Golf IV / Jetta IV :: Burning Oil Smell From Engine Bay After Driving For A While
My engine bay smells of burning oil after driving for a while. I have cleaned up the engine in order to find the leak. There is some gunky residue on the belt side of the engine but that wouldn't cause the smell.
Crawling under the car I found that there appears to be a leak between the (what I think is) the aluminum intake side of the turbo and the cast iron center. You can see it in the videos below:
[URL] .....
This is the only leak near the exhaust that I can find. Does this mean that the seals inside my turbo are toast and I will need to either rebuild or replace it? What is the best course of action? Rebuild? New OEM Turbo?
Golf IV / Jetta IV :: Smell Of Oil And Fuel Burning
2000 Golf Gl AEG 2.0
My car smells of fuel in the exhaust and when checking the oil it is mixed. I have a cel and it says the o2 sensor is bad, not sure if a bad o2 would be causing all of this or not. The air filter is clean and I have done a few oil changes also. The oil is low also after so many miles but cannot seem to see any leaks.
Car also has over 200,000 miles. Is it necessary to change the gear oil in the vehicle?
Golf/GTI VII :: Strong Burning Smell After Driving For A While?
Just in the last couple days, after driving for a while, I noticed a strong burning smell immediately as every time I opened my door! It doesn't feel like it's from the engine bay, but more likely from underneath of the car (I could smell it near the rear wheel arch). The smell starts very noticeable and diminishes quickly! BTW, it's a 2015 GTI DSG, 2-month-old, 2700 miles, pure stock. I got a bit concern on this since it never happened before.
View 14 RepliesGolf IV / Jetta IV :: When Idle Smoking White And Burning Smell?
Searched for days on this, symptoms are when at idle sometimes will smoke white/bluish with a burned smell. Not just a cold start, warm start aswell. Happens someimes when starting in 1st gear getting going a cloud with appear, only sometimes, does not happen all the time. And also cruising on the highway i was told little was visible. Now my turbo hold and boosts full. All new pcv piping. No engine codes. No lights on, was thinking along the lines of turbo seal? Spark plugs are dry aswell. Im stumped.
View 16 RepliesGolf/GTI VI :: Clutch Burning Smell After Faster Highway Driving
I have right around 2k miles on my '13 base model 6MT. I've noticed recently that after faster highway driving (75-80mph sustained for 10-25 min, up to 95 passing occasionally), I can smell something when I get out that reminds me an awful lot of the clutch burning up in my old 350 as I hauled a way-too-heavy trailer. Drivetrain is still very responsive, no noticeable slippage. Never shifted out of 6th when passing at speeds above. Just paranoid? Something I should look into?
View 3 RepliesGolf IV / Jetta IV :: 2000 VR6 GTI Misfire / Funky Smell Kind Of Like Burning Oil
My 2000 vr6 gti been starting too act up. After about an hour or so of driving the ride gets rough , loses power and it makes this knocking noise . Although when I punch the clutch in the knocking goes away . Besides the knocking going away the rides still pretty rough though . Once it starts this it starts too backfire way louder than it usually does and it throws out this funky smell kind of like burning oil /syrup smell lol .
I really wanna fix the car . When the car does drive good it's no complaints at all . I do know that I have a misfire in cylinder 3 & 4 though and I do have all the codes scanned from the obd2. I've heared of this being the throw out bearing but I'm not completely sure. There's a video to actually hear it. [URL] ....
Obd2 Codes :
P1473
P1432
P0300
P0301
P0306
Golf IV / Jetta IV :: 1.8t GLI Overheating / Coolant Light On
Mk4 Jetta Gli 1.8t , car was over heating only when sitting 5+ minutes at idle, mechanic said the big fan needed replaced so he replaced it. Car still over heated so i replaced the coolant with G13. It hasn't over heated yet but got in the car this morning and the coolant light started flashing and car was telling me to STOP the car. Checked out the coolant and it was on the low side. What it may be? Leak somewhere? Bad thermostat or water pump gone bad? Timing belt and water pump were done when i bought the car when it had less than 50k miles, car now has 99k miles on it.
View 7 RepliesGolf IV / Jetta IV :: 2004 - Overheating - Coolant Leak?
My 04' GTI, 24v VR6, all stock, @ 107,000. I had a coolant leak from the t-stat housing. I installed all new housing, seals, and C-Pipe from GruvenParts. Already had a green CT sensor installed and the kit I got didn't come with one, so I didn't change it. Found out the leak was from the t-stat housing o-ring didn't fit the old housing. The new one fits perfect. I put coolant on the seals and burped it. Doesn't leak a drop. But still overheating, all the hoses have pressure and are hot, so no blockage....I noticed the fans were not coming on at all. The fans used to engage every other minute and run for 15 secs on high ONLY. Longer times, if not constantly w/ A/C on. I was wondering how to test the fans, sender, and/or fan control module to see which one of them isn't working. And which pinouts are what?
