Golf IV / Jetta IV :: Losing Power And Boost At 4k RPMs After Tuning
I have a 2002 gti with an apt software tune. Whenever I'm on the interstate in 5th gear for a while. And I'll start to speed up. Once 4k kicks in. My boost no longer works when it normally pushes like 22psi. Then after slowing down. No matter what gear I'm in. It limits back to 10psi of boost and once I hit 4k. It goes super slow and boost won't work. I'm not sure what else I should get to restore my car to perform fully.
I'm currently on the factory ko3 turbo and the previous owner had nitrous hookups and lines to the motor.
I'm already 3k into fixing it. Needed new shift cables and a fresh transmission
I'm hoping to push about 250hp maybe 300hp
The boost problem is fixed once I turn the car off and back on. I just want it to work again without having to spend an arm and leg on parts and labor. My mechanic works at Volkswagen dealership. But isn't allowed to work on my car due to dealership policies about working on vehicles older than 10 years old. The guy who tuned my car professionally at an apr shop told me that I should get a smoke test done (idk where or how to do that) for my vacuum lines and that I have a cylinder 4 misfire. It may be a bad coil or spark plug. But I'd like to get some performance out of my car and I don't know what else or where to start.
Golf IV / Jetta IV :: Losing Power And Boost At 4k RPMs After Tune
I have a 2002 gti with an apt software tune...
Whenever I'm on the interstate in 5th gear for a while. And I'll start to speed up. Once 4k kicks in. My boost no longer works when it normally pushes like 22psi
Then after slowing down. No matter what gear I'm in. It limits back to 10psi of boost and once I hit 4k. It goes super slowe and boost won't work
The guy told me that I should get a smoke test done (idk where or how to do that)for my vacuum lines and that I have a cylinder 4 misfire. It may be a bad coil or spark plug. But I'd like to get some performance out of my car and I don't know what else or where to start. I am new to this.
Golf IV / Jetta IV :: Losing Boost / Power At High RPMs In High Gear
2003 jetta gls 1.8t 5spd - gts stage 1 tune(gonzo stage 2)
tt 2-1/2" downpipe with high flow cat
turbo smart splitter valve(set to divert only)
turbo inlet pipe
homemade intake with k&n filter
stock n75 valve (f)
So in first through 3rd gear my car gets 20psi of boost then at 3,500 ish rpm smoothly starts to lower down to 15psi. but in forth and 5th gear the boost drops faster, enough so the diverter valve actually opens. then the boost will bounce up and down, around 15psi. the car still accelerates but with obvious power loss.
Is my diverter valve not "firm" enough? it is adjustable, so I've tightened it as much as it can. it doesn't seem to change anything. it came with spring spacers to make it tighter, but I haven't tried that yet.
Is it something with the tune? not enough fuel, need bigger injectors? The problem is only at about 100mph, so its not a big deal. I would like to get it straightened out if possible.
Volvo - Xc90 :: Electronics And Navigation - How To Boost Weak Radio Reception
Does the XC90 have a very weak radio reception? Some of the FM stations that were normally very strong in my other cars were weak at the XC90, and some of the AM stations that were normally okay got no signal at all at the XC90. Is there anything I can do to boose the radio reception?
View 19 RepliesGolf/GTI VI :: Losing A Little Boost At Higher RPMs
I have been looking around for some boost information. I have come across a few threads that have boost graphs, but the images are no longer available. I have tried to get a hold of some of the posters, but no luck.
I only recently hooked up a boost gauge and have been monitoring my boost more. I had a slight feeling before I hooked it up that I was losing a little boost at higher rpms. Between 4500-5000 my boost drops from 18 to 15 and then from 5000-6000 it drops to about 10. I know it's sometimes normal for boost to drop at top end, but I'm not quite certain it's supposed to be that much.
I installed the Spulen Boost Pipe Kit hoping it may make some type of difference, but it's the same. What it might be? I have checked all my pipes as best as possible, but couldn't find anything.
Golf IV / Jetta IV :: Stalling In High Gears But It First Start Doing This When Hit Boost (3000 RPMs)
I have a golf mk4 1.8T AGU, about one week after i had my k04-023 turbo on and all the Stuff that comes along it started "stall" (don't know if its the right word??) in the High gears, most 5th gear but it first start doing it when i hit boost (3000rpm)
I runs on Stock n75 valve.. I though i could be a boost problem, maybe the Stock system cant handle it? I did install a boost gauge to see if it was the was the problem, and it dont Seem like it. In first it runs from 1.4 bar and drops to 1.2. Same in second and third. But in 4 and 5th it goes to 1.7 bar and drops to 1.4.. I did wonder it maybe the n75 valve cant handle 1.7 bar??
