Ford - Explorer :: 2001 - Oxygen Sensor Wire Harness?
I have a 2001 ford explorer sport and realized that the oxygen sensor on the passenger side behind the cat was unplugged from the harness.
I am unable to find the harness and dont know where its supposed to go.
I would like to get this fixed right away but can not find a diagram anywhere, or a manual...
Ford Super Duty (1999-2016) :: Running Lights Limit On Trailer Wire Harness
Any limited number of lights the factory trailer harness on the truck can tolerate? I'm looking to add some extra running lights on my trailer, also want to put a couple of lights on each running board on the truck, they will be tied in with the trailer harness since it is not monitored by the BCM. I did a search on this a few different ways and couldn't find anything.
View 8 RepliesFord 6.7L Power Stroke Diesel :: Tail Lights Go Out / Wire Harness In Front Left Wheel Well Rubbed
My fathers truck had the tail lights go out the other night so we checked the fuse and the bulbs both good. Took it to ford and they found that a wire harness in the front left wheel well had rubbed through and needed replacement. I went and checked mine and yup it was rubbing through the wire just not all the way yet. Might want to take a look. It is at the top of the well near the coil spring. I will get the camera out tomorrow in the daylight and take a picture of the location.
View 13 RepliesGolf IV / Jetta IV :: 2002 - Wire Harness Missing In Sunroof
I own a 2002 GTI and my sunroof was damaged beyond repair.
A local headliner shop had a used 2004 Jetta sunroof which he sold to me. The shop owner said everything was in working order with the sunroof except the wire harness that runs to the sunroof was missing the plug since it was cut. He recommended just taking the plug from my GTI sunroof motor and soldering it onto the Jetta motor since it may throw off the "timing" of the sunroof motor and would need to be recalibrated if removed. Keep in mind he is an authorized Webasco dealer so I took him at his word.
I cut my plug off of my GTI sunroof motor harness and began to solder it onto the Jetta sunroof.
I quickly noticed the Jetta sunroof motor had one extra wire (Brown). I didn't think it would be a big deal since my GTI doesn't have 6 wires and only requires 5 so I mounted the new sunroof with the Jetta motor onto the car.
The sunroof retracted back into the "fully open" position and would close but would not go into the "vent" position. Each time I would turn the dial to the "vent" position, the sunroof would slide back into the "fully open" position.
I thought this was a bit strange and now I am beginning to wonder if I need to swap the GTI sunroof motor on my car due to it not have the extra wire or is the Jetta sunroof motor going to work fine but another issue is causing this to happen?
Below are the differences in the two sunroof motors. Both are Bosch products.
Jetta Sunroof Motor - Part Number : GDO 849 696 564
This part has 6 wires that connect to it.
White, Green, Gray, Blue, Purple, and Brown
Where as the GTI has only 5 wires on it.
GTI Sunroof Motor - Part Number : GDO 849 696 566
White, Green, Gray, Blue, and Purple
The difference between the two is the additional BROWN found in the Jetta sunroof motor.
Ford - Explorer :: 2002 - Intermittent Rear Brake Lights
We have a 02 Sport Trac that has intermittent brake light problem. All other functions for the bulb filament for the brake lights work! Turn signal and flashers work great. The brake light that is above the rear window works, BUT the brake lights on the rear of the Sport Trac work when they what to.
Right now I can not find a cause that causes them to not work or to work. This morning they worked in the garage but did not work as my wife pulled out of the driveway. Last night they did not work on part of the way home but worked coming into the drive way.
Ford 7.3L Power Stroke (1999-2003) :: Green Wire Located Above The Fuel Filter Assembly Knocked Loose?
I'm in the process of replacing my HPOP lines and fittings and after I got everything removed and started cleaning the threads before re-assembly I noticed this green wire (located above the fuel filter assembly) that apparently I pulled out of its socket.
What is it for? Can I just push it back in its sleeve right below the red wire??
Ford 7.3L Power Stroke (1999-2003) :: Stripped Wire Harness Connector Bolt?
As part of my ongoing P1393 troubleshooting, I’ve found that I can’t get the main engine wire harness separated. The big connector by the driver’s side valve cover.
I’ve cranked and cranked in the correct direction, but the plug never separates. I tried a cordless impact wrench and it still doesn’t move. (Edit -- the bolt moves very freely, but it doesn't push out one side (e.g. like removing the PCM) I can't figure out how to separate the two sides.)
Any tips on how to get it separated? Can I cut off the bolt head to get it separated?
Ford 7.3L Power Stroke (1999-2003) :: 2001 - Injector Engine Wire Harness
I'm trying to find a part number for the wiring harness that sits on top of the motor and plugs into the valve cover gaskets. The previous owner replaced the pigtails but the wires were cut so far back that there is virtually nothing left coming out of the harness. What the actual harness looks like other than it has the 9 pin plug on it or whether both sides require an individual harness. What is the part number or picture of said harness. Just in case.... it's a 2001 7.3.
View 14 RepliesFord Super Duty (1999-2016) :: 2007 - Mirror Swap - Wire Harness?
