Golf IV / Jetta IV :: VW 2008 - OBD Communication Failure
Took the emission test at two different facilities last week, both test failed with an error saying "OBD Communication Failure".
This is a 7 years old car, with 63K km, nothing has been changed on this car, it still has the original wiper blades .
I went to a VW dealership today (Toronto) and this is what they did:
- Performed ODIS diagnostics, results were ok, no DTC,s in the system
- Performed a drive clean, aborted due to communication error
- Performed technical diagnostics cap discharge system, ok.
- Tested ECM ok
- Performed basic wiring test, ok.
- Next step was to remove the cluster and perform 1598 pin out diagnostic - This is where I quit.
I assume at this point I need to go through drive cycle procedure since all codes have been cleared at VW, if it's possible that there is an issue only when generic scan tools (Clean Drive OBD test systems) are used, issues with Drive Clean system software, or there is something else?
Golf IV / Jetta IV :: VR6 Will Not Start / Just Cranking - No Communication To ECU
I have a Mk4 GTI with the 24v vr6. Car wont start, just cranking for days. This all happened a week ago. I was at work, went on lunch at 12 and drove home to eat, come back at 1 and park it. 4 o clock I get off, try to start my car and nothing. Just cranking no turn over. Ive had no prior problems with this car, other than some misfires from 2 different coils, which I've replays 2 of them.
Car has absolutely no spark. Here's the parts I've regretted throwing at it because of this
-Coolant temp sensor
-Spark plugs
-Crankshaft sensor
-Fuel pump relay
I thought for sure it would of been the crankshaft sensor but I put it in and got nothing. I've checked all my fuses and they are all good. Finally got my code read with a vagcom last night and got these 2 codes
01177 no communication to ecu
01314 no communication to ecu
I also get no CEL when turning the key on "ON" which tells me ecu.
So I've kind of narrowed it down to 3 things, but it wouldn't surprise me if it was something else though. I think it's either the ECU, relay 428 for ecu, or wiring on the ecu. I swapped in a working BDF ecu and got nothing. I figured it would at least start and then cut off because of the immobiliser, but maybe im wrong. I know when my key imobiliser died it started and then cut off, maybe with a different ecu that's not married to the car is different and wont start, I am not sure. how this works.
So after the ecu swap didnt work I started reading wires. Going off the diagram here [URL] .....
I have found the following
a) pins 1/2 for ecu ground are OKAY read 12v
b) pin 21 read 12v
c) pin 3 would go to about .12 while cranking. idk what it is supposed to be
d) pin 23, which is ground to the relay 428, read .01, which is the same reading i got off the ground for the relay spot
e) pin 62 gave me nothing with the car off
So right now my concern is kind of on the relay 428. I don't know what it is supposed to read but that seems kind of off for .12v power while cranking and .01 ground. What should these readings be? should i be reading them while cranking?
Golf IV / Jetta IV :: 2001 - No Communication With OBD Port?
I have a friend who Just picked up a 2001 GTI 1.8T (auto) and it has a Check Engine Light, but will not communicate with the scan tool. It does have an aftermarket radio, and I did unplug it for giggles, but still no comunication. the K line has 8V on it now.
Is there something IM missing here thats a common problem?
Ford 7.3L Power Stroke (1999-2003) :: Resealed HPOP - All Fine Now Died As Pulling Into Driveway?
Resealed HPOP, reinstalled, started right up, ran for good half hr, shut it down, started it next day, ran for 15 min. Revved it up, n all that, good to go, took it for a spin around block, died as pulling into driveway. At crank Dashcmd shows 200 psi on HPOP. I'm double checking the gear bolt right now. When I installed the pump I seated the gear by hand n torqued bolt to spec, so idk...
View 3 RepliesGolf IV / Jetta IV :: 2003 VR6 Started Sputtering And Then Died
I have a 2003 Golf VR6. Last weekend the car started sputtering and then died. I haven't been able to get it restarted since. I have already replaced the fuel pump relay and the fuel pump. Since I replaced the fuel pump it will prime when I open the door or when I insert the key. When I go to start it it will only stay running for 5-10 seconds then acts like its running out of fuel and dies. EVERY. SINGLE. TIME.
Its not throwing any codes other than a couple 02 sensor codes telling me its running lean. What to do at this point. I was told that vws have a secondary fuel pump relay under the passenger rear seat that sometimes when it goes bad it will turn on the fuel pump to prime it, but wont kick on when its supposed to stay on. I cant find anything on the interweb about it. The shop I took it to that diagnosed the fuel pump said it wasn't throwing any codes when they scanned it.
Golf IV / Jetta IV :: 2003 GTI - No Start After Car Died While Idling
I'm running into a brick wall trying to get my GTI to start. This post is my last-ditch effort before just towing it to a shop.
