring to think the BCM or bad ground wire may be the problem. Cannot figure out where the negative voltage comes from.
Jetta - Volkswagen :: High-pitched Squeak / Whine Coming From Front Left Tire
I have the most annoying high-pitched squeak/whine coming from my front left tire. For those who cant see the video, its making a high pitched, metal on metal noise... at all speeds... especially when making slight turns... my foot was not on the brake when the video was taken (coasting around the parking lot at around 10 mph)...
View 4 RepliesGolf IV / Jetta IV :: VR6 Pulls To The Left While Driving
2000 jetta vr6 145k.
So when I bought this car it was not driving and hasn't been driving for a year or so, needed time chains and the whole 9 yards. Did that, everything is up and running as well as new brakes all around, snow tires until I can afford some all season.
While driving, only in gear, the car pulls to the left. Even with a touch of the gas pedal it's pulling left. As soon as I let off its going right. If I coast in neutral it holds straight like an arrow. I have replaced the bushings for the dogbone and trans mount with polyurethane thinking with the high mileage it would be the culprit. The control arm bushings seem to be ok, neither side has any play, no wheel bearing play, no tie rod play....so I'm stumped.