Golf IV / Jetta IV :: 2005 - Fuel Pressure Regulator Location
Where is the fuel pressure regulator on a 2005 Jetta 2.0 BEV. It's nowhere on the fuel rail.
View 1 RepliesGolf IV / Jetta IV :: 2005 1.8t AWP Cranks But No Start - Cannot Hear Fuel Pump Priming
2005 1.8t gti wont start. The other day I was driving on the highway when a thin plastic type wrapping got caught in my serpentine belt. The car immediately died and I hit the gas and nothing and with no power steering i pulled over to the side.
Timing belt was done with water pump and tensioners
Spark plugs and coils are brand new
What fuel line to disconnect to test if the fuel pump works? Like I said in the title I cant hear the fuel pump priming. The engine was running 100% before this 2 techs saw it and the vw dealer i workrd at looked it over.
Mercury - Mountaineer :: 2005 - No Fuel Pressure - Won't Start Easily?
On my 2005 Merc Mountaineer AWD, I've had the fuel pump and fuel filter replaced, crankshaft sensor, ECM relay for the fuel pump, starter, and spark plugs replaced, but to no avail. Car starts when it wants to, but when it doesn't, it'll usually take three to ten minutes of cranking on and off before it fires up. Ford dealership and second repair shop confirmed no fuel pressure to the fuel pump when the vehicle doesn't want to start and recommended a new fuel pump. Problem is, I've already paid the first repair shop for that same service and its gone back to them three times. Could this be electrical as the first shop is now claiming or are multiple mechanics missing something? Second shop replaced the ECM relay out of caution, but the problem persists.
View 5 RepliesGolf IV / Jetta IV :: 2005 - Oil Pressure Light?
I got a feeling of dread when that light came on, luckily I was a block from home so I shut it off and pushed it home. I had a local VW mechanic come look at it the next morning, only the light wasn't on anymore there is a loud humming coming from the top of the engine, the head as it were, as if high RPM, but no clanking or metal on metal grinding. Does it spell game over?
View 3 RepliesGolf IV / Jetta IV :: 2002 GTI Barely Starts And Has Low Fuel Pressure
I got a 2002 GTI 1.8t , with about 109,xxx miles. Ran into a few problems, I took the hose off the fuel rail and turnt the key on. & noticed the fuel pressure was noticeable low & another problem i got is the car doesnt start most of the time. it takes about 3 or 4 cranks before it eventually tuns over. sometimes i noticed if i turn the key on and leave it for a minute or so itll start up. finally want to fix this POS. so I decided to run the codes & heres what i got
P0230
Fuel Pump Primary Circuit Malfunction
CONFIRMED
P0341
Camshaft Position Sensor A Circuit Range/Proformance B1
Golf IV R32 :: Won't Start - Fuel Pressure?
so my car doesnt want to start so i am going to check a few things.
first how do i check my fuel pressure or the location?
Golf IV / Jetta IV :: 2005 GTI Losing Power To Fuel Pump
I have a 2005 Volkswagen GTI with 80k miles. Just yesterday I went to school and the car drove fine. But when I came back and tried to start my car, it stalled out after a few seconds. Now I thought this was a bad fuel pump until I checked it and found that the fuel pump wasn't receiving any power. I checked the fuse and it was intact. So then I went to check the relay and found that if I unplug the relay and plug it back in, the fuel pump momentarily receives power for about 2 seconds then nothing. Any clue what the interference could be?
View 1 RepliesGolf V R32 :: Fuel Trim Stuck In 0 In Turbo Mode
Ever since I made my car turbo (UM tune) my long term fuel trim has been stuck in 0. When talking to Tom over at Innovative Motor sports (they were the ones that got my tune done) he stated that I must have my N80 ( Evap Purge Valve) unplugged, except that I didn't. Until recently, I had every single sensor plugged in except for my SAI pump and the flapper solenoid for the exhaust. My LTFT worked fine before and he can't figure out anything else that could be wrong. So before I send back my ECU to see if a refresh will fix it, what else should I look for?
For more info, my gas tank is venting to the atmosphere, I just have the solenoid connected electronically. This worked fine on my 1.8T so I don't see why it should be any different here. My short term fuel trims fluctuate mostly in the -10 range and off idle drivability could improve a little (thought it's not terrible) and I think that if my LTFT's were working right, it would take care of that.
Golf IV / Jetta IV :: 2005 - Engine Temperature / Fuel Gauge Not Working
I have a 2005 mk4 gli and the other morning I went out to start my car for work and all I got was crank no start. I then realized my fuel pump wasn't priming when I opened the driver door. After work I came back and checked the fuel pump fuse and swapped the relay with another I had, still nothing. A buddy of mine decided to check the connector at the fuel pump for power, using a power probe I believe he hit all or the majority of the wires with 12v of negative and/or positive power. He then unplugged the connecter and plugged it back in and the car fired right up. But I noticed that my fuel gauge, engine temp gauge, and outside air temp readout were all not functioning. I've searched and searched without being able to narrow down a solution.
