Golf IV / Jetta IV :: 2002 1.8T - Shifting Out Of Time / Revs When Changing Gears

Got a 02 Jetta 1.8T 5spd auto tiptronic with 100k miles. Having issues with shifting. Trying to determine if its electronic or mechanical. Had a short in solenoid 10 N283 which melted the TCM. Put in a used N283 to see if the trans is still ok mechanically. Plan is if its ok to put new fluids and solenoid pack. What do the experts think does is need a full rebuild or will new electronics do the job?

After putting the used N283 solenoid the trans works but not correct. The problem is in the shifting only. Feels like its out of time. When you start moving from a stopped position from 1st to 2nd the car takes off good but when changing gears it reves and feels like its slipping then it hits hard into 2nd. Then 2nd-3rd is a fast shift and not hard. 3rd-4th slips and revs a little then changes gears 4th-5th is fine. all down shifts are fine. Does not mater if the car is hot or cold its the same.

If I disconnect the MAF 1st to 2nd shifts fine with no problems. 2nd-3rd little rough but not bad. Problem with disconnected MAF when going in Drive at 30-40mph all of a sudden it jumped into 1st gear and felt like I was slamming on the brakes.

With the MAF connected and I shift manually in tiptronic mode each gear runs real good with no slipping at all. But same problem happens when switching gears. I can drive it smooth if i accelerate to 3000 rpm and then left off the gas a little and it shifts fine.. Same with the other gears.

I got a used TCM to rule that out and the problem is close to the same. It tries to shift at lower rpm but still does about the same problem. I did recently had a MAF go out. Put in a new bosch and no change. Did my VCDS scan and only codes I get is "17840 secondary air". I can get operational data on some solenoids but not sure what parameters to look for.

View 2 Replies

Passat (B5) :: 2002 VW Revs Then Shifts Into Gear

So I sea foamed the passat vac/intake 2 days ago and car drove fine then did oil change 1 day ago 5/30 all I had with additive resline. Since then car revs then shifts into gear or stays in wrong gear until I rev the car. Never had problem shifting until now. Low oil pressure or electrical issue from sea foam vacuum leak.

2002 VW Passat 2.8 AWD

View 1 Replies

Golf IV / Jetta IV :: 2002 02M GTI Won't Move In Any Gear

So today I was driving my car and everything was fine. I get to a freeway off ramp. I put it in first and it goes like normal I shift from first to second and then into third when i shifted into third, I hear a grind sound like I miss shifted or something. I continue on and when I get to a red light I go to take off in first and nothing...The car wont move!! I have the clutch all the way out and its in gear and nothing... I can have the car running and the clutch out and i can shift it in any gear and nothing happens. I have a spec stage one and an 8lbs smf in the car and before i could hear clutch chatter and now when i have the clutch out I don't hear anything? What is causing this?

View 3 Replies

Golf IV / Jetta IV :: 2002 1.8t - Tiptronic Won't Go Into Any Gear

So last night I bought a rather nice low mileage tiptronic jetta for a good price that supposedly needs a new transmission (girl was quoted $5k to fix at a shop). The car starts right up and moves under it's own power...for about 2 minutes. I haven't actually driven the car but moved it forward and reverse a few times in the parking lot last night. Got out to look at something and when I got back in there was zero response from the tranny, any gear. Engine just revs. Seems a bit different than the usual slipping in gear or violent shifts these trannys are known for.

View 4 Replies

Golf IV / Jetta IV :: 2002 VW GL - Hard To Go Into 1st Gear And Reverse

Drove my 02 VW golf GL to the airport, it sat there for 4 days, drove it back home. Next day I noticed that my 1st gear and reverse are very hard to get into. So I kept messing around with it and noticed that if I tried to put it slowly into first gear that there was no way in hell it would go, it felt like the gear was closed.

But if I put it into second gear and push it from second gear into first gear it goes back into first gear about 70% of the time. And it will also go into first gear if I push my stick down as if I'm attempting to go into reverse, and slowly move it into 1st gear.

The reverse is also very hard to get into it feels just like the 1st gear does when you try to do it slowly, it's like it's closed off/blocked. Latest work that was done to the car, replaced the clutch about 4-5 months ago.