I have a 2007 F-350 SRW. I bought some mirrors of craigslist from two different sellers. They are from 2008 or later, they didn't know the exact year. I have looked in the tech folder and searched and searched. could not find wires that are the same color as mine. Yes, mirrors are OEM. I need to know what color goes to what color.
Do they match color to color? question mark represents color that doesn't line up
drivers side door colors=============== new drivers side mirror colors
green------------------------------------------------- green
black--------------------------------------------------black
green/white-------------------------------------------black/white?
blue----------------------------------------------------blue
yellow--------------------------------------------------yellow
red------------------------------------------------------red
brown---------------------------------------------------brown
passenger door colors=================new passenger mirror colors
green/purple------------------------------------------white?
black---------------------------------------------------black
white/blue---------------------------------------------black/white?
yellow--------------------------------------------------yellow
green---------------------------------------------------green
brown---------------------------------------------------brown
brown/purple-------------------------------------------purple?
Side note these are in no particular order as far as pin location.
Camry :: Broken Wire Harness Spark Plugs
Two of my plugs locking clips broke today on the wire harness side where the coil over plugs into the harness today while changing spark plugs. They will plug back up, but they won't lock together like they are suppose to. How critical is this? It is my wife's car will she break down? I drove the car maybe twelve miles, and everything seemed fine.
View 8 RepliesFord Super Duty (1999-2016) :: 2006 F250 - Trailer Wire Harness Bracket - Connectors Hanging Loose
I have a 2006 F250 and my 7pin and 4 pin connectors are just hanging loose. I'm not sure what happened to the factory bracket. What is the part number for this bracket? Also, where does it mount to? I looked under the truck and couldnt tell where the factory one mounts.
View 4 RepliesFord Super Duty (1999-2016) :: 2003 F350 - Wire Color For Reverse Lights At Rear Bumper
Installing a back up camera and need to locate reverse lights on driver's side at rear bumper. What color wire is for the reverse lights on a 2003 F-350 (truck in my sig)?
View 4 RepliesPassat - Volkswagen :: 2002 - Rear Spark Plug Wire Pops Off?
The rear spark plug boot, the kind that goes down into the center of the engine, pops up about a quarter inch every so often. I have switched the boots and cleaned the walls of the plug area and it pops up on the rear cylinder only. This is a 2002 Passat 4 cylinder Turbo with 163,000 miles on it.
View 2 RepliesFord - Explorer :: How To Access Wiring Bundle Connecting Door And Car Body
I've had a problem with non-operational power windows on my 03 Explorer and in fiddling around I've found that there is something up with the wiring bundle between the drivers door and the car body. If I wiggle the bundle of wires I can get the windows operational again temporarily so there is some sort of short happening.
I'm not sure of the best way to access the wiring bundle though - they're surrounded in a rubber casing and the only way I can see to get access would be to cut the rubber casing to either open up a section or completely remove it. Trying to pull the casing back from either end just doesn't give enough access to the wires.
Is that my only option - cut the rubber casing?
Ford A/C :: 1994 Explorer - Compressor Leaking Green Fluid (Antifreeze)
I had a small leak in my 94 Explorer which was getting on the compressor pulley and being splattered around the engine compartment. The fluid was green like antifreeze--which didn't make sense; why would antifreeze be leaking from the air con compressor? But as an experiment, I got a non-AC belt and ran the truck without the compressor pulley turning, and the leak has stopped! The level in the coolant overflow tank has dropped an inch or two in the last 500 or so miles. Is it possible that antifreeze is getting into the air con system somehow, like through an internal leak in the heater core?
View 10 RepliesFord - Explorer :: 2002 - 4x4 Lights Not Coming On
The 4x4 lights do not come on. I have check all fuses. I have replaced my module still nothing. I guess I could try another module but dam I am really at a dead end before I have to take it to Ford dealer and get hosed.
View 2 RepliesFord - Explorer :: 2002 - Low Beam Lights Does Not Shut Off
2002 Ford Explorer Sport .. Just started last evening when I returned home .. Closing lights low beam ( yellow & rear tail light ) did not shut .. Bell sounding .. Not dealing with it last night disconnected ground cable off battery ..
This morning took a look .. Connected ground cable too battery. Expecting low beam lights too go on. Did not .
Turning lights on & off. Head lights work fine. yellow and rear stay lit ..
Disconnected battery, OFF .. Reconnected battery cable yellow light stays off until I turn on head lights, and will not shut off from switch .. Thinking light switch ?
Could a burned out fuse in another fuse cavity cause this effect? How can I test ??
Ford - Explorer :: 2002 - Rear Wiper Won't Working?
NO RESPONCE TO REr wiprt control ?
View 6 RepliesFord - Explorer :: 2002 - ABS Light On After Changing Rear?
I have a 2002 Explorer that had a whining rear, changed it out with a good rear out of my parts truck and now I have an ABS light on. It says something about input to the sensor and output from the sensor and left and right wheels. 4 Codes in all. I changed the speed sensor in the top of the rear to the one that was in this truck because the light wasn't on before and it still has this light.
View 1 Replies