Ford A/C :: Fan Sounds Like Its Blowing Hard On High But Air Flow Seems To Be Restricted
My fan sounds like its blowing hard on high but air flow seems to be restricted some. I have noticed a sound of the fan hitting leaves in the past. I just don't know how they get in there. It still cools good but air flow is nice when the temperature is close to 100.
96 Ranger 2.3 XLT Regular Cab ...
Ford F-150 - 1997-2003 :: Overheating In Hot Weather - Restricted Coolant Flow?
I have an 1997 F150/4.2 V6/220,000 miles/4x2. During hot weather (over 90F) the engine slowly overheats. While driving on the interstate (from Indy to Fort Wayne), the coolant temperature shows normal on the gauge. Slowly the temperature gage creeps up to close to the red area. I am running the A/C.
When I switch the heater on and the heater fan at max, the temperature gauge drops pretty quickly to a normal range. I switch off the heater and the A/C back on, then it takes 30 minutes for the temperature gauge to start rising again.
When I open the hood when the gage shows close to the red area, the upper coolant hose has a lot of pressure (cannot squeeze it), which would mean that the thermostat is open and the waterpump is working. Also the fan is running fast. The coolant was changed out a few weeks ago and the coolant level is at normal level when the engine is cold. At lower ambient temperatures, there is no overheating. I am puzzled what the problem can be. I am thinking of a restricted coolant flow. Looking for solutions to my problem.
Golf IV / Jetta IV :: 2002 VW 1.8t - How To Replace Fuel Line
I need to replace the fuel line that connects to the fuel rail, it is old and corroding and drips out gas when I dry so I need to replace it. I have the new fuel line for it but how would I go about taking it off and the clamps? Just wanna make sure I am doing it right.
View 1 RepliesGolf IV / Jetta IV :: 2002 GTI Barely Starts And Has Low Fuel Pressure
I got a 2002 GTI 1.8t , with about 109,xxx miles. Ran into a few problems, I took the hose off the fuel rail and turnt the key on. & noticed the fuel pressure was noticeable low & another problem i got is the car doesnt start most of the time. it takes about 3 or 4 cranks before it eventually tuns over. sometimes i noticed if i turn the key on and leave it for a minute or so itll start up. finally want to fix this POS. so I decided to run the codes & heres what i got
P0230
Fuel Pump Primary Circuit Malfunction
CONFIRMED
P0341
Camshaft Position Sensor A Circuit Range/Proformance B1
Golf IV / Jetta IV :: CEL Comes On - Insufficient Air Flow
So my check enginr light has been on for a while saying "po411" "insufficient air flow" but dont know where the vacuum leak is coming from. But today I was working under my car and saw this "hose" that is connected to the air pump looks like it's leaking??
View 3 RepliesFord 6.7L Power Stroke Diesel :: Turns Over But Won't Start / No Fuel Flow
I changed out my fuel filters today on my 2016 F350 SD and right parts, no leakes, main filter full, and I did the 6 cycle fuel pump prime. Turns over but won't Start. Redid the 6 cycle prime several times now and still no start. Pulled the 2ndary filter lines while it was priming to see if flowing and got squirted on both lines.
View 8 RepliesGolf IV / Jetta IV :: 2002 - Won't Start Sometimes?
Now I'm back and just picked myself up 2002 Golf GTI with fairly low kms for its year. Anyway when i test drove and checked through it all everything seemed fine. Basically she won't start 1/6 times. So for example of the amount of usage she had today:
AM - Drove to work this morning, started fine from cold (its just come into winter so probably around 12 degrees Celsius).
PM - Drove home from work, started fine from cold
Evening (3 hours approx. after driving home) - started fine from cold, drove 5 mins, stopped at gas station, started fine and drove another 5 min then stopped and parked.
After parking, i decided to move her closer to the building for security but when i cranked her she would turn over but not start. Tried this 2 or 3 times (probably flooded the engine).
After about 1 1/2, jumped backed in, started first time but took a few seconds to start with foot slightly on gas. Checked the fuel pump, i can hear it switching on so can rule that out.
I'm suspecting its a battery issue based on history (has had all the major service parts done timing belt, fuel pump etc) and for the majority of its life, its actually just sat in a garage, according to the dealer (old guy that lived and worked in the city owned it before me) and that this just needs replacing. The battery doesn't look old however under the bonnet it is stupidly clean so might not be an indication of anything.
