Golf IV / Jetta IV :: 2005 - Leaking Coolant Flange?
2005 jetta gli 1.8t automatic ( i know flanges are different from automatic to manuel) just recently found the leaking coolant flange. Can I change the flange without having to drain the coolant out of the system. my coolant is new because i recently had the timing belt/water pump etc done so its new coolant and i do not want to flush the system. also will i have to "bleed" the system if i just pull the flange of and replace it if that is possible.
View 2 RepliesGolf IV / Jetta IV :: 2004 - Turbo Is Leaking Oil
I have a GTI with a turbo that leaks oil.I don't exactly know what to do. The guy i bought it from said it had "Bad Seals" I've seen many rebuild kits online for my turbo(KO3) Looking through the kits i really only sea one seal. One single O-ring. So that doesn't seem right but this is my first turboed vehicle so i can honestly say I don't know much. Should I buy the Rebuild kit or should I just buy a new Turbo? Any video to reference too because i don't even know how to remove my turbo.
Also, on a side note. I was being a show off one day and tried speeding off like a dick.I went from first and grinded HARD into second and since then I haven't had first gear. Now i suspect its my synchros. But like i've said before. I don't know much.
Golf IV / Jetta IV :: 2000 - Coolant Is Leaking
When my 2000 GTI VR6 sits for a week or two the coolant will run low. There are no leaks that I can find. No coolant in the oil. The crack pipe looks dry. Nothing from the thermostat hosing that I can see. The carpet by the heater core is dry. Nothing that I can see. The thing that is funny is I can drive the car with it 100 degrees outside in Georgia and have no problems with the coolant getting low, or any signs of a leak, smoke or smell. The head gasket and every gasket except the oil cooler and oil stand gasket were replaced about two years ago. The heater core was also replaced at the time. I gave the front pulled loose so I can pressure test the system and look more today.
View 1 RepliesGolf IV / Jetta IV :: 2003 - Coolant Leaking During Hot Days
Today I had planned on replacing coil No. 5 to rid myself of the rough idling and drive I've been experiencing the past couple weeks. Car is running smooth now, however, I've noticed again that coolant continues to leak at a fast pace on hot summer days.
I've always had a slight leak, about the size of a hockey puck or so if I let it sit over night. But once temps reach in the mid 80s-90s, like today in PA, the leak gets even worse. Pictured below is the amount of coolant that had dropped in about an hour span. I have attached an image and video of where I can see it dripping from. It looks like it may be a hose, but I can't tell if the coolant is just dripping on there initially from somewhere else, and then onto my driveway. I don't have a jack that I can get it high enough to check.
Car specs:
2003 VW GTI VR6 24V 98,000 miles
Golf IV / Jetta IV :: 2000 VR6 Started Leaking Coolant And Getting Way Too Hot
So over the weekend my 2000 jetta VR6 started leaking coolant and getting way to hot. So i parked it at work and eventually got it towed to a friends shop. I haven't looked at the car since then so bear with me on the descriptions I'm giving as they are just what he told me over the phone. I'm going to try and get to the shop in the morning to check it out some more. He says I have a leak in 2 hoses that look like they are just rotted out.
First hose he says "Comes from the back of the head and is about a half inch wide. it goes into a Y and then the top half goes into a smaller hose." The 2nd hose he says "on the top of the coolant bottle there is a line that goes across the back of the firewall then comes into a rubber hose and from that hose their is a T going into other places."
Obviously that's not a lot to go on. and when I'm looking at replacement hoses at shops online I'm not seeing ones that match these descriptions really. I've been looking for a diagram or some kind of illustration of these hoses so that i can send it to him and he can figure out which ones they are but I have not been able to find one.
Golf IV / Jetta IV :: Coolant Burning Smell - Car Overheating While Driving
Last night while i was driving my car began to overheat. I could smell coolant burning. I pulled over and opened my hood. The coolant inside the coolant pod was boiling. Some coolant lines were steaming as well. I could also hear a gurgly like noise coming the engine. This is a 1.8t gti
View 3 RepliesGolf IV / Jetta IV :: Radiator Coolant Started Leaking From Pipes?
Recently I started leaking coolant on the driver side area to the right of the engine:
I am assuming I need to replace some part/tubing that has a leak in it, but I am not sure what any of these things are called. How to identify what leaking part here is?
Golf IV / Jetta IV :: Leaking Coolant On Right Side Driveshaft Near Differential
My MK4 Jetta started leaking coolant recently and I'm not sure where it would be coming from. I already checked the reservoir to see if it was leaking out of there but I could not find any leakage. I've found some coolant on the right side driveshaft near the differential, there is also some on the diff. I'm wondering if this could of happened because it has been sitting on a jack stand not being driven for about 2 months. Is it possible that within that time 1 or more of the coolant hoses could have cracked or anything. And while I'm on the subject of why it's on a jack stand, it also has gone through wheel bearings twice within the last 6 months to a year. Is this normal?
View 8 RepliesGolf IV / Jetta IV :: 2003 - Coolant Leaking Onto Belt Making It Squeal And Slip
Yesterday i was cleaning my car and when I took it out from the garage i noticed a spot on the garage floor. Put my finger on it and thought it was oil but when i looked under the car it was red. It was a few drips on the oil pan and a few on the splash shield. I'm sure its coolant because i was missing some too. This morning on my way to school by serpentine belt started the squeal every time I let go of the clutch. Where this leak is from? My guess is that its leaking onto the belt making it squeal and slip. Its a 03 vr6 24v ...