View 2 RepliesGolf IV / Jetta IV :: 2000 AWD 1.8t Overheating - One Side Of Coolant Line Hot
After finally getting some issues sorted this weekend (needed a transmission flush) I was driving around a bit to make sure everything was good. On the way back to my house, the car started overheating. I replaced the thermostat this winter (~4-5 months ago) because it was stuck open making things run a little cool.
I was thinking the water pump is probably shot but not 100% sure. the radiator fans both work and when I turn on the heater, it blows hot. Any good way to check if the water pump is dead? I have a little point and shoot infrared thermometer and one side of the coolant line was way hot and the other was fine (cold ~90 deg F).
Golf IV / Jetta IV :: 1.8T AWP GTI Overheating - All Of A Sudden Coolant Starts To Flow
I am having a overheating issue with my 1.8t AWP gti, it goes as fallows, start the car, engine warms up go for a drive (short 5-8 mi), park the car and temp gauge starts to rise, (turns off car)... I began to check some things with the system, I checked both rad hoses bottom is hot top is a bit hotter and fans work when ac is on; here is where it gets interesting i took off the coolant return hose on the reservoir (cold start) and nothing was flowing ...water pump?... So i turned the heat on and air full blast and all of a sudden coolant starts to flow.
It also seems like air is being spat out as well. Soon after the flow beginning my coolant in the reservoir starts to fluctuate (rising and dropping) with air bubbles and beginnings to over flow so i shut the car off. Now I know what the possible issues are its either the water pump, air in the system or bad autozone thermostat. Here is some history of the car TB was replaced at 70,000 by Previous owner, i bought the car had the belt inspected and was told it was good, about 2 months ago i had a coolant leak and had it misdiagnosed as a thermostat housing leak; it turns out it was a coolant bypass hose that was leaking so i ended up fixing it. I lost a lot of coolant but topped it off with g12+. My mechanic doesn't think its the water pump and recommended changing the thermostat for an VW one another mechanic recommended to bleed air of the system.
Golf IV / Jetta IV :: 2004 Overheating - Radiator Cracked And All Coolant Leaked Out
Ok so I have an 04 Jetta 2.0 and lately it's been overheating on me. The first time it started overheating was because my radiator was cracked and leaked out all my coolant, I swapped the radiator everything was fine for a while. The second time I started overheating, I saw my primary fan was bad it wasn't spinning at all, I swapped it everything was fine for another while. I also changed the coolant temp sensor, it wasn't bad it's just because the coolant flange was leaking coolant, so I changed it a long with the O-Rings and sensor. I also changed the thermostat just incase that was the problem but it wasn't.
I don't think the fans are turning on by them selves when they have too, but either way the car still overheats when I turn on the fans manually with the A/C. I'm not sure if the coolant is circulating, as the car only begins to overheat when I come to a stop and it idles. I have a feeling it's the water pump but I wanna be sure it is before I change it. What it could be? Things that I should check for that usually go out?
Golf IV / Jetta IV :: VR6 Overheating / Coolant Warning Light Came On When Car Idling For 10 Minutes
Before I go buy a Bentley manual to dig around, when should my radiator fans kick on. I had the car idling for 10 minutes, no ac or heat on, and my coolant warning light came on, it overheated. It already has a new fan switch in the radiator, and the fuses are good.
View 7 RepliesGolf IV / Jetta IV :: 2001 - Engine Overheating - Coolant Temp Sensor Replacement
My temperature has been randomly dropping, them back to middle, and recently my engine was overheating because I'm guessing the fans didn't turn on, because I'm also guessing, the engine didn't know it was overheating?
Anywho, during my replacement, I made sure to get rid of the pressure, and the car was cold. I tightened the cap again, but when I took the sensor out, all the coolant spewed out.
Now if I understand this correctly, do I have a leak? I figured the leak I had was coming from the temp sensor as it is.
Here's some pictures for those who'd like to see ....
Golf IV / Jetta IV :: Overheating - Coolant Spraying Everywhere Causing White Smoke Under The Hood
I have a 2002 VW MK4 1.8t. It has 172,000 miles on it. Since i bought the car i have had to add coolant from time to time due to leaks from various plastic coolant parts so I replaced the crappy plastic connectors and flanges as they failed but it has never overheated till a couple days ago. It rose up to about 210'F but I didn't let it get to 260'F (aka the red zone).
