Golf IV / Jetta IV :: 2004 1.8T Overheating - Water Pump Or Blockage In The Radiator?
First off new jetta owner. I changed the thermostat. There is no heat coming into the car upper radiator hose hot lower hose is cold & seems there is no pressure. I bought the book to repair the car but it doesn't give me troubleshooting directions other than it might be the water pump or a blockage in the radiator.
View 9 RepliesGolf IV / Jetta IV :: 2002 - Replaced Water Pump And Thermostat Still Overheating?
My son has a 2002 Jetta, we just changed the water pump and the thermostat. The car will sit at idle and the temperature will stay around 190. When you drive down the road the temerature will rise and when you let off teh gas the temperature goes back down. What this could be, I have tried everything I can think of to fix this car.
View 13 RepliesGolf IV / Jetta IV :: 2001 GLS VR6 Engine Lag After Water Pump Replaced
My girlfriend has a jetta and I work at a DODGE dealership in service. I recently replaced the water pump and flushed the coolant twice and replaced the coolant with G13 coolant from the local VW dealership. After I finished burping the coolant system of air bubble. After I finished I took it for a spin and being the speed demon I am, I don't hold back on the throttle. I noticed immediately the engine lagging and being extremely sluggish. I ran my shops snap on code scanner on it and I came up with cylinder 1 fuel injector open circuit. Cylinder 6 fuel injector limited power. And last but not least o2 sensor 1 open circuit. If your facing the motor I undid the left motor mount from the frame, lifted the car on a hoist and took the bottom side motor mount off of the motor. I took the cv shaft off of the transmission and lowered the car and jacked the motor up by the oil pan to expose the water pump for removal and replacement. I'm wondering if possibly the o2 sensor could cause the ECU to seize power to two of the cylinders to ensure no engine damage or if its 3 separate problems.
View 3 RepliesGolf IV / Jetta IV :: Coolant Leak On Passenger Side - Water Pump?
So my coolant system woes have continued! I recently replaced my thermostat ,thermostat housing, thermostat cover and all of the rings and gaskets. I finally stopped the leak on the driver side which seem to be the thermostat now about seven days later I am experiencing leaking on the passenger side. I walked out from work today and noticed I pool of coolant under the car. I can't tell exactly where it's coming from but it's coming from one of the components that runs off of the large belt. I snapped a few pics from the bottom of the car I don't think this is the actual component that's leaking. I think the leak is just falling off of it . I was wondering where the water pump is located.
View 5 RepliesGolf IV / Jetta IV :: 2003 - Auxiliary Water Pump Wires Got Ripped Out
Some how my aux water pump wires got ripped out and I'm not sure if they shorted out. I pig tailed the wires on the pump and ran the car up to temp and turned car off and pump was not running. If the wires did or can short out what would I look for to replace (ie fuse, relay). Also I'm not sure which wire goes to what pin as the plug got ripped off. Wires are black red, and brown black.
View 2 RepliesGolf IV / Jetta IV :: Belt Squealing After Replacing Water Pump And Crack Pipe
So I have a 2002 GTI VR6 with the 24v BDF Engine. I have been having a problem with my belt squealing. It started after I replaced my water pump and crack pipe. While I was at it I replaced the belt tensioner and belt with a kit from ECS than had an aftermarket tensioner and a Conti drive belt(has 6 ribs). When starting the car up for the first time after doing the water pump I noticed the belt was squealing. It would only squeal when I gave it some good throttle.
After a few minutes it stopped squealing so I figured it was some coolant or something on the belt. Well its been a few weeks and it continues to squeal when I give it throttle, but only if the ac is on and it will only do it for a few minutes. After a few minutes of the car running or driving down the road it doesn't squeal anymore. I did make a long drive in the rain very shortly after replacing the belt and it was a really heavy rain storm. There was a lot of water on the road and my belt was squealing pretty much the whole drive if I had the ac on. I had to alternate ac on and off so I could keep the windows defogged.
After that experience I put on a set of engine splash guards from ECS. (note these guards were the ECS branded ones and were a terrible fit. Holes didn't line up with studs on bottom of frame and ended up taking the middle belly pan section out as it would hang down way too low even with the side covers connected to it.) That seemed to keep it from squealing while driving in the rain but it still squeals after first starting the cold engine with ac on.
Golf IV / Jetta IV :: 2004 - Stalling / Dies After Long Trips - Leak In Water Pump
I have a 2.0l Jetta that has been giving me problems for about a year now.
First, the car started dying out on me after long trips at en excessive rate where it would shut off and have trouble starting multiple times consistently. So I got the fuel lines cleaned, a new fuel filter, the fuel pump checked, and did a basic tune up by changing the sparks and oil.