Ford 7.3L Power Stroke (1999-2003) :: Waste Gate Supposed To Work At High RPMs / Boost?
I understand how the waste gate is supposed to work at high rpms / boost.
I believe that as long as I keep the max boost down, that I can run with the waste gate plugged in order to goose the power a little in the 2000-28000 RPM range. Since the truck is stock and there's no intention of running higher RPMs, it seems like plugging the waste gate is a good idea. I just want to make sure that I'm not missing something.
It appears that the wast gate also opens when at idle and possibly when you let off the throttle. Are these important functions of the waste gate as well?
Here's a chart showing waste gate operation...
Passat (B5) :: Loosing Boost In Higher RPMs?
so there is no visible signs of a boost leak and my boost gauge shows normal vacuum at idle indicating its not a vacuum leak, yet in the higher rpms im loosing boost.
View 22 RepliesPassat (B6) :: Sudden Boost Loss At 4000 RPMs
I just installed a boost gauge and drove the car a little and this is the readings I get. It starts off with 20 inHg and to normal street driving it goes up to 0 and down. However when I pushed it a little, the maximum reading I got was 11-13PSI (High RMP-almost redline). I am a noob in this boost department so Is this readings really accurate or is there something wrong? Recently i had some transmission work done. And since then the gas pedal feels heavier. I was convinced that it is from the new bushings but I feel like this is boost related. Because at 4000 RPM sometimes It suddenly looses the boost (Kick).
View 5 RepliesGolf IV / Jetta IV :: Boost Noise / No Power - Code P1556
I have a 02 Jetta TDI with 186k miles. Couple weeks ago it all of a sudden started making boost noise when I was driving to work and then on the way back I was getting almost no power. Like over boost and under boost issue, so I assumed it was the MAP sensor. I got busy next couple weeks and then tried to start the car but now the car is not starting.
Completely charged the battery so its not the battery. Looked online and it seemed like it could be the 109 relay for the fuel pump. I pulled the back seat off and I can't hear the fuel pump prime up. I got a new relay from auto zone and put it in, still same thing. I don't want to have to replace the fuel pump only to find out its not the fuel pump. I ran the code and I'm getting the P1556 code (charge pressure control negative deviation).
Golf VI R :: Inconsistent Power - Low Fluttering Sound Under Full Boost
Ok here is my question. I've noticed the power on my car has felt inconsistant for the last little while. I finally got around to logging the car and my boost peaks at mid 20's just over 3000 RPM and then drops fast to between 13-15 psi before I even get to 5000 RPM.
Under full boost I hear a low fluttering sound like the diverter valve opening and closing when this is happening. I also don't get the typical diverter valve sound when shifting when the car is doing this.
I took my diverter valve out and inspected it. I can pushing the piston up very easily with almost no resistance, is that normal? I would think that it should be hard to push the piston up if not wouldn't boost pressure be able to overcome the piston and leak past?
My mods are. HPA tune, HPA catted down pipe, and VWR intake.
Tiguan :: Accel Making Tiny Boost Leak Noise At Certain RPMs
I was driving the wifes 12 Tiguan SEL 4mo the other day and noticed that on accel it makes some odd noise, almost a tinny boost leak noise, it seems to accel just fine but at certain rpm's it makes this weird noise, its not a normal turbo boost noise i hear that as well. Maybe this noise is completely normal or maybe it isn't?
View 10 RepliesGolf/GTI VI :: Lack Of Power - Misfiring - Boost Pipe Blew - Symptoms Of Ruined DV?
So last friday (20th) I got my the APR stage 1 tune put on my car at NGP Aberdeen. On my way out of the shop I started having symptoms that resembled a fouled plug. At the two stop signs I came to my car died.
I turned back to have the fellas at NGP investigate problem. About 20 minutes later the tech that had been problem shooting my issue told me that a boost pipe with a quick connector blew itself off. Something that he had never seen before. I'm on my way home this afternoon and I start getting the same feeling (lack of power and slight bucking/misfiring feeling) I had last week.
It got dark outside before I could take a look, so I'm curious what you all think. Could it be this mysterious boost pipe? If so which one do you think it may be (I already checked the one that goes into the "stage II" pipe, and that one is connected). Also, any thoughts on how to make the quick connector stay with my increased boost? Otherwise, what are the symptoms of a ruined DV?
Current Mods: APR Stg I intake, APR Stg I flash (running 93 oct right now), no other engine mods.
Ford 6.0L Power Stroke Diesel :: 2003 - Weak HPOP / High Pressure Oil Leak?
My 03' 6.0l hpop only makes about 1700 psi at wot, at hot idle the ipr is 25.1 and the icp is about 580. It runs pretty good but it seems the crank time to start is getting a little longer sometimes, other times it fires right up. It makes no difference if its hot or cold. Do pumps get weak or do you think I have a leak?....
View 1 RepliesFord 6.0L Power Stroke Diesel :: 2006 F350 - Check Engine Light That Came On / EGR Volts Weak
Truck had a check engine light that came on. Plugged in scanner while I was still running it, said egr volts were weak, i just cleaned it yesterday.. and earlier today reset the check engine light once but then drove about 30 miles with no reoccurrence of light. Now i pulled over, shut off truck unplugged egr and reconnected. Went back to start my truck and nothing at all. Its like I am trying to start it in park.....been here for about 3 hrs now I've checked fuses nothing is blown. I am just sitting here freezing trying to fig out anything i can on line....... Its a 2006 f350 6.0 ty
View 14 RepliesFord 6.0L Power Stroke Diesel :: Brakes Normal Under Light Braking But Weak During Fast Stop
My truck is a 2004 F350 6.0 as with most of the ford diesels from this era it has hydro boot brakes.
Under normal braking the truck felt fine and the brakes behaved as they always have. However if you where to depress the brakes hard, as if making an emergency stop, the brakes would not lock up in the way they did when I bought the truck two years and 80,000km ago. The problem was slow to appear and at first I blamed it on the larger tiers I was running (stock 2012 F350 wheels and tires (yes the offset is wrong)) but after switching back to my stock wheels for the winter I knew that something was not right. It was something I could live with, it did not make the tuck unsafe it was just that it did not stop as well as I knew it could and this avowed me. I replaced the front and rear calipers and when that had no effect I swapped out the master cylinder this still made little difference.
I drove the company truck all of last month (2008 GMC 2500 Duramax) and when I got back in mine I realised that I had to chase down the problem. I did a lot of reading online and after thoroughly flushing and bleeding my brake system I narrowed my problem down to either the hydro booster or the power steering pump. The plan we came up with for diagnosing was:
1. Thoroughly inspect for PS/Hydro boost and brake fluid leaks following the procedure found here Hydro-Boost Power Assist Systems: Operation Diagnosis and Repair
1a. Consider bleeding the brakes as a bit of trapped air would cause your symptoms.
1.b Consider flushing the PS system. Some suggest this works with tough steering.
2. Have a shop check the PS pressure is within spec. (assuming this is cheaper than buying the tool or just replacing the pump) If it is low, replace the PS pump.
3. If PS pump is fine, or is replaced and the problem is still there, consider replacing the Hydro booster.
It is not super complete but it was a place to start. We checked for leaks and found nothing. The pedal would not sink under braking but would say firm meaning the brake system was free of leaks.
I began a rudimentary test of power steering pump. With the truck in the drive way I could easily turn the steering wheel however, applying the breaks about half way would make turning the wheel imposable. This led me to believe the power steering pump was starting to go. The next step would be to have the pump tested using a power steering pressure gage or take the truck to a shop to have it tested. I found the pressure gage to be more expensive then the new pump so went that way. With 350,000km on the truck I figured it was not a bad thing to do even if it turned out to not be the cause of the problem.
It is a bit tricky to get the power steering pump out but after pulling the radiator line under the truck I could drop the pump out the bottom. The new pump went back in the same way and after a full flush and bleed of the system it was time for a test. What a difference! The truck stops like the day I got it. If your symptoms are like mine I would recommend you check the power steering pump. If it is the problem it is a lot cheaper then replacing a master cylinder or calipers.
Golf VI R :: Almost All Power Loss Once Hit 5k Rpms?
I seem to loose almost all power once I hit 5k rpms. Like I will floor the car and Ill feel a nice pull and all of a sudden once I hit 5k it slowly starts climing like a hybrid civic. wtf? Could this be a misfire, tune problem, exhaust leak IDK
View 20 RepliesGolf IV / Jetta IV :: Losing Power At 4,000 RPMs
I have a 3inch cat back exhaust, cold air intake, and a stage 1 apr tune. I just installed a front mount intercooler. When I spool my turbo in 1st gear the car loses all power at 4 grand and just bogs out after that. Rpms keep climbing but the speed doesn't move. What's going on?!
View 8 RepliesGolf V R32 :: Car Lost Power And The RPMs Dropped Promptly
Last wednesday when I was on my way home, the car felt like it lost power and the RPMs dropped, I keep on driving until I got home, I let the car cool off for a few minutes then I tried to start it and it wouldn't, after a few tries the car started and then died.
I didn't take it to the dealer because it was kinda late but I called and made an appointment for the next day, I ended up not taking in the car since it ran good all day and I know they don't do nothing unless they can replicate the problem, now this morning the car started acting again and it smells like gas inside the cabin and weird noises are coming from the gas tank filler neck.
[URL]..........................................