Golf IV / Jetta IV :: 2001 - Exhaust Rattling / Catalytic Converter
My exhaust on my 01 was rattling. It was coming from the catalytic converter, I assumed it was the heat shield. Put it up on the lift and lo and behold it was something in the cat that was rattling. I was popping a code for the cat anyways so figured I'd just swap it out. Fast forward to tonight. I get the car back up on the lift and I wiggle the cat but no rattling? I go farther back to the first muffler/resonator now it's rattling. It's not a hanger or a heat shield or metal to metal on the outside, there is obviously something of substantial mass inside of it I can almost feel where it is by wiggling around. I chose to wait and cut the exhaust up a different night because I plan on taking that section out as well now, hoping to get out whatever is rattling. If not I'll just have some spare pipe on hand to replace it.
View 6 RepliesPrius (2001-03) :: Loud Noise Coming From Exhaust System / Catalytic Converter Replacement
After hearing some loud noise coming from my exhaust system, it was determined that there is a hole (from rust) in part of the cat. assembly. Three shops advised for replacement, there are no aftermarket products for this unit. I have NOT gotten any error codes, the only problem is the noise. What to do? The car is 10 years old with 86000 miles. I have been reading about some of you getting just the one piece and having it welded on, but I do not believe any of the shops here will do that, and indicated that it would be a very temporary fix.
View 17 RepliesGolf IV / Jetta IV :: CEL Came On, Car Needs A New Catalytic Converter
I have a 2001 VT GTI with 155K miles on it. It is in very good condition. I have loved the car except for the high maintenance costs that typically seem to be associated with VWs.
I found out this week after my check engine light came on that the car needs a new catalytic converter and a new new secondary air pump.
Let's assume that this diagnosis is correct and the repair is accurate for the sake of this posting (and I have no doubt it is). In other words, I don't want to get my question derailed on that issue.
The car has new Michelin tires on it and runs well. The problem is that it will fail the state emissions test I am required to take next December, and I will either be forced to have the car repaired or will not be able to get updated license tabs (isn't that sweet?!).
It seems that I have a few options:
1. Get the repair done (ouch) and keep driving the car for a few more years. Repair cost is about what the market value of the car is (from what I have seen).
2. Sell the car "as-is" between now and December and see what cash I can get out of it. Any buyer will discount the value of the vehicle based on the repairs needed. Of course, then I'll need a replacement vehicle of some sort.
Mazda - Mpv :: 2000 - Won't Running After Catalytic Converter Replacement
My husband,who is an engineer and has done all of our car maintenance for decades is stumped by our 2000 Mazda MPV. He replaced the catalytic converter and put every thing back together, but the car won't run. Will start, but dies right away. Took off new cat,and runs with that off, but not sure why it won't run with the cat on.
View 4 RepliesKia - Sephia :: Stalling Out And Running Very Rough - Catalytic Converter Replacement?
I was told that my 1997 kia Sephia needed a new catalytic converter by a very reliable shop. My car had been stalling out and running very rough. They did replace the distributor cap which seems to have increase the overall performance and that same day i had a smog check and passed with flying colors! Why would I still need to replace my converter if I passed smog. My car has only 36k on it.
View 19 RepliesToyota - Prius :: Check Engine Light Has Been Coming On - Catalytic Converter Need Replacement
My wife's car is a 2002 Prius, 149 k miles. Lately the check engine light has been coming on. I took it to the dealership, and their assessment is that the catalytic converter needs to be replaced. They are recommending about $2,000 + of repairs. While I am contemplating the practicality of investing that much in keeping this car going I'm wondering if it harmful or dangerous to continue operating this vehicle.
View 12 RepliesToyota - Repair - Corolla :: Loudest Rumbling Exhaust Sound / Catalytic Converter Replacement?
Yesterday my 1995 Toyota Corolla (which runs well otherwise) started making the loudest rumbling exhaust sound I've ever heard whenever I stepped on the gas pedal. It also felt like it had trouble accelerating when I would try to get going after a stop. I took it to a mechanic right away, who says it needs a new catalytic converter and resonator pipe.
My boyfriend says this is a repair he could do. He has done some car repair and worked with a mechanic before, so I am considering trusting him on that, but I don't know what types of repairs he's done before and I know he has never worked on this model. What would you take into consideration whether or not it would be safe to attempt this repair at home?
Jetta :: Change Catalytic Converter After 12,000 Miles?
My car had its check engine light come on a few days ago, and the engine started to get extremely loud whenever I was accelerating. I would also smell gas whenever I would start the car. I decided to take it to a mechanic, who did a diagnostic check and told me that my catalytic converter was busted. This troubled me because I had just had the part replaced a little over two years ago. I figured the part would still be under warranty, but the mechanic that I had used to replace the cat told me that it was only under warranty for one year or 12,000 miles, according to the distributor. Well, I got a hold of the distributor, and he told me that he didn't have the information for the specific part that he used (he just told me that he "figured" it would be one year or 12,000 miles because most of the parts that they receive have warranties of that length....). Shops are closed now for the weekend, and I am getting worried about my bank account here...should I be?