I haven't had a flat battery for a while though but from what i remember, a flat battery just clicks or even struggles to turn over? Any simple things i can check myself? Just went downstairs to check fuel pump, thats switching on and car started fine 4 times in a row.
Golf IV / Jetta IV :: Car Won't Crank / Start - Faulty Fuel Pump
1999 Jetta 2.0L manual trans
One day out of the blue the car would not crank or start. Checked and found that fuse #14 was blown and would blow the instant another fuse was inserted. Checked all the typical locations for wiring issues usually associated with the comfort module because it had all the symptoms of a faulty module (the power windows did not work and the fuel pump didn't pressurize the system when the driver door was opened, the alarm didn't set, automatic door locks also inoperable).
I checked the dome light, trunk hinges, rubber boot between doors and body and found nothing. Put a jumper wire into the neutral start relay and was able to crank the car. I then replaced clutch safety switch, neutral start relay and installed new (junkyard) comfort module and the car cranked up, started and everything was working normally again...for about 3 weeks. Then it did the exact same thing again. Fuse #14 was blown again and would blow the new fuse as soon as it touched the terminals in the fuse box.
I reinstalled the jumper wire in the start relay in order to be able to drive the car for the last week, and then last night out of the blue the car would crank, but not start. I turned the engine over several times and could hear the fuel pump pumping and even smell fuel, but no start. 3-5 minutes later after random tries to start, the car stumbles to life as if it wasn't getting fuel, and then drove 10 miles home with no issues. I returned the 'faulty' comfort module Monday and got another one but haven't installed it yet because I fear the same thing happening with this one as the other one.
Last night after I got the car home, I plugged in the comfort module and everything worked like it was supposed to. Can a faulty fuel pump damage the control module? I'm trying to get to the bottom of this and fix the problem and not the symptoms so I'm looking into anything that could potentially cause the problem.
Golf IV / Jetta IV :: 1.8t AWP Won't Start - Fuel Pump Not Priming When Key Turned On
Its a 2005 awp 1.8t gti with 180K stage 2 apr. When i tune the key to the accessories on position I used to hear the fuel pump priming but now I don't and the car wont start.
View 5 RepliesGolf V R32 :: Movement Restricted Error Is Coming
I am having some issues with my radiator fan (the big one). Vagcom show an error I think it was "Movement Restricted / Jammed" so I'm thinking of ordering a new one but not the OEM . A year ago I had issues with the same fan, hit it with a small bat and it worked fine until now.
[URL]........
Golf IV / Jetta IV :: 2002 GTI 1.8t AWP Won't Start On First Crank?
So i got a 2002 gti 1.8t awp . Wont start unless I crank it about 2-4 times. Also noticed a bit of a grinding/high pitched noise when cranking. when the car starts up it idles perfect, doesn't die , drives perfect etc...
Eventually i got the car scanned. & got 2 codes.
P0341 : Camshaft Position Sensor A Circuit Range/ Performance B1
&
P0230 : Fuel Pump Primary Circuit Malfunction
So I went and bought a Fuel pump , Camshaft position sensor & Even a new starter. Nothing fixed it. & the problem still occurs..
Heres a video of me trying to crank it ; [URL] .....
Golf IV / Jetta IV :: 2002 - No Start / Not Even Turning Over
2 weeks ago my fans stayed on all day and killed my battery. Did a bunch of research and found that the FCM would be a possible place to start. FCM was literally in pieces under the battery. Replaced it with a new one. Still no fans. Popped open the fuse box on top of the battery. Fuse closest to the engine was blown and the plastic had started to melt. Bought a whole new one of these and replaced it. This time I read about the AC test with the car off. AC works (which is a pleasant surprise) but only the big drivers side fan works. The small passenger side fan never turns on. Turned the key off and the fan stops so that's good, I think. Ever since then my battery gets drained if it sits for so many hours.
Everything I read points to that fan going bad and becoming inoperable. But is that what is causing my battery to drain? Today I pulled the fuse nearest the engine when I got to work to see if my battery stays charged all day. Well as of right now it will not even turn over. Went out after work and it turned over 6 times but did not start. Started to jump it using my buddies car. Let it charge for 20 minutes and now it wont turn over. Have dash lights. Glow plug light is working as it should. Headlights everything works. Charged up the battery. Have 13 volts at the battery. Doesn't make a difference. Still will not turn over. Going to pull my battery tray after work and see if I can see the solenoid. Will see if I have any power there. Can I see the solenoid from the top of the car? Probably not...
Golf IV / Jetta IV :: 1.8T AWP GTI Overheating - All Of A Sudden Coolant Starts To Flow
I am having a overheating issue with my 1.8t AWP gti, it goes as fallows, start the car, engine warms up go for a drive (short 5-8 mi), park the car and temp gauge starts to rise, (turns off car)... I began to check some things with the system, I checked both rad hoses bottom is hot top is a bit hotter and fans work when ac is on; here is where it gets interesting i took off the coolant return hose on the reservoir (cold start) and nothing was flowing ...water pump?... So i turned the heat on and air full blast and all of a sudden coolant starts to flow.
It also seems like air is being spat out as well. Soon after the flow beginning my coolant in the reservoir starts to fluctuate (rising and dropping) with air bubbles and beginnings to over flow so i shut the car off. Now I know what the possible issues are its either the water pump, air in the system or bad autozone thermostat. Here is some history of the car TB was replaced at 70,000 by Previous owner, i bought the car had the belt inspected and was told it was good, about 2 months ago i had a coolant leak and had it misdiagnosed as a thermostat housing leak; it turns out it was a coolant bypass hose that was leaking so i ended up fixing it. I lost a lot of coolant but topped it off with g12+. My mechanic doesn't think its the water pump and recommended changing the thermostat for an VW one another mechanic recommended to bleed air of the system.
Golf IV / Jetta IV :: 2005 GL Trim 2L SOVC Won't Start On First Try - Fuel Pressure?
I have a 2005 Golf GL trim 2L SOVC. For months now the car won't start on the first try. One must let off the key and disengage the starter then reengage. It always starts the second try and never starts the first. Once the engine runs for a few seconds, if you turn it off, then start it again, it immediately starts. It's never a problem en route. Only if you let the car sit for a while, say 8hrs or more, (when the fuel pressure dies) do I observe this "no start on first try" behavior.
I recently replaced the plugs and fuel filter and cleaned the throttle body. It's a little better now. It stumbles like it is going to start on the first try after sitting but doesn't.
I exposed the fuel pump and measured the voltage going to it. When you turn the key to "on" position, the engine computer put's voltage to the pump for about 1.5 seconds and that's it. So while you are cranking I guess it expects that 1.5 seconds of pump operation is enough. I put my fuel pressure guage on the port near the injectors, and, as I suspected, the pressure only builds to about 28lbs. On the second try it gets up to 40. Once running it's about at 45lbs.
Sounds like a firmware bug to me.I'm considering wiring in a switch that I can toggle to deliver more on time to the pump inititally - maybe 3 seconds? Is this normal?
I noticed that when I put the fuel pressure gauge on initially there was zero pressure. Is this normal?
Shouldn't a check valve keep it at pressure? Where is the check valve located? I'm also getting a P0171 code "engine too lean". I repaired a hole in the air hose going from the air pump to the throttle body - still get the code. All hoses look good.
Golf IV / Jetta IV :: 2000 - Won't Start At Cold / Poor Fuel Mileage
I own a 2000 Jetta VR6 5 speed. Car has over 300,xxxkm on it, with documented maintenance including chains within the past 12k. Car has intake, 2.5" resonated exhaust, stock software.
I have recently noticed that the car has a cold start issue. Its winter here in Canada, so in the morning when i go to start the car and let it warm up for a couple minutes, the idle is choppy at first and then evens out at around 900-1k rpm. If i try to blip the throttle, or even hold it (half way or WOT) the car just wants to bog out, EXTREMELY rough idle. It will eventually, after about 2 mins of idling, go away and i can drive.
I have absolutely no issue with allowing the car to idle for a few mins to warm up, but i know for a fact that whether a car is cold or not, it should be able to rev freely.
I also have horrible fuel milage. I use 91 octane, and average about 250-300km per tank. 70% city 30% hwy driving.
The following parts have been replaced in the past 1200 to try and resolve the issue
OE Mass air flow sensor
OE spark plugs
BREMI wires
OE Bosch front O2 sensor
I have scanned the car several times, which led me to change the parts i did. Only had a CEL once and it was for the front O2 sensor which i just replaced. Any other codes were for random multiple and a cat efficiency fault. Again those were fault found off a GFF test done at VW, they were not enough to trigger a CEL, but i still changed the parts.
Golf IV / Jetta IV :: No Start After Replacing Fuel Lines To Rail In Engine Bay
Yesterday , my feed fuel line was dry rotting and leaking gas so I bought 516 fuel injection hose and replaced them. Pulled fuse 28 , started the car and let it die to release pressure , fixed the hoses and put the fuse back in and now it just cranks forever. I have spark , and I'm getting fuel just not sure if it's adequate pressure. When I open the door the pump did sound a little funny when it primed. I'm gonna pull it out and check it later but right now I'm completely stumped. I did this last night around 8pm and it's 4:30 am the next morning and still not start.
View 6 RepliesGolf IV / Jetta IV :: 2002 - Car Will Crank Fine But Never Start
2002 Jetta GLS 1.8T (engine stock except diverter valve) 171k miles
It's done this a couple times now. Both while raining out/high humidity. Prior to this, I could hear the pump "growling". Sounded like maybe starting to go. You could hear it prime when opening the door or turning the key forward but would stay sounding like that even when the car was started. Without the radio, you can hear the pump running.
1st time- The car will crank without issue but never start. I let it sit a few minutes, turned key, heard it prime,tried again, started right up like there wasn't an issue and I couldn't hear the pump this time while the car was running.
2nd time-The car will crank without issue but never start. I let it sit for an hour, opened door (couldn't hear prime), checked fuse 28 (good). Figured wth, let's try anyways. Turned key, couldn't hear prime, started right up. WTF. cold idle normal (1000-1200rpm), light revs to 3000 ish normal. Turned off car, let sit for a minute. Turned key, heard prime, car started without issue and I couldn't hear the pump again while the car was running.
My dad is thinking to replace the pump right away. Is there anything else to try? The relay is working... at least sorta. With the somewhat intermittent issue, where to start? Either way, relay or pump, I will be replacing fuel filter.
Golf IV / Jetta IV :: 2005 1.8t AWP Cranks But No Start - Cannot Hear Fuel Pump Priming
2005 1.8t gti wont start. The other day I was driving on the highway when a thin plastic type wrapping got caught in my serpentine belt. The car immediately died and I hit the gas and nothing and with no power steering i pulled over to the side.
Timing belt was done with water pump and tensioners
Spark plugs and coils are brand new
What fuel line to disconnect to test if the fuel pump works? Like I said in the title I cant hear the fuel pump priming. The engine was running 100% before this 2 techs saw it and the vw dealer i workrd at looked it over.
Golf IV / Jetta IV :: 2002 2.0L 5 Speed - Intermittent Crank No Start
I have a 2002 2.0L 5spd Jetta that has an intermittent crank no start issue. The car has about 140k miles on it. The car will crank, but will not always start. It seems to start about 8/10 times. During the cranking, there is a rough noise coming from the starter area. More on this noise later.
When the car starts, no codes are thrown. When it refuses to start, the following codes show up:
P0261 Cylinder I Injector Circuit Low
P0267 Cylinder 2 Injector Circuit Low
P0270 Cylinder 3 Injector Circuit Low
P0264 Cylinder 4 Injector Circuit Low
P0445 Evaporative Emission Control System Purge Control Valve Circuit Shorted
P0037 HO2S Heater Control Circuit Low B1S2
P0418 Secondary Air Injection System Relay "A" Circuit Malfunction
P0420 Catalyst System Efficiency Below Threshold (I don't think this is related to the intermittent starting issues)
I've read up on these codes, and there are instances of other people getting these codes as well, but unfortunately, I haven't found any "smoking gun" that's the root cause to solve the issue. What I've tried, chronological order; none of these solved the problem:
Checking for spark. The spark plugs are new (within 2 months), but I removed spark plug and checked for spark.
Check fuel system: I removed the fuel line to the engine and drained it to a jug. I saw fuel flow intermittently when I keyed on the car. (Should it flow continuously?)Replaced the fuel filterSwapped fuel relay 409Checked wires near relays for obvious signs of damage (admittedly maybe I missed something here)Swapped coil pack. The coil pack was replaced in April, but I put a different one on, to no avail.
The spark plug wires were replaced at the same time as the coil pack.Starter
Thought fixing the noise might fix the starting issue. The noise from the starter is a grinding noise that occurs during the cranking process (not after, as is a common problem with these Jettas. It's NOT this noise: [URL] .... In any case, I tried the fix for the above noise by removing the starter and regreasing the inside. That didn't work and the noise and the intermittent starting issues are still here.Finally took the starter to Advance Auto Parts, had it tested, and was told it was good.
I think I have two issues that may or may not be related- the intermittent starting issues and the noise issue. They started happening at close to the same time.