View 1 RepliesGolf IV / Jetta IV :: 2005 GTI 1.8T Overheating - Cooling Flange Leaking
I have a problem with my 2005 gti 1.8t , I had a issue with my cooling flange leaking, I changed it yesterday refiled it with g12 and distilled water took the car for a test drive about 20 min in see the temperature go up, no steam or water leaking any where, turn on the heat notice no hot air from the vents,turn on the ac no cold air, and the fans are not turning on. Everything worked the day before I did the coolant flange, am thinking is this possible because the coolant temperature sensor broke? fans will not turn on at all even if it overheating. If I leave the radiator cap off the coolant is spiting out of the overflow expansion tank don't know where to start looking for some pointers. Would bad thermostat cause the fans not to turn on?I think is impossible that the fans and the thermostat broke at the same time with the fact that everything worked the day before..
View 9 RepliesGolf IV / Jetta IV :: 2005 - Oil Cooler Randomly Start Leaking?
I've got 149,xxx miles on my Golf TDI. Took it by a local shop for a routine oil change and since then, it's just been puking oil from the oil cooler. I took it back to the shop and the mechanic even pointed that out. Some red flags here; Timing is too shady. This happened literally the day after the oil change. He also told me that he won't use customer-supplied parts for liability reasons. Seems believable enough, but why would this part just choose to go wrong now?
This is my first time at this shop too and I've never really dealt with "bad mechanics" before but something about this isn't sitting right with me, and I'm not sure how to handle my next step properly. So what would cause an engine oil cooler to leak profusely just after an oil change?
Pontiac - Grandam :: 2000 - Smell Coolant While Stopping - Head Gasket Leaking?
I have a 2000 V6 3400 engine. I had the intake gaskets repaired with the "good metal ones" according to the mechanic I had do the job. Cost me $600. Car still has coolant leak it overheats every 3 days or so. Leaves no puddles under car when parked. Can smell coolant when stopping at stop light or stop sign or when parking car. No obvious coolant running down or pooling on the engine. Sometimes it seems like smell is coming from heat vents but no wet spots on carpet or liquid coming out of vent. Took to mechanic again and he said it was the head gasket leaking. Wants $1100 to fix it. Don't have the money. Was wondering if any of these additives you can get at Autozone Etc. may work. It wouldn't be my first choice but financially it's about all I can do right now.
View 2 RepliesGTI 337/20th Anniversary :: Coolant Smell After Short Drive - Left Side Hose Leaking
I just got my 337 a few days ago and I got out today after a short drive and smelled coolant. Immediately thought the worst but luckily I found this hose to be leaking. What hose this is its on the left side just about the throttle.
View 11 RepliesGolf/GTI VI :: Oil Inlet Line On Turbo Leaking
Dropped her off at the dealer for the 30k service and minor oil leak near the turbo.
-Water pump replaced (never did whine nor did I notice it leaking)
-Valve cover gasket replaced
-Oil inlet line on turbo leaking
-Wastegate clamp
-Driver side window regulator
Already had my intake mani replaced around 25k miles. Hopefully this will cover all the known/dreaded Mk6 issues. My 1.8T was bulletproof.
Elantra XD (2001-06) :: 2005 - Engine Compartment Has Coolant Smell
I recently purchased a 2005 Elantra GLS. It is super clean and runs great. The dealer replaced the original radiator and hoses because they said the original radiator had a hole in it. After driving the car, the engine compartment has a coolant smell. No smell in the cabin. I looked everywhere but don't see any signs of a leak. There is no smoke coming from the exhaust and the oil is clean. Coolant levels in the over flow tank and radiator are good. The car is only driven short distances (maybe 100 miles per week). What could be causing the coolant smell in the engine compartment?
View 5 RepliesElantra XD (2001-06) :: 2005 Coolant Low - Antifreeze Smell When Shut It Down
Our Elantra never overheats or shows hot on the gauge but every couple months it is a little low on coolant. When I shut it down I sometimes get the sweet antifreeze smell. I see no leaks. Never a spot on the driveway. Just need to add a little. Car has about 80,000 miles. as a matter of annual maintenance I drain and fill the coolant and trans fluid once a year. Hoses are in good shape. The oil is clean and shows now sign of contamination. We Love this little car.
View 4 RepliesElantra XD (2001-06) :: 2005 - Coolant Leaking Externally From The Head Gasket
Our 05 Elantra (170k miles) is leaking coolant externally from the head gasket. At first I thought it was coming from the freeze plugs, but it's actually leaking from above. I'm mechanically inclined but have no experience with head gaskets. I have access to Alldata but no service manual. Will it tell me everything I need to know? The farthest I've gone inside an engine is removing valve covers car runs great and we like it enough to want to keep it for a while ... I'll also mention I will be replacing the timing belt as well.
View 7 RepliesGolf IV / Jetta IV :: Coolant Temp Light Came Flashing On - Oil Getting Into Coolant
Okay so recently I was driving my 2000 Jetta and the coolant temp light came flashing on, when I went to check the coolant I was surprised to discover that it was like a mud brown color, almost looks like peanut butter. From everything I have read this can be from a few things, either rust build up that is gunking everything up and oil getting into the coolant somehow. I'm pretty sure its rust build up but I was wondering what everyone thinks about this, I was also not using G12 coolant which I'm told now is the premier brand for VW's.
View 3 RepliesGolf IV / Jetta IV :: Turbo Set Up - Motor Won't Start
Well I have been working on my build for about 2 1/2 years. Built the motor for the turbo set up that I had on the car and a few other goodies.
Now the motor turns over with no issue and I have spark. So I know my problem lies in the fuel delivery. My pump tested fine and I have fuel at the rail. So my next guess is the injectors. After trying to start the car I pulled 2 spark plugs out and they where dry. So this proved to me there's an issue here.
Before I go and rip my manifold off and start pulling injectors is there anything I could check first? I'm thinking from sitting that have gotten dirty and clogged.
Looking for wire diagram for the injectors on the vr6?