Still the same problem. after some troubleshooting i gave up and decided to take it to the stealer dealer. after a $130 diagnostic fee and a $300 repair fee they told me that they had fixed it by replacing a speed sensor in the transmission. the car was noticeably running better and did not stall during the short driving i did. I am a student so not much driving was done initially. A couple of months later i took a ~150 mile trip and upon stopping at a red light and trying to go once the light turned green the car stalled.
I took it back to the dealer that told me they would check if the speed sensor was faulty. it was not and they could not refund me my money. i paid for another diagnostic for another $130 and this time they said it was a bad coil pack, a $400 repair fee that i was not going to pay. i went out and got myself a coil pack and installed it myself. still the same problem.
I met a guy that worked for the dealer and had the same tech as the dealers so i took the car to him. he had it for 2 days and drove it for over 80 miles to test run it. he could no replicate the problem and just charged me 80 dollars just for his time.
I decided to take matters into my own hands and I read on these forums a couple of common solutions to the problem such as changing cam,crank,speed sensors etc etc and i started out with the crank..then speed...etc etc.
2 days ago my water pump had been leaking and i believe the antifreeze caused the timing belt to slip about 3 teeth in the middle of driving. luckily no bent valves or any damage to the engine but i did have the push the car about half a mile. After a 5 hour job i replaced the pump and the timing belt along with the cam sensor. I drove it around 70 miles and everything seemed fine. just yesterday i drove around 120 miles and the car had a small stall about 50 miles in when i was at a red light. The rest of the trip it ran fine. As i got to my apartments I decided to see if i could replicate the stall since the engine was hot. I stopped and waited around 10 seconds and then stepped on the gas, the car did almost stall but it stayed on since i let go of the gas. I tried it again and it would no longer do it.
Passat (B5) :: 2001 1.8t Overheating After New Water Pump
i just did a new timing belt water pump kit on a 2001 1.8t (aug engine code) the new pump has a metal impeller. i ran it in the drive way for mots of an hour off and on. figured it was good. took it for a drive and at 5 miles it overheated. Temp Went straight to 260 and stop light came on. coolant could be heard boiling in the system. when i let it idle and ran the heater i got the temp to go back down to 190. but after idling for couple minutes it started going back up. I don't think the stat is bad considering that the heater works which shows that the system is flowing.
View 5 RepliesGolf IV / Jetta IV :: 2005 GTI 1.8T Overheating - Cooling Flange Leaking
I have a problem with my 2005 gti 1.8t , I had a issue with my cooling flange leaking, I changed it yesterday refiled it with g12 and distilled water took the car for a test drive about 20 min in see the temperature go up, no steam or water leaking any where, turn on the heat notice no hot air from the vents,turn on the ac no cold air, and the fans are not turning on. Everything worked the day before I did the coolant flange, am thinking is this possible because the coolant temperature sensor broke? fans will not turn on at all even if it overheating. If I leave the radiator cap off the coolant is spiting out of the overflow expansion tank don't know where to start looking for some pointers. Would bad thermostat cause the fans not to turn on?I think is impossible that the fans and the thermostat broke at the same time with the fact that everything worked the day before..
View 9 RepliesCelica :: 1993 GTS Overheating / New Water Pump And Radiator
Ok, I just bought myself some problems in the form of a '93 Celica GTS. (5S-FE)
Well, alright, that's a little dramatic. it just overheats. but here's my issue. it's got a new water pump, new radiator, and is still overheating. The guy I bought from says it's in the block, cuased by an attempt to plug a radiator leak with stop leak. He said it just had a minor leak in the radiator, so he put stop leak in it, and after that it started overheating. he's replaced the thermostat, water pump, and radiator since then.
My first question is, could he (and I) be overlooking something? could there be a clog somewhere easier to access? and then if there isn't, how should I go about cleaning out the block? are there areas I should check? anything I should do to try to unclog it? my current plan is to put cooling system flush in (he has some) and drive it home (about 55min. drive) with the flush in it, then empty it and hope for the best.
Rodeo :: 1995 - Overheating After Water Pump Replacement
1995 Isuzu Rodeo. Replaced water pump, thermostat, timing belt & components. Now it over heats & no heat in cab. I was told to "burp" the cooling system but can't find the bleed valve. Is there even one on the V6 engine???
View 3 RepliesCamaro :: 1995 Chevy V6 3.4L - Overheating / Water Pump Was Leaking Fluids
My 1995 chevy camaro has been overheating. at first i thought it was the thermostat sticking because there was no spewing or smoking so i changed the thermostat and my car was still over heating. I finally found out that the water pump was leaking fluids. so I changed out the water pump and filled it full of coolant. i turned on my car and within 10 minutes the gauge went up to 260 degrees and went down a little bit but stayed around 260, there was no spewing or leaking or smoking again. I was thinking that maybe now it could be the sensor but im not sure.
View 1 RepliesChevrolet - Cavalier :: 1998 - Overheating After Installation Of New Water Pump And Thermostat
I had a leak in my water pump so we had it replaced and a new thermostat. Now it is overheating in just about 2 minutes and my heater is now not working. I was told that it is most likely an air pocket in the coolant. I have let the car heat up, not to the point of hot but over half way and shut it off, taken the cap of let it sit for a while and then trying it again. No luck so far. Is there another way to get it out of there? and would the cap have anything to do with it? it has been hard to take off in the past and now its coming off easy. It is the plastic kind. I am at the end of my rope here . the car runs like a dream, its just this one thing.
View 12 RepliesImpala - Chevrolet :: Overheating - Small Leak From Gasket On Water Pump
Ok so my car kept overheating and I saw I had a small leak from the gasket on the water pump. I replaced the water pump and gasket but then it would zoom straight to overheating. I then assumed it was a stuck thermostat and replaced the OEM with a fail-safe thermostat. After topping off fluid and leaving the radiator cap off until I saw fluid running through it took it for a drive. The temp began to climb to overheating but dropped just as it was getting to the red and then began to fluctuate. Finally heat came through the car climate system and all was good until I had to come to a stop. It seems that whenever I have to stop at a light the temperature rises to overheating.
View 9 RepliesFord F-150 - 1997-2003 :: Replaced Water Pump - Overheating Occasionally - CEL On
We had my son's water pump replaced in his 97 F150. It is now occasionally jumping to completely hot. If you turn it off and back on it returns to normal. The power to the engine is cut when it shows to be overheating. The check engine light has now come on.
View 9 RepliesDodge - Intrepid :: 2002 - Overheating After Replacement Of Timing Belt / Water Pump?
I have a 2002 Intrepid ES with a 3.5L V-6 with 264,000 miles on it. I have recently had the timing belt and water pump changed. Three weeks later I am driving home and the temperature gauge starts climbing. This is the first time this car has ever overheated. Well, I call my buddy who is a certified mechanic and he tows the car to his shop. I have him check the water pump to make sure it hasn't prematurely failed. He tears the front of the engine down and inspects the pump. He finds nothing wrong with the pump but he discovers the timing belt tensioner has failed and it has caused the engine to jump time, I tell him to go ahead and replace the tensioner.
After he put the engine back together he started it and it ran cool while it was sitting at idle for about 45 minutes. Then he took it for a test drive and it overheated again. He checks the thermostat and finds that it has also failed; he replaces that also, still overheating. New radiator hoses, upper and lower, new radiator, new thermostat, new water pump and it still overheats. He put dye into the coolant to check for a blown head gasket and it tested negative for a blown gasket. The exhaust doesn’t smell of burning coolant or producing white smoke. My mechanic friend and I both have run out of solutions…
Golf IV / Jetta IV :: 2005 GTI Losing Power To Fuel Pump
I have a 2005 Volkswagen GTI with 80k miles. Just yesterday I went to school and the car drove fine. But when I came back and tried to start my car, it stalled out after a few seconds. Now I thought this was a bad fuel pump until I checked it and found that the fuel pump wasn't receiving any power. I checked the fuse and it was intact. So then I went to check the relay and found that if I unplug the relay and plug it back in, the fuel pump momentarily receives power for about 2 seconds then nothing. Any clue what the interference could be?
View 1 RepliesFord 6.0L Power Stroke Diesel :: 2006 - Overheating - Water Pump Impeller Slipping?
have a 2006 f250 with the 6.0 Powerstroke diesel started overheating yesterday the ECT and EOTcheck fine with the scangauge always ran with in 8 degree's of each other. Thought maybe water pump impeller may have been slipping so it is new with no change. Fan kicks on like it should. Heater works good so don't think it is a thermostat.
View 13 RepliesGolf IV / Jetta IV :: 2005 1.8t AWP Cranks But No Start - Cannot Hear Fuel Pump Priming
2005 1.8t gti wont start. The other day I was driving on the highway when a thin plastic type wrapping got caught in my serpentine belt. The car immediately died and I hit the gas and nothing and with no power steering i pulled over to the side.
Timing belt was done with water pump and tensioners
Spark plugs and coils are brand new
What fuel line to disconnect to test if the fuel pump works? Like I said in the title I cant hear the fuel pump priming. The engine was running 100% before this 2 techs saw it and the vw dealer i workrd at looked it over.