Golf IV / Jetta IV :: Whistling Noise When Hit Boost
I just recently notice a whistling noise when I hit boost. I'm not sure but it sounds like it is coming from my gauge. I'm not losing boost pressure. I do have a glow shift gauge. The most recent install was the TIP which I clamped on to the turbo but I'm wondering if it isn't on tight enough.
View 2 RepliesGolf IV / Jetta IV :: Chirping Noise Under Boost?
I think my stock DV is going bad, my car makes a weird noise under boost?
1. Only happens when first starting the car after it has been sitting for an hour or a few. (not overnight)
2. Does NOT happen when first start in morning.
3. Goes away after like 5 minutes every time and the normal WHIIISHH sound comes back like it should when I step on the gas.
4. It does not make the sound at idle.
This recording I made was of my car being revved up after it sat for one hour.
[URL] ...
Golf IV / Jetta IV :: High Pitched Noise While Under Boost
I'm having a strange, very high-pitched, noise that seems to be coming from my turbo or (possibly) somewhere else in the engine bay. It sounds very screechy, and it may be paranoia, but I believe it also may have a slight metallic sound to it.
It all started yesterday after changing the thermostat housing for the third time in 2 days (autozone sold me a faulty, warped, housing that leaked after install). During this repair the engine never overheated (it did however leak fluid and go a little low) and the main point for replacement was a stuck thermostat. After finally getting it fixed I took it for a test drive and noticed the horrid noise after hitting a good amount of boost (no gauge installed). The noise occurs when boosting and doesn't happen when spooling in the 3k-4k range. I had no hint of the noise before this.
There doesn't seem to be any drop in performance and it still pulls hard. Hoping this to be a loose exhaust connection or boost leak. May be spooling sound escaping.
Mods:
- short ram air intake with an aem filter
- 3" turbo-back exhausted
- revo chipped
- 4 bar fpr
Golf IV / Jetta IV :: Losing Power And Boost At 4k RPMs After Tuning
I have a 2002 gti with an apt software tune. Whenever I'm on the interstate in 5th gear for a while. And I'll start to speed up. Once 4k kicks in. My boost no longer works when it normally pushes like 22psi. Then after slowing down. No matter what gear I'm in. It limits back to 10psi of boost and once I hit 4k. It goes super slow and boost won't work. I'm not sure what else I should get to restore my car to perform fully.
I'm currently on the factory ko3 turbo and the previous owner had nitrous hookups and lines to the motor.
I'm already 3k into fixing it. Needed new shift cables and a fresh transmission
I'm hoping to push about 250hp maybe 300hp
The boost problem is fixed once I turn the car off and back on. I just want it to work again without having to spend an arm and leg on parts and labor. My mechanic works at Volkswagen dealership. But isn't allowed to work on my car due to dealership policies about working on vehicles older than 10 years old. The guy who tuned my car professionally at an apr shop told me that I should get a smoke test done (idk where or how to do that) for my vacuum lines and that I have a cylinder 4 misfire. It may be a bad coil or spark plug. But I'd like to get some performance out of my car and I don't know what else or where to start.
Golf IV / Jetta IV :: Losing Power And Boost At 4k RPMs After Tune
I have a 2002 gti with an apt software tune...
Whenever I'm on the interstate in 5th gear for a while. And I'll start to speed up. Once 4k kicks in. My boost no longer works when it normally pushes like 22psi
Then after slowing down. No matter what gear I'm in. It limits back to 10psi of boost and once I hit 4k. It goes super slowe and boost won't work
The guy told me that I should get a smoke test done (idk where or how to do that)for my vacuum lines and that I have a cylinder 4 misfire. It may be a bad coil or spark plug. But I'd like to get some performance out of my car and I don't know what else or where to start. I am new to this.
Golf IV / Jetta IV :: Losing Boost / Power At High RPMs In High Gear
2003 jetta gls 1.8t 5spd - gts stage 1 tune(gonzo stage 2)
tt 2-1/2" downpipe with high flow cat
turbo smart splitter valve(set to divert only)
turbo inlet pipe
homemade intake with k&n filter
stock n75 valve (f)
So in first through 3rd gear my car gets 20psi of boost then at 3,500 ish rpm smoothly starts to lower down to 15psi. but in forth and 5th gear the boost drops faster, enough so the diverter valve actually opens. then the boost will bounce up and down, around 15psi. the car still accelerates but with obvious power loss.