A little over a week ago, the car just died while idling outside a buddy's house. Prior to dying, it had been having some sputtering starts and had been dying while driving as well (engine cut outs) for about a month, but it had always started right back up strong after cutting out.
First I tried replacing the crank position/engine speed sensor. No dice, still not starting. I had new spark plugs in the toolbox so I popped them in, still nothing. Then I realized that my spark plugs were totally dry when I changed them. I pulled the hose off the fuel rail, tried to start the car, no fuel. I had a more mechanically inclined friend come out with a multimeter and he checked my fuel pump and relay. He tells me the relay is good, but the pump must be fried because it's getting power but not pumping (I'm not certain of this as I didn't physically lay eyes on the multimeter when he told me this). The next day, I replaced the fuel pump and the fuel pump relay just to be safe. The car started! I thought I had it all figured out. I drove the car for two days and then, last night, it refused to start again. This morning, pissed off, I went back and was ready to tow it but it started right back up again on the first try. I drove it home, but then later when I went out to go grab a burrito it wouldn't start again. It cranks and cranks but just won't catch.
Pertinent information:
- I do have a CEL. Don't remember the exact code it's throwing but it's something like "Engine distributor circuit, no signal." The code cleared after installing a new fuel pump, but the CEL is back now. Could be a new code, though as I don't have a scanner.
- No other nasty dash indicators are on.
- With the new fuel pump, even when it was working normally, I never heard the usual "priming noise" you get when opening the driver's door. This is strange to me as I used to hear it all the time.
- The car cranks normally but I think it just isn't getting fuel, even with a brand new pump, plugs and relay.
- About a year and a half ago, the coil pack was replaced under the recall campaign.
After all these new parts, I'm thinking electrical. A ground short or something. But I've seen that for some people it was the ignition switch, or the IMMO, or the fuel injectors, etc....
Golf IV / Jetta IV :: Beeping Brake Warning Light When Go Up Steep Driveway
Had the 2003 Jetta in for inspection, and he said the rear brake caliper was gone. SO he replaced it.
Now in the morning when I leave for work, as I go up my steep driveway, the brake warning light comes on and beeps at me. Then it stops.
On the way home, as I come up the steep road to my driveway, the warning light comes on and beeps at me!
All other times and all other driving, it's fine.
Golf IV / Jetta IV :: Condensation On Inside Windows When GTI Sitting In Driveway Unused
My Gti has been sitting in my driveway unused for a couple months now. The condensation in it has been unusually heavy when parked. The carpet is dry, doesn't smell damp inside, no coolant smell. Windshield was replaced 2year ago never had a prob with it so idk if it's that that's leaking, but what would the signs of that be? But what I really think it could be is that my recirculating flap is stuck closed. Could that be it?
View 9 RepliesGolf IV / Jetta IV :: After Driving For 20 Minutes And Sitting In Driveway VR6 Start Running Hot
This only happens once or twice a week. After driving the car for 20+ minutes and sitting in the driveway, it will start running hot. I'd say around 230 degrees and it will stay there until I start driving the car again. I made sure the fans work and I also checked the coolant level and both are fine. What could be causing this issue?
View 2 RepliesGolf IV / Jetta IV :: 1999 - When Pulled Out Of Driveway Car Started Running Rough
I have a Jetta Mk IV, yesterday I went to go drive it and just as I pulled out of the driveway it started running rough, so I pulled back in the driveway and the coolant temperature sensor light came on, then the check engine light. and then it died. Then today I tried starting it, and it will only start and run if I have the gas pedal all the way to the floor, and it runs really rough. Then it will die. I thought maybe the coolant temp sensor since the light came on. I replaced that, and it still does it. I'm leaning towards a head gasket.
View 2 RepliesStalling - Jetta - Volkswagen :: 2003 1.8T Stall Randomly When Driving Or Idling In The Driveway
I am having a problem with my car stalling randomly. It happens when I am driving and it also happened when the car was idling in the driveway. I believe it to be an electrical problem as there are no lights on the dashboard when I try to turn it over, however after a few minutes it will start and run ok. At first I thought it was the fuel pump, but now I'm not so sure. There is no pattern to when it happens either. When driving the car will start sputtering then stall. I'll let it sit for a minute or so, then it starts again. What can be causing this?
View 5 RepliesFord 6.0L Power Stroke Diesel :: Died In The Driveway?
AE shows 600+ ICP while cranking, 48.5v-49v ficm continuously, has sync, has 50 psi fuel with manual gauge, replaced fuel filters with Ford, fresh oil change, 2 new batteries, cleaned EGR, no codes.
Prior to this I changed the driver's side injectors because (before I had AE) Ford said it needed #8 (power balance) due to a stutter at minimal load at highway speed. Figured I'd change them all due to 290,000 miles. Had enough cash for 1 side this month. Ran great! Had AE hooked up and showed all good pressure, volts, temps then died in the driveway.
Golf IV / Jetta IV :: 2002 VW GTI 1.8 T Died While Driving
I was recently driving home when I made a left hand turn and the car died. I had the timing belt and water pump replaced 1,800 miles ago. It sounds like a timing issue to me. The last time I had timing issue it wouldn't run. This time it runs. Attached is a video of me starting it with the camera looking at the timing belt. The noise I heard made me shut it off. I did not want to cause more damage.
[URL] .....
Golf IV / Jetta IV :: Died Won't Start But Crank?
Driving home on the highway today, not boosting, just regular driving. Car was acting fine, then just shut off. Tried starting, and it would crank, but not actually start.
Got it towed home. Scanned. Two codes: 01314, Engine Control Module. And again, 01314, Engine Control Module. Tried clearing codes, and it says "comm. error". Im using the VAG Check scanner from ECStuning, has always worked fine.
Thought it could be fuel pump, but the fuel pump primes when I open the door. I did notice that the throttle body refuses to align when I put the key in the second position, when it always has before. Radio works, all presets work. Unplugged the battery for a half hour, replugged, nothing. I'm leaving it unplugged overnight to see if that does anything.
Golf IV / Jetta IV :: 2004 GLS Started And Then Died Immediately
Previously, I have had no rough starts or other starting issues, and no issues with my battery, which is 4 years old. I left work and had some errands to run--started my car, drove about 1/2 mile. Started my car again, and drove about 1/4 mile. Started my car again, and drove about 2 miles and stopped at a gas station. Started my car again and drove 2.5 miles.
This time, my car started fine, and I began to take off (moving forward--no car in the space in front of me) and after about 5-10 feet my engine died. I haven't been able to start it since. The starter is turning well, but I don't hear anything firing, and giving it gas as I hold the key over does nothing.
Where should I start? I have a video of trying to start, I may try and upload to Dropbox and post. Car is a 2004 Jetta GLS with 247k, and I currently have no DTCs stored (checked using a generic OBDII scanner, not a Vag).
Golf IV / Jetta IV :: Battery Died - Alternator Malfunction
Been the proud owner of a '04 Golf for a few years but it hasn't been without its share of hiccups. I recently had my battery die on me. Got the car looked at and apparently the alternator was the culprit, ie, it wasn't functioning and re-charging the battery. Swapped out the OEM for a rebuilt Bosch 120A (my car is a 2.0GL, so it's supposed to be 90a default, but I looked online and saw that I could use the 120). Even put in a new battery as the old one was past its prime. Now the new alternator (which was not fun to install) isn't working either. I had a different mechanic look at it and they said that while the auto shop gave me the right part number, that apparently VWs are hinky with aftermarket parts and I'd have to take it to a VW dealer for a diagnostic? Makes no sense as I've seen tons of people online who've used aftermarket alternators with no problem.
So now the car essentially is dead in the water. Battery light comes on when the car is started and I'm not tempted to not drive the car anywhere out of fear that the new battery will die in mid-traffic. I've checked the grounds, pulley, etc, everything looks fine and connected proper. What could be going on?
Golf IV / Jetta IV :: Produce Cloud Of Smoke And Oil - Died
My k03 blew up after 100k miles in a cloud of smoke and oil... Where is a good place to buy a k03 turbo for less than $900 or so?
View 2 RepliesGolf IV / Jetta IV :: 2005 GTI Started / Ran For 15 Minutes Then Died
Ok so I started car ran for about 15 min at idle but ran rough a few times then died now wont start. O yea I drove it on sunday and the speedometer and odometer stopped working also.
View 2 RepliesGolf IV / Jetta IV :: VR6 Died While Driving / No Start And Multiple Codes
I was driving down the road when my car (02 GTI 12v VR6) suddenly died. I pulled off and tried to restart it. It sounded weird, kind of metallic like maybe the clutch went out. It seemed to be firing, but would not turn over so I stopped trying for fear of damaging something. I thought the timing chain may have come loose, however I didn't hear anything catastrophic like valves breaking so if that's the case then hopefully it only jumped a tooth or two. I scanned it and a bunch of codes came back. I did have the battery out for a while before scanning so I'm not sure if some of the Central Convenience codes are due to that or not.
Here's the full scan:
VAG-COM Version: Release 409.1-S
Chassis Type: 1J - VW G/J/B Mk4
Scan: 01,02,03,08,16,15,17,19,22,35,46,56
[Code] .....