Well, my questions for you all are as follows:1) Have you all ever heard of a catalytic converter ever having only a 1 year or 12,000-mile warranty? My current mechanic tells me he has never heard of one being so short, and that usually they are 5 years or 50,000 miles. I did minimal research on the internet and also found similar results.2) Who do I need to get into contact with in order to find out how long the warranty is, and how I redeem the warranty?
Subaru - Forester :: 2001 - Smoking From Catalytic Converter Area
I'm getting smoke from the catalytic converter area on my 2001 Subaru Forester. The smoke smells of rubber or oil. I've only noticed it after the car has been driven up a long, steep incline of at least a couple of miles. I've never seen it happen after normal highway driving. The car runs fine, gas mileage is good, CE light is not on, 85K miles, regularly serviced.
View 2 RepliesNissan - Sentra :: 2001 - Burning Plastic Smell From Catalytic Converter
Where do I start. I have a 2001 Nissan Sentra. 128,000 miles. In Aug. of last year, the engine detonated, so I had it replaced along with other parts. Shortly after that, I noticed a burning plastic smell coming from the car after driving it for a while. I confirmed that that the smell wasn't coming from a plastic bag. Fast forward to Dec 2011, my check engine light comes on. I go to Autozone, have the code read; it's the dreaded 420 code. I go to have it checked out, was told my cat went bad and probably because of the old engine and that the smell is probably coming from that.
The check engine light went off on Christmas day. Fast forward to last month, the light comes on again and I pony up the cash to have the cat replaced since inspection is coming up in June. Now, I had an engine diagnostic run right before I got the cat replaced and it came up fine. The cat was replaced on 4/20. Everything seemed fine. The burning plastic smell went a way, but lo and behold, it came back this week. I don't know what to do. I did a little search on the net and it seems that burning plastic smell indicates there is something going on with engine and possible misfire.
Golf IV R32 :: How To Make Catalytic Converter Ready
Took my car in for emissions and says catalytic converter is not ready.
What can I do to make this go to "ready"?
I've recently got my computer flashed with new programming.
Since it's been flashed, I've driven the car over 400 miles.
All of the cars self checks should be complete, I can't figure out why the catalytic converter won't go to ready!
Any thoughts or tricks to make it work?
Golf IV R32 :: Catalytic Converter - Heat Shield Rattle
The catalytic converter shield is tack welded on the front end but free on the rear end. There was originally some braided wire packing at the rear to keep the shield from rattling against the pipes. Mine was deteriorated and had been damaged, I think, when I sustained some oil pan damage last summer -- big jolt to the system when running over a muffler on the highway.
The fix is simple. Bought a foot of 3/16" braided stainless steel cable. I used about 8 inches and layed in the lower bead line on the catalytic converter shield (see picture below). You can see a bit of the cable thru the gap in the upper/lower shield on the left side. (1/4" cable would be a better fit, but this will work for a long time.) Cost: $1.84
The local VW parts man dug out an exploded drawing of the system but it showed NO parts or packing for this problem.
Golf V R32 :: Rattle Coming From Underneath The Car - Catalytic Converter?
I have this rattle coming from underneath the car that's been going on for a while.
The car has 110k miles and the rattle is most prominent when I start the car or accelerate hard or just cruising downhill without gas.
I went to one of the well known shops in the area and they said it's coming from the cat and it needs to be replace and quoted me like $1300 for parts and labor which seemed quite steep to me.
They said it's coming from the inside the cat so it needs to be replaced.
Is this a common issue with our cars? I though maybe something is loose and can be just welded together or something.
Golf VI R :: 2009 TDI - P0420 Catalytic Converter Code
Does this mean the DPF is shot? I believe its integral with the cat. whats worth checking first?
View 2 RepliesGolf V R32 :: Check Engine Light On For Catalytic Converter
105,000 miles on my R32, starting to get check engine light for catalytic converter. Any cheaper options to VW originals that won't harm performance?
View 1 RepliesGolf/GTI VI :: Code P0420 / Hesitation At WOT - Fried Catalytic Converter?
Title says it. Cat is done. Threw code p0420 and am experiencing hesitation at WOT. Already replaced my front o2 (cbfa) and now I'm debating whether or not to get a new downpipe. I daily the car and am wondering if keeping the car as is for a while will damage anything. Cts turbo has a sale for a catless downpipe.
View 5 RepliesGolf IV / Jetta IV :: Other Model Year Keys Work With The Alarm And Immobilizer?
My one original switchblade is long gone and the other no longer works. It starts the car of course but none of the functions work, battery change did nothing.
Question: Do any other model year keys work with the alarm and immobilizer?
Golf IV R32 :: Exhaust System - Clamp Connecting Resonator And Catalytic Converter Leaking Around The Edges
The clamp connecting the resonator and the catalytic converter is leaking around the edges. I changed the bolts and tightened the clamp but still leaking.
View 24 RepliesGolf IV / Jetta IV :: 2001 VR6 - Power Steering Rack Replacement
I need to replace the power steering rack on my car. Mech wants 300+parts. I supply the parts. Is there a different rack for the vr6 VS the I4 jetta?
View 1 Replies