Is my diverter valve not "firm" enough? it is adjustable, so I've tightened it as much as it can. it doesn't seem to change anything. it came with spring spacers to make it tighter, but I haven't tried that yet.
Is it something with the tune? not enough fuel, need bigger injectors? The problem is only at about 100mph, so its not a big deal. I would like to get it straightened out if possible.
Golf IV / Jetta IV :: Won't Boost Past 4 Lbs?
my car into VAG COM and since then it hasn't boosted past 4 lbs. it has Revo stg 2, K04, aftermarket side mount, full exhaust and a couple other bolt ons. Before the car was spiking at around 23/24 lbs. after pressure testing the system I found that the turbo inlet pipe was lose, so I tightened it. Still no change. I tried holding the battery terminals together for 10 minutes to reset the ecu and I also tried clearing the codes through a handheld code reader. No codes even come up anyways for this. The car is a 1.8T.
View 4 RepliesPassat (B5) :: Low Boost Code And Strange Noise
I currently have the P0299 code for underboosting. I am pretty certain that i need to replace my wastegate actuator because i can hear it rattling on deceleration.
My plans are to replace it at the same time I replace the timing belt since it would be a decent opportunity to remove the turbo to change the WG actuator. However, I still can't figure something out. When I am starting to accelerate from a stop in 1st gear (and only 1st gear), there is a loud screech, lasting only a second, coupled at the same time by a quick and noticeable loss of power; as if boost was released. I typically shift out of 1st within 2500-3700ish rpm, if that makes any difference.
From what I have researched, this sounds like the turbine making contact with the housing. I may be wrong, but that does not add up to me because I am only experiencing this problem in 1st gear. We are talking about a 2003 B5.5, Engine Code AWM. No mods, 100% stock.
Golf IV / Jetta IV :: Car Loses Boost Throughout The Rev Range
So my 2001 1.8t Golf is having some issues holding boost. I have a Gonzo stage 2 tune, CTS FMIC, Forge 008 Diverter, Silicone inlet and MagnaFlow Exhaust. I've also done the whole Evap, SAI delete and installed a catch can.
Starting in 2nd or 3rd at WOT the car spikes up to 18psi and then progressively loses boost throughout the rev range. Close to redline the boost drops to 5 psi or so. It seems to be dependent on the revs. In fifth gear the car holds 18 psi much longer as the revs don't increase as fast.
There are no CELs. I've done multiple leak tests starting at the air box and plugging the pcv/catch can system as well as at the compressor side of the turbo. None of the tests revealed a leak anywhere in the intake system. However, when I stuck my ear very close to the valve cover I could hear what sounded like a very small air leak coming from inside the valve cover. I took a look at the wastegate actuator and it seemed fine, no play in the rod, no loose bolts and to move it just requires enough force to compress the spring and it returned to its original position.
My thoughts are that it could be a fueling issue or turbo in the process of dying maybe.
Golf IV / Jetta IV :: Slight Drop In Boost
Just noticed today that I have a slight drop in boost. Normal boost is 1.5 bar but today it is running slightly lower boost and does not have the same pull through all the gears.
2001 mk4 1.9 tdi golf
Golf IV / Jetta IV :: Car Wouldn't Run 10 Psi Of Boost After Stop
I was riding along today everything running fine then I came to a stop sign and when I pulled off my car wouldn't run 10 psi of boost it was only running 5 psi so I when to a buddys checked everything over and all my piping looked fine so I went up the road and everything was fine so when I started going home it did the same thing pulled of shut the car off pulled off and it was fine again.
View 5 RepliesGolf IV / Jetta IV :: Power Loss - Code P2178
My car has been throwing a code P2178
P2187 System Too Lean at Idle (Bank 1) DTC.
Checked the intake, checked maf, checked injectors.
Today after leaving show n go. Stopped at a gas station (never turned off the car) leaving the gas station the car was loosing power, I thought I was in 3rd instead of first. No, I was in 1st. Driving and car was sputtering and wasn't getting any power. After a few blocks it sounded like its gonna shut off. Pulled over to the side. Car died, doesn't wanna start again. Got spark, got fuel to the injectors, discoed the sensor to maf, still cranks but doesn't start. Got it towed to NY from NJ. Still no start. Few people said crankshaft sensor, starter, clogged cