Ford - Explorer :: 2002 - Green Wire Cut Extending Out Of Harness Connecting Rear Lights?
While pulling the bed and dropping the fuel tank to replace the sending unit, I noticed a green wire that had been cut extending out of the harness of wires that connect the rear lights. a bunch of cars were tagged in the neighbor hood and they probably cut that wire. it connects to a black and red wire in the Y at the harness. Where does it go to? Simple ground wire? No tow package on the truck either. Where it leads too?
View 4 RepliesCamry :: Broken Wire Harness Spark Plugs
Two of my plugs locking clips broke today on the wire harness side where the coil over plugs into the harness today while changing spark plugs. They will plug back up, but they won't lock together like they are suppose to. How critical is this? It is my wife's car will she break down? I drove the car maybe twelve miles, and everything seemed fine.
View 8 RepliesFord - Explorer :: 2001 - Oxygen Sensor Wire Harness?
I have a 2001 ford explorer sport and realized that the oxygen sensor on the passenger side behind the cat was unplugged from the harness.
I am unable to find the harness and dont know where its supposed to go.
I would like to get this fixed right away but can not find a diagram anywhere, or a manual...
Golf IV / Jetta IV :: Harness Protection Coolant Temp Sensor
I just replaced my CTS, and I noticed that there is a small section of exposed harness wiring between the end of the loom and the CTS connector. I can't tell if it came loose when I swapped the sensor, or if it was this way for awhile, but all of the other harness connections around this area are completely covered and the loom end doesn't seem to clip into the connector or anything. If I were to try and seal it, I would need to use tape.
How hot does this area get? It seems like there shouldn't be exposed wiring here.
Picture taken with the new sensor: [URL] ...
Ford 7.3L Power Stroke (1999-2003) :: Stripped Wire Harness Connector Bolt?
As part of my ongoing P1393 troubleshooting, I’ve found that I can’t get the main engine wire harness separated. The big connector by the driver’s side valve cover.
I’ve cranked and cranked in the correct direction, but the plug never separates. I tried a cordless impact wrench and it still doesn’t move. (Edit -- the bolt moves very freely, but it doesn't push out one side (e.g. like removing the PCM) I can't figure out how to separate the two sides.)
Any tips on how to get it separated? Can I cut off the bolt head to get it separated?
Ford 7.3L Power Stroke (1999-2003) :: 2001 - Injector Engine Wire Harness
I'm trying to find a part number for the wiring harness that sits on top of the motor and plugs into the valve cover gaskets. The previous owner replaced the pigtails but the wires were cut so far back that there is virtually nothing left coming out of the harness. What the actual harness looks like other than it has the 9 pin plug on it or whether both sides require an individual harness. What is the part number or picture of said harness. Just in case.... it's a 2001 7.3.
View 14 RepliesFord Super Duty (1999-2016) :: 2007 - Mirror Swap - Wire Harness?
I have a 2007 F-350 SRW. I bought some mirrors of craigslist from two different sellers. They are from 2008 or later, they didn't know the exact year. I have looked in the tech folder and searched and searched. could not find wires that are the same color as mine. Yes, mirrors are OEM. I need to know what color goes to what color.
Do they match color to color? question mark represents color that doesn't line up
drivers side door colors=============== new drivers side mirror colors
green------------------------------------------------- green
black--------------------------------------------------black
green/white-------------------------------------------black/white?
blue----------------------------------------------------blue
yellow--------------------------------------------------yellow
red------------------------------------------------------red
brown---------------------------------------------------brown
passenger door colors=================new passenger mirror colors
green/purple------------------------------------------white?
black---------------------------------------------------black
white/blue---------------------------------------------black/white?
yellow--------------------------------------------------yellow
green---------------------------------------------------green
brown---------------------------------------------------brown
brown/purple-------------------------------------------purple?
Side note these are in no particular order as far as pin location.
Golf IV / Jetta IV :: Misfire On Cylinders - Cracked Harness / Vacuum Leak?
I just bought a 05 1.8T Jetta 116,000miles. and need diagnosing it. It misses all the time. Has new plugs I tried two other sets of coils (from my 2.0 a4 and my dads passat) and it made no difference. The SAI was taken out but nothing is blocked off. Also the coil pack wiring harness has cracks on the big brown wire where it goes down along the block. I'm getting these codes on my vag-com.
16687 cylinder 3 misfire
16686 cylinder 2 misfire
16688 cylinder 4 misfire
17766 cylinder 2 open ignition circuit
17763 cylinder 1 open ignition circuit
17769 cylinder 3 open ignition circuit
17772 cylinder 4 open ignition circuit
So am I correct in thinking that it's from the cracked harness? An not a vac leak?
Ford Super Duty (1999-2016) :: Running Lights Limit On Trailer Wire Harness
Any limited number of lights the factory trailer harness on the truck can tolerate? I'm looking to add some extra running lights on my trailer, also want to put a couple of lights on each running board on the truck, they will be tied in with the trailer harness since it is not monitored by the BCM. I did a search on this a few different ways and couldn't find anything.
View 8 RepliesFord 6.7L Power Stroke Diesel :: Tail Lights Go Out / Wire Harness In Front Left Wheel Well Rubbed
My fathers truck had the tail lights go out the other night so we checked the fuse and the bulbs both good. Took it to ford and they found that a wire harness in the front left wheel well had rubbed through and needed replacement. I went and checked mine and yup it was rubbing through the wire just not all the way yet. Might want to take a look. It is at the top of the well near the coil spring. I will get the camera out tomorrow in the daylight and take a picture of the location.
View 13 RepliesGolf IV / Jetta IV :: 2001 - Hot Plastic Or Wire Smell From Vents
I have an 01 GTI GLX with climatronic, and I've noticed this hot plastic or hot wire smell in the vents. Yes the fan wire gets hot when the car is hot and AC is on. But I don't think that's it. I've torn the passenger side apart, took the blower motor out, not it. The vent / recirculate motor is external to the vents, the only other place is behind the radio for the other one. What else is internal, if anything, that could be causing this smell? I'm concerned that something will melt or burn up.
I've been wondering if the ecm in the cowl would be getting hot but I can't smell anything with the plastics on. I would say it does seem to occur after driving for about ten minutes in town. But it also seems like it's there when I first start it up also.
Ford Super Duty (1999-2016) :: 2006 F250 - Trailer Wire Harness Bracket - Connectors Hanging Loose
I have a 2006 F250 and my 7pin and 4 pin connectors are just hanging loose. I'm not sure what happened to the factory bracket. What is the part number for this bracket? Also, where does it mount to? I looked under the truck and couldnt tell where the factory one mounts.
View 4 RepliesGolf IV / Jetta IV :: 2005 - O2 Sensor Wire Disappears Above The Heat Shield
Didn't touch the downpipe during engine swap of my BEW TDI.
After swap, have code:
17524 - Oxygen (Lambda) Sensor Heating; B1 S1
P1116 - 000 - Open Circuit
The O2 sensor wire disappears above the heat shield above the exhaust. I am used to (Audi 1.8T, 2.7T, 2.8) seeing the O2 sensors coming up with plug on firewall.
Where is the O2 sensor wire going to.
I normally by the generic Bosch O2 if the SENSOR is bad (cut and splice), but suspect that maybe the problem (open circuit) is further 'upstream'.
Obviously, I am a TDI (and Golf/transverse engine) newbie, so bear with me.
Golf IV / Jetta IV :: Turn Signal Wire Repair - Necessary To Remove Grill?
Im switching out the bulbs on the front turn signal light today, I reach my fat little fingers in there and can barely pull off the wire harness that goes into the back of it. When I did this the wire coverings on all three wires just disintegrated I would guess from the heat inside the headlight. Wel there's a short from where they are touching and my signals don't work at all. my question is I can hardly even reach my fingers down in there too remove that wiring harness ( which is the shortest wire ive ever seen) is it necessary for me to remove the grill the front bumper and each headlight in order to access the wires better?
View 5 RepliesGolf IV / Jetta IV :: Removing Mk4 GTi Sunroof Cover?
So I want to remove a sunroof cover from a GTi that's being parted out but the problems are there is no power in the car. I know that you need to be able to tilt the sunroof up in order to remove the cover. So, is there any way to do this without power?
View 6 RepliesGolf IV / Jetta IV :: 2004 - Sunroof Won't Open
2004 GLI ... Venting opens but when I turn the knob to open the sunroof completely, I can hear and see that it wants to open but it stays neutral and wont open up. I attempted the manual crank. Again, I can get it to vent manually, but when I turn the allan key the other way to fully open the roof, it will go as far as moving just below the roof line, but it will not continue to open. I'm concerned if I crank on it too hard, something will break.
View 2 RepliesGolf IV / Jetta IV :: Sunroof Would Open But Not Closing
Trouble shooting my sunroof. When I first go the car the sunroof would open but not close, even when I pushed in the button to reset.
I have replace/ and calibrated replace the switch now I get the fallowing.
When I put it to open all the way, it goes in to vent mode ( the back opens up), ( when i put it close it closes fine).
When i put in vent the sunroof slide back 1/4 of the way. when I try to close it closes and opens back to 1/4 open. I have to close it and press the button in to close it.
Golf IV / Jetta IV :: Car Came With No Sunroof But Seals Started Leaking
So I bought my 03 golf 2.slow about 10 years ago used and it came with a moonroof... not a sunroof. I never really thought about it and just assumed it was a option from the factory but the seals have been leaking lately and I was looking for a replacement seal and could not find anything only sunroof parts. Is this an aftermarket moonroof where they cut a hole in the roof and added this?..I really hope not. Or did someone take the sunroof assembly out and put this in its place.
View 3 RepliesGolf IV / Jetta IV :: Sunroof Rattle When Closed While Going Over Bumps?
Have a sunroof that rattles when closed while going over bumps? I use my fingers to lift up on it and its barely budging, also floors are soaked....
View 3 Replies