While the temperature was up, the coolant was spraying everywhere causing white smoke under the hood. I stopped and looked under the hood and came up with the conclusion it was the coolant flange that holds the temp sensor since it was leaking coolant from the flange like a faucet hince the reason it caused it to overheat due to lost of pressure and no coolant in the system. So I replaced the part and gaskets then checked for other obvious leaks.
No leaks are shown nowhere else in the vehicle. So I added coolant to the car and let the cooling system do its magic as i left the heater on high. Let car idle with cap off and heater on for about 45 minutes. No signs of overheating. So I take the car for a spin and that's when the car starts heating up. I look under the hood and feel hoses and notice all are pressurized but top hose that leads to coolant flange is hot and the bottom hose connected to thermostat is cold.
I checked the return hose that leads up to the coolant reservoir to see if it's cycling and it appears it was. At low rpms the return hose had a steady flow and at high rpms it was flowing much rapidly. Which made me think it wasn't the water pump also this car with that many miles wouldn't have lasted with the plastic impellar this long if it wasn't already swapped out by previous owners. My question is what would cause it to still overheat? I forgot to note the fans did not turn on when the temperature was rising unless i turned the a/c on. But i still did a drive test with a/c on and it still overheated. I also did multiple burp cycles. I have invested alot of money in custom work and suck to leave it parked on the drive way.
Bmw - 328 :: 1996 - Overheating After 5 Minutes / Loosing Coolant - Exhaust Burning Out?
I have a 1996 BMW 328is and recently it overheated on the way to work which is about 20 miles i pulled over let it cool down and now when i drive the car after about 5 minutes it starts overheating and is loosing coolant but i am pretty sure its burning out the exhaust now the person i had bought it from had replaced the head and head gasket no more than 8000 miles ago with thermostat and housing and water pump and radiator so now i get no heat in the car both upper and lower radiator hoses rock solid and burning the antifreeze.
View 13 RepliesGolf IV / Jetta IV :: 2004 GTI 1.8t Started Overheating - Little Steam Coming From Coolant Overflow Tank
I have an 04 gti 1.8t and last night it started over heating. I pulled over and checked the coolant and the oil but everything looked good. I let it cool down and drove it home. When I popped the hood there was a little steam coming from the coolant overflow tank but I saw no leaking. I decided to vent the pressure off the system and then I got a little drip on the passenger side close to where the inter cooler is. I can't pinpoint the leak though.
View 4 RepliesGolf IV / Jetta IV :: 2005 GLI - Coolant Smell / Turbo Is Leaking
I am looking at a 05 GLI 5 speed with 133k miles. I drove it yesterday and it runs fine, but I smelled coolant after I turned it off. I was told by the dealer that the turbo is leaking some, it was spooling while driving and didn't seem to do anything funny. The check engine light came on and said coolant was low when we got back, when I cranked it back up the light was out. Just not sure about it.
View 4 RepliesHonda - Accord :: 2001 - Smell Of Burning Coolant
So I noticed the smell of burning coolant a day after I got an oil change. My car wasn't overheating and my thermostat didn't jump at all. I open the hood and there's a little bit of smoke. I take it to a mechanic and they do a pressure check. They see dried coolant under the upper hose connecting the engine to the radiator. They tell me its the flange connecting that hose to the engine that's leaking low levels of coolant and it will cost 150 to fix.(not a gasket) I say go ahead. They're in the process of fixing it today and they call me saying "We got the part, and we're going to fix it but we think the thermostat isn't fully opening or closing which is causing the problem and it will be another 150 to fix". Now I looked up this mechanic and they have 12 1 star reviews on Yelp of people saying they were overpriced and the mechanics often piled on things once they got on.
My issue is essentially the mechanic said "This problem could happen again if you don't replace the thermostat" but he also said they're not sure if its a bad thermostat. Couldn't they check the thermostat easily??? Like I said I said besides the leak in the flange I haven't had any issues. The car warms up fine and the temperature NEVER spikes (I had a different car overheat and blow a gasket two years ago cause I didn't notice the temp gauge for 2 miles and I LEARNED MY LESSON) I always keep a careful eye on the gauge.
My question is isn't there an easy way to check the thermostat? The mechanic keeps pressuring me to fix it. Just to be safe I am just having them fix the flange and taking it to a mechanic I trust. (I couldn't take it to him before cause he's on the other side of town and I was paranoid my car wouldn't make it)
Golf IV / Jetta IV :: 2002 1.8t Overheating - Temperature Started To Rise After Driving Like 30 Seconds
I have a 2002 jetta 1.8t that overheated on me out of no where i have read some post and couldn't really find what i need it never overheated on me before and this was the first time and when ever i open the reservoir where you put in coolant everything spills out its my first time owning a volkswagen, it happens as soon as i start driving like 30 secs and temperature starts to rise.
View 3 Replies