View 19 RepliesGolf IV / Jetta IV :: 2005 - Engine Temp And Fuel Gauge Both Not Working
I have a 2005 mk4 gli and the other morning I went out to start my car for work and all I got was crank no start. I then realized my fuel pump wasn't priming when I opened the driver door. After work I came back and checked the fuel pump fuse and swapped the relay with another I had, still nothing. A buddy of mine came to me and decided to check the connector at the fuel pump for power, using a power probe I believe he hit all or the majority of the wires with 12v of negative and/or positive power. He then unplugged the connector and plugged it back in and the car fired right up. But I noticed that my fuel gauge, engine temp gauge, and outside air temp readout were all not functioning.
View 1 RepliesGolf IV / Jetta IV :: 2005 - Cannot Get Car To Start
OK so been about 3 weeks and still cant get my car to start. So far I have installed a new crank position sensor, speed sensor located on top of transmission, new spark plugs, new fuel pump had battery tested and charged. I have tested the fuel injectors and get 13.1 ohms at all injectors tested the new crank position sensor and get 800 ohms. I just had car scanned with VCDS scanner and the codes that come up are. What else can I check.
[IMG] ....
Golf IV / Jetta IV :: 2005 - Won't Start Intermittently?
So my little brother bought a 2005 Vw gli, and it's been pretty good on him so far however, one day he was coming back from work and the car suddenly shut off on him and we haven't been able to get it to start.
(Haven't really been able to actually diagnose it fully since this is his second car)
Did the typical unplugging of the air mass sensor to see if it was that. Checked the relays to see if they clicked Checked all the fuses Checked the ignition switch Checked to see if fuel is getting to the injectors Checked some of the grounds( can't locate all of them)When I turn the key, the rpm needle moves a tiny bit
Golf IV / Jetta IV :: 2005 - Ran Hard And Now Won't Start
Last Saturday I got gas on my way home from work then let my car sit all day. Sunday morning i go to start my car and it starts terribly along with a very rough idle. The ride to work was hideous as the car could barely climb a hill (max 25mph and high RPMs 3000 to 4000). Along with bad hill climbing power the car could barely get to 60mph.
I added a bottle of Gumout as I thought I might have gotten bad gas this had no result. While trying to figure out what was wrong I also replaced the air filter.
Fast forward to Tuesday I decide to inspect the fuses in the car and under the hood (all of which looks in good condition). I started the car before i went inside and it seemed the same as it has been all week. Wednesday morning I go to leave and the car refuses to start. It tries to start but immediately quits and then shakes wildly while trying to start. I have since changed the fuel filter, replaced 5 ignition coils, and given it 5 new spark plugs. The car is still doing the exact same thing it was Wednesday morning.
This is a VW Jetta 2005 2.5 Engine
Golf IV / Jetta IV :: Car Won't Crank / Start - Faulty Fuel Pump
1999 Jetta 2.0L manual trans
One day out of the blue the car would not crank or start. Checked and found that fuse #14 was blown and would blow the instant another fuse was inserted. Checked all the typical locations for wiring issues usually associated with the comfort module because it had all the symptoms of a faulty module (the power windows did not work and the fuel pump didn't pressurize the system when the driver door was opened, the alarm didn't set, automatic door locks also inoperable).
I checked the dome light, trunk hinges, rubber boot between doors and body and found nothing. Put a jumper wire into the neutral start relay and was able to crank the car. I then replaced clutch safety switch, neutral start relay and installed new (junkyard) comfort module and the car cranked up, started and everything was working normally again...for about 3 weeks. Then it did the exact same thing again. Fuse #14 was blown again and would blow the new fuse as soon as it touched the terminals in the fuse box.
I reinstalled the jumper wire in the start relay in order to be able to drive the car for the last week, and then last night out of the blue the car would crank, but not start. I turned the engine over several times and could hear the fuel pump pumping and even smell fuel, but no start. 3-5 minutes later after random tries to start, the car stumbles to life as if it wasn't getting fuel, and then drove 10 miles home with no issues. I returned the 'faulty' comfort module Monday and got another one but haven't installed it yet because I fear the same thing happening with this one as the other one.
Last night after I got the car home, I plugged in the comfort module and everything worked like it was supposed to. Can a faulty fuel pump damage the control module? I'm trying to get to the bottom of this and fix the problem and not the symptoms so I'm looking into anything that could potentially cause the problem.
Golf IV / Jetta IV :: 1.8t AWP Won't Start - Fuel Pump Not Priming When Key Turned On
Its a 2005 awp 1.8t gti with 180K stage 2 apr. When i tune the key to the accessories on position I used to hear the fuel pump priming but now I don't and the car wont start.
View 5 RepliesGolf IV / Jetta IV :: 2002 VW Does Not Start / Fuel Flow Restricted
The Symptoms: Car decided not to turn over for my son one morning, when I came home I tried with my key and the engine did turn over but immediately died.
Turned on key to power and watched for lights like the immobilizer/key but that came on and went off no problems there, did the same with both keys and the immobilizer/security key light went off fine.
Read for codes and there was a P0320 which pointed to Crankshaft Position Sensor. Order the part from good old Rock Auto and 2 days later it came, installed, cleared out the code, tried to start, did not start.
Decided to spray some starter fluid into the throttle body to get it to turn over in hopes a new code would come out.
It did fire up for a few seconds and did throw another code, this time P0321. That code points to the same sensor I just replaced.
Figured I would check to ensure the fuel pump and relay were working so I wired from positive and negative battery terminal to the outer plug clips at the fuel pump and I heard and felt it click. Not sure if it should prime and make more than just a click.
In my other cars you can clealy hear it prime for more than a second so not sure if the fuel pump is really the culprit here.
The car has 125K and the pump is original I can see.
I did check the relay fuse under the drivers side dash and I can feel/hear it click when I turn the ignition on.
I also did check all of the various fuses in the side compartment that have to do with the engine, they all look good and tested with multimeter as well.
So now I did order a new fuel pump, what else to try out? I did change the fuel filter at 100K so do not believe that is causing the issue. Not sure if the fuel regulator by the rail could be an issue.
It seems like all of a sudden fuel is not being delivered and with faulty injectors or plugs, they throw a code for misfire etc. Also starter seems to be fine, no griinding/smoke etc but was thinking about taking it out and over to Advance to have them check as well.
Golf IV / Jetta IV :: 2000 - Won't Start At Cold / Poor Fuel Mileage
I own a 2000 Jetta VR6 5 speed. Car has over 300,xxxkm on it, with documented maintenance including chains within the past 12k. Car has intake, 2.5" resonated exhaust, stock software.
I have recently noticed that the car has a cold start issue. Its winter here in Canada, so in the morning when i go to start the car and let it warm up for a couple minutes, the idle is choppy at first and then evens out at around 900-1k rpm. If i try to blip the throttle, or even hold it (half way or WOT) the car just wants to bog out, EXTREMELY rough idle. It will eventually, after about 2 mins of idling, go away and i can drive.
I have absolutely no issue with allowing the car to idle for a few mins to warm up, but i know for a fact that whether a car is cold or not, it should be able to rev freely.
I also have horrible fuel milage. I use 91 octane, and average about 250-300km per tank. 70% city 30% hwy driving.
The following parts have been replaced in the past 1200 to try and resolve the issue
OE Mass air flow sensor
OE spark plugs
BREMI wires
OE Bosch front O2 sensor
I have scanned the car several times, which led me to change the parts i did. Only had a CEL once and it was for the front O2 sensor which i just replaced. Any other codes were for random multiple and a cat efficiency fault. Again those were fault found off a GFF test done at VW, they were not enough to trigger a CEL, but i still changed the parts.
Golf IV / Jetta IV :: No Start After Replacing Fuel Lines To Rail In Engine Bay
Yesterday , my feed fuel line was dry rotting and leaking gas so I bought 516 fuel injection hose and replaced them. Pulled fuse 28 , started the car and let it die to release pressure , fixed the hoses and put the fuse back in and now it just cranks forever. I have spark , and I'm getting fuel just not sure if it's adequate pressure. When I open the door the pump did sound a little funny when it primed. I'm gonna pull it out and check it later but right now I'm completely stumped. I did this last night around 8pm and it's 4:30 am the next morning and still not start.
View 6 RepliesGolf IV / Jetta IV :: 2005 - Cold Start - Chokes / Sputters Like It Isn't Getting Enough Gas
So my new problem is cold engine starts If it's mildly cold out like 30-40 F or 0-10C and has been sitting awhile the car won't start on the first couple of tries. It tries to start but I guess chokes/sputters out like its not getting enough gas. Warm engine it starts instantly.
I put a bottle of gumout regane fuel system cleaner in the tank hoping its a dirty fuel system seeing it feels like it chokes out on gas during the cold start. I'm about half way done that tank and was going to add another bottle on the next tank.
I'm worried about the cold winter approaching and found out issue 8001 today that the oil pan heater is ripped off with broken wires and missing cover.