View 2 Replies

Golf IV / Jetta IV :: 2002 - Acceleration Loss In 5th Gear Around 35 - 45 Mph

I have a 2002 VW jetta 1.8t recently I've noticed that in 5th gear around 35-45 mph its losing acceleration. its a tiptronic so i can just downshift speed up a bit an o to 5th, however I don't want that to be the permanent fix, what this is or why its doing it?

View 1 Replies

Golf IV / Jetta IV :: 2002 - Died / Won't Start - Hesitate In 1st And 2nd Gear?

I have an '02 GTI VR6. It died on me on the freeway after surging then limping to a stop and wouldn't restart. I replaced my fuel pump 5 months ago and now I suspect that it has died again, but I want to be absolutely sure that the pump is the problem before I replace it again.

Last time the car would sometimes hesitate in 1st and 2nd for a couple weeks before the pump actually went bad. This time it seemed fine for 5 months then just went out.

The pump does not prime when I open the door. I checked fuse #28 and it's not blown, but there doesn't seem to be any power to it. I tested the power to the fuel pump connector. When I turn the key on I get ~12v for a split second then nothing. While cranking the engine I get ~9v constantly. I hooked a square 9v battery straight to the two outside connectors on the pump and nothing happened.

Can I be sure that the pump is the only problem? Obviously it's dead, but is there any reason for fuse 28 to not be getting power? And should the connector only be getting power for a split second when the ignition is turned on? I tried a different fuel pump relay with no change.

View 2 Replies

Ford F-150 - 1997-2003 :: 2002 - Revs Then Goes In Gear But Reverse Is Fine

So my aunt has a 2002 ford f150 king ranch 5.4l and a night ago it started this problem which when you put it in drive which she has to put it in 2nd for it when she pushs on the pedal it will rev up to 2500rpms than jerks and goes and its usely fine till she stops than goes and it does it again...

Than today it wouldn't even go in anything but reverse... So than we herd about the Range Sensor on the side of the transmission and it seems like it was it so I unplug it when it was running and when i push on the pedal and it revs up to 2500rpms it will go forward and have power. So we went to get a new range sensor after like 4 hours trying to get the dam thing off and another 2 to get it back on.. I started it up and only reverse works again... So I unplug the harness to it again and we got the gears but 1st and 2nd will just rev and go.

We at a lost right now i even tighten the shift screws under the dash cause our expedition was loose at one time and the gear shifter was loose like hers. But even tighten the bolts it still don't fix the looseness or even the gears.. Is this a transmission problem? OR even the torq covertor?

View 4 Replies

Golf IV / Jetta IV :: 2002 GTI Front End Creaking When Accelerate In Second Gear Right After Shifting

I purchased a 2002 gti in Febuary with 161k miles. I believe it was a couple weeks after I bought it - it started making this creaking sound. At first it was more rare to hear it but it occurred going on uneven surfaces like up a steep hill or around an uneven turn or even stopping and going. It basically happened when the front end pitched up/down. It sounds almost like a rubber creaking or even plastic. (Some sort of bushing maybe? I'm no expert) Now it is rare for it not to make the creaking when taking off or slowing to a stop. It only occurs at lower speeds like right when taking off or at the very end of the stop right before the actual stop.

It will even slightly make the noise when accelerating in second gear right after shifting. (This is occasional) When I come to a complete stop and turn the wheel side to side ot will make the sound for a couple of turns and then go away. I have tried rocking the car and pushing down on it to replicate the sound. No luck. I lubricated various bushings and parts with silicon. It seemed to fix it but it only lasted for a few hours. (This could've been coincidental) It doesn't make the sound 100% of the time though. Probably at least 90% though when coming to a stop and going. It seems as the environmental factors (Temp and humidity) have a small effect on the creaking. I have a neuspeed 25mm front swaybar with endlinks.

View 2 Replies

Golf VI R :: Sometimes Revs Stay After Disengaging First Gear?

Purchased my '12 R a week ago. It's got 40k on it. I noticed that sometimes after disengaging from first gear, the revs climb and hang around 1500 for around a couple of seconds.

View 7 Replies

BMW :: 1990 - AT Cannot Leave 1st Gear Or All Forward Clutches

My car is 1990 BMW E34 M20B20 that uses 4HP22 transmission and here is the problem:

When I put it from P into R it makes a sound like a hitting and doesn't move but you can understand it is on load, because when I step on the gas, engine cannot outrun 2000 rpm (even at trying to rev).

When I shift into N, it starts to move forward and it's drivable but not an engaged drive, and while traveling or not, when I shift from N into D, it retrieves the engaged drive and goes normal.

I think it cannot leave 1st gear or all forward clutches. What the problem could be?

View 7 Replies

Golf VI R :: Revs Slow To Drop When Changing Gear

I just picked up my new R (Rising Blue 2 Door w/ S-Roof & Nav) yesterday and love it, except for one thing. When accelerating and changing up through the gears, the revs seem very slow to drop after lifting off the gas and dipping the clutch to select the next gear. It is like there is a delay between me lifting off and the instruction getting to the engine.

View 6 Replies

Golf V R32 :: Revs For About Three Seconds Then Catches A Gear In D And S Mode

Sometimes while cruising at moderate to highway speed I'll go full throttle (to pass, merge, etc.), but the car just revs for about three seconds then catches a gear. It has happened in D and S mode. I've taken it in to the dealer and they checked for any codes, but there weren't any.

View 21 Replies

Golf IV / Jetta IV :: 2003 VW Won't Move / Just Revs

I have a 2003 Jetta Gli with a VR6 manual transmission 6 speed. So the other night I am pulling into this store parking lot and all of a sudden my car is just rolling its still in gear and running but when i push on the gas it just revs the motor i thought i was in neutral for a second but I wasn't so I jump out and push it into a parking spot.

Car is running but when i put it into gear and let off the clutch it just revs. so i have i towed to my house it was late so i decided to look in the morning.

So I go out the next day its still the same only now when i let off the clutch it just dies. I'm not an auto mechanic expert by any means any car work i have done is just self taught as needed diving in and figuring it out myself.

I did do the Cv axle on the passenger side last year i bought the one from O' Reilly auto parts. I know its the cheap one and probably a no no. Could this be my cv axle? Did my clutch go out? It moves through all the gears except reverse when the clutch is depressed. Could it be my transmission?

View 2 Replies

Golf IV / Jetta IV :: When Turn On The Car It Just Revs / Accelerates On Its Own

So for the last few days, every now and then when I turn on the car it just revs/accelerates on its own. The rpms will be at about 2k and stay that way whether I'm in neutral or in gear. Then when I go to turn the car off and back on it again it doesn't start. It'll sound like it wants to turn but it doesn't until I let it rest for a few minutes and then it's back to normal.

View 7 Replies

Golf IV / Jetta IV :: 2005 GTI 1.8T Engine Revs Too High?

I have a 2005 GTI 1.8T with 203K miles, stock except for a MagnaFlow exhaust. My problem arose about a month ago. When I accelerate aggressively and shift from 4th gear to fifth at about 4K RPMs the engine will jump up to 5K RPMs. Happens while shifting from any gear when accelerating hard.

When I push down on the clutch and take my foot off the gas, I get a jump in RPMs. It's kind of like the boost in the turbo is not getting released. I replaced the stock diverter valve with a Forge DV with the splitter. Had no effect on my problem, but now I have that cool sound when I get off the gas.

Could this be the waste gate on the turbo not opening and releasing the boost when I get off the gas? I'm not very familiar with the intricacies of the Turbo functions and the diverter valve.

View 7 Replies

Golf IV / Jetta IV :: Buzzing Noise Gets Louder With Higher Revs

I am experiencing a weird noise coming from my 1.8T AWP engine. Its kind of a buzzing, and it gets louder with higher revs. Unfortunately its hard to hear while driving as I have an exhaust on it, but in a confined space you can hear it clearly.

View 4 Replies

Golf IV / Jetta IV :: Revs Just Drop Down To 0 And Engine Shuts Down While Slowing Down

Looking for some hint regarding V6 AUE ? Regardless if engine is warm or cold, sometimes happens to me that during driving, while slowing down and pressing on clutch pedal, revs just drop down to 0 and engine shuts down (vehicle still moving). This usually happens while changing gears from 3rd to 2nd on low speeds in city, or while slowing down to full stop in 2nd gear and pressing clutch pedal.

While this happens, I quickly switch off the ignition and start the engine again, which is tricky and potentially dangerous, since vehicle is still moving but my power steering and brakes are not functioning because of stopped engine.

Some relevant info...I have K&N cone air filter intake and ECU is remapped by BTS Racing (German tuning house).

Car is running and pulling normally. In all other regimes of driving, there are no issues or whatsoever.

View 2 Replies