Golf IV / Jetta IV :: 02 - Axle Came Loose From The Tranny
I have an 02 Jetta the the left CV Axle came loose from the tranny/axle flange. I checked the Bentley and it shows that a bolt holds the flange on, I guess a spline. My question when taking one off, is there anything inside that will drop/pop off when I pull it? The reason I need to take it off is that some of the bolts actually broke off, while others screwed their way out. Not sure why they came out or what made the others break but they did. It would be so much easier to get the broken bolts out with the flange out.
View 2 RepliesGolf IV / Jetta IV :: Tranny Replaced, Can't Reverse
This weekend I replaced the transmission in my 2000 12v vr6 5 speed golf. Got In drive around block going through each gear all seemed fine. Then I tried reverse and couldnt find it. Seem like it reverse was more like 5th cause car would try and move forward. I have the new style shifter and the bearing is quite a bit beat up. However if I in engine bay operating the gears directly on shift paddle I still can't seem to find reverse. Is there some kind of lock out or what could I be missing. I tried adjusting the cables but that seemed to make things worse not better.
View 5 RepliesGolf IV / Jetta IV :: 2000 - What To Do While Installing Tranny
I just picked up a 2000 VR6 golf a few weeks ago. been doing lots and lots of reading. It needs a transmission and was wondering what other things should I do why tranny is out of the way. I know some things can either only be done with tranny out or are a hell of a lot easier with it out of way. So what are your recommendations. Looking to pick up a tranny and get this bad boy on the road asap. Car ran great no issues or sounds my buddie just shifted to 3rd on highway and something walked loose in tranny and kaboom she went.
View 5 RepliesGolf IV / Jetta IV :: 04 - Tranny Wouldn't Shift Out Of First Gear
Okay so I bought this car and a week later tranny wouldn't shift out of first when I would slow down or at least it would take a min. I would hit 4or 5 grand then it would jolt me back. It wouldn't do it every time though. I bought it to go to college drove it the 900 miles on the highway and had no problems except right before I left town but then fine. All I did was change the tranny fluid before I left which I can confidently say I don't think has been changed before that. stunk bad bud no metal.
Alright now I'll go jump in the car to go to class and it will not leave first. If I put it in the manual mode it thinks it's in third but clearly if in doing 15 mph at 4000 rpm that's not the case. It doesn't do it every time. Kinda hit or miss. After driving for a min it usually shifts. Sometimes I make it the two miles without it shifting though. Also sometimes It will shift but once I slow down it won't shift out of first again.
I have seen a code for torque management since I bought the car. The check engine light is on now but I haven't seen the torque code since I change the MassES. that's not to say it's not still there. I used a different handheld computer for the check engine light the last time I did it and I could have missed it because I was unfamiliar with it. I have put a mass airflow sensor, battery, alternator, and changed the tranny fluid since I have owned the car. drained 3L of tranny fluid and put 3L back in. Oh and the last time I checked the light it said lean in bank 1 but I was assuming that was an unrelated issue.
Golf IV / Jetta IV :: Axle Popped Loose, Spilling All The Tranny Oil
So I just had my transmission replaced because my cv axle popped loose and tore a hole right into my old one spilling all the tranny oil all over the road. I was able to find another used one and then bolt it up and now I have a small issue. Its been leaking a little bit of tranny oil through the one piece on the bottom that has two bolts on it and a VW logo on it.
View 5 RepliesGolf IV / Jetta IV :: Clutch Feeling Softer After Tranny Change
So long story short, last week I destroyed my first gear in the tranny. This weekend I did the complete swap and put a used o2j in. 5 speed. 2.0 motor.
Right after the swap, on the first startup I noticed the clutch felt softer. The grip is also a little less than it used to be.
Right before my transmission blew I upgraded from 15" alloys to 17" longbeaches with spacers all around- much heavier. It happened on my first drive with the new rims so I didn't get to feel the car much.
I reused my current slave cylinder. Did not disconnect it from the line while swapping. I did however notice my slave boot had a small little dent in it (super small) but no tears or anything. Also, reinstalling it i pushed it in and compressed the boot and secured it with the bolts - I hope I did this right.
I redid my rear brakes about a month ago, did not disconnect brake lines or bleed the system.
I have already driven about 50km on the new tranny. Today I am getting the tranny service (flush) done because I didn't have the sockets to check it after install. I'm going to ask the mechanic if he might know anything. The brakes also feel a touch less but I'm not sure if this is cause of the 17" wheels.. does the system just need to be bled?
All gears go in smooth - clutch in.
All gears go in smooth with car off.
No grinding of gears when switching or driving.
No reverse grind.
No slipping in any gears.
Just a soft pedal and feels like softer bite. I did the tranny swap in a rush, did not replace fork, TOB or anything. They should all be fine, I'm thinking it's just air but need confirmation. I just want this car to last another year or so..
Golf IV / Jetta IV :: 2005 - Cannot Get Car To Start
OK so been about 3 weeks and still cant get my car to start. So far I have installed a new crank position sensor, speed sensor located on top of transmission, new spark plugs, new fuel pump had battery tested and charged. I have tested the fuel injectors and get 13.1 ohms at all injectors tested the new crank position sensor and get 800 ohms. I just had car scanned with VCDS scanner and the codes that come up are. What else can I check.
[IMG] ....
Golf IV / Jetta IV :: 2005 1.8T - Brake Lights Keep Going Out
The brake lights in my GTI keeping going out, I kept replacing the fuse and it kept blowing out.
I then replaced the relay/switch. They worked for a while now out again.
Golf IV / Jetta IV :: 2005 VW Not Starting In Hot Weather
Recently my 2005 VW golf has not been starting in hot weather. The radio, lights, and every other electronic will start when i turn the key. I will push the clutch in and try to start the car and the engine will not even try to turn over. I hear the starter kicking in so I know its not the starter. I had multiple mechanical tests done and no results came up. No warning lights are on. I brought it to a mechanic and he replaced the clutch relay... and that didn't work. If i leave the car windows open for about an hour after the interior of my car gets too hot the car will start. So I am thinking if it has to do with a relay in the cab of the car. What this will be or what I should try?
View 10 RepliesGolf IV / Jetta IV :: 2005 - Won't Start Intermittently?
So my little brother bought a 2005 Vw gli, and it's been pretty good on him so far however, one day he was coming back from work and the car suddenly shut off on him and we haven't been able to get it to start.
(Haven't really been able to actually diagnose it fully since this is his second car)
Did the typical unplugging of the air mass sensor to see if it was that. Checked the relays to see if they clicked Checked all the fuses Checked the ignition switch Checked to see if fuel is getting to the injectors Checked some of the grounds( can't locate all of them)When I turn the key, the rpm needle moves a tiny bit
Golf IV / Jetta IV :: 2005 - Ran Hard And Now Won't Start
Last Saturday I got gas on my way home from work then let my car sit all day. Sunday morning i go to start my car and it starts terribly along with a very rough idle. The ride to work was hideous as the car could barely climb a hill (max 25mph and high RPMs 3000 to 4000). Along with bad hill climbing power the car could barely get to 60mph.
I added a bottle of Gumout as I thought I might have gotten bad gas this had no result. While trying to figure out what was wrong I also replaced the air filter.
Fast forward to Tuesday I decide to inspect the fuses in the car and under the hood (all of which looks in good condition). I started the car before i went inside and it seemed the same as it has been all week. Wednesday morning I go to leave and the car refuses to start. It tries to start but immediately quits and then shakes wildly while trying to start. I have since changed the fuel filter, replaced 5 ignition coils, and given it 5 new spark plugs. The car is still doing the exact same thing it was Wednesday morning.
This is a VW Jetta 2005 2.5 Engine
Golf IV / Jetta IV :: 2005 - Oil Pressure Light?
I got a feeling of dread when that light came on, luckily I was a block from home so I shut it off and pushed it home. I had a local VW mechanic come look at it the next morning, only the light wasn't on anymore there is a loud humming coming from the top of the engine, the head as it were, as if high RPM, but no clanking or metal on metal grinding. Does it spell game over?
View 3 RepliesGolf IV / Jetta IV :: 2005 - Headlights Will Not Turn On
05' TDI Jetta. The headlights will not turn on. The DRL's will work. I changed the dimmer switch, and put in a Euro switch to try and fix it. But the only thing I get when I turn on the headlights are the running lights. All the running lights and interior (dash) lights work fine. I checked the fuses and pulled the 173 relay (to kill the DRL's).
View 7 RepliesGolf IV / Jetta IV :: 2005 - No Power To Injectors
2005 Jetta 2.0L Bev gas engine... Changed fuel pump. and then not getting power to injectors. Changed Battery, fuse block at battery, repaired alternator wire, and changed ignition switch. Tried napa fuel relay and no change. Put old relay in and car started up but died several times. when it shuts off I'm losing power to #32 and 34 fuses. when cycling ignition, power restores at times and car will run. By the way fuel pump has always run since changed. Codes show injector circuit malfunction on all 4 injectors P0201, P0202, P0203, and P0204.
View 1 RepliesCamry :: 2005 LE Surging Under Acceleration Or When Tranny Downshifts
The vehicle I am working on is a 2005 Camry LE with the 2.4L I4 with 172,000 miles. The problem is it surges under acceleration or when the tranny downshifts and engine is under load going up a hill.car idles fine and runs good otherwise. Its hard to explain the surging without driving it yourself but I will tell what I have done so far and car is not showing CEL.
-replaced the AFR sensor (Bosch)
-replaced the O2 sensor (denso)
- plugs look good (no fouling)
I am thinking maybe the throttle position sensor or MAF sensor. What to check next.
Monte Carlo :: 2005 - Tranny Is Doing Banging And Knocking
I have a 2005 monte ss supercharged and the tranny is doing some serious banging and knocking..flywheel is tight..no metal shavings in fluid or around tranny. The noise goes away then I rev the engine or driving. But if I floor it it makes a grinding sound at high rpm..
View 2 RepliesToyota - Rav4 :: 2005 - Dirty Tranny Fluid
Looking at buying an 05 rav4. Everything looked great until I checked the tranny fluid which was grey/pink. It was a trade so no service records but a very clean carfax. I really like the car and it shifts fine including accelerating up a hill. I'm hoping it just needs changing. I'm in need of replacing my 99 CRV with 230k and needs a new head.
View 18 RepliesGolf IV / Jetta IV :: 2005 - AC Not Working / No Power To Compressor
Ok My Ac doesn't work on my 05 Jetta 2.0 blows hot air. These are the steps taken so far to no avail
_Function test A/C System_ A/C is not cold_ Recover A/C, System was low
_Pressure test system with nitrogen for leaks_No Leaks Found
_Charge system and add dye
_Test operation
_Found compressor not cutting in_ Inspect for ground at compressor_OK
_Test for power at compressor_NO POWER GETTING TO COMPRESSOR
_Inspect fuses_OK
What's going on with this and what the next steps might be?
Golf IV / Jetta IV :: 2005 - Clunk Sound When Going Into Gear
So I have a 05 mk4 golf 2.0 automatic. Ive noticed that when i take it from park to drive the car shakes and makes a huge clunk sound like I just got hit by something. Turns out it was a motor mount, I think they call it the dog bone cause its attached to the body & engine of the car. So it was replaced but the car still does it. But not as hard & not as much. Before when I revved the car it would kind of shake and dance. Since the replacement it parks still when I rev it. But that noise is still there. Someone told me it could be another mount or the torque converter.
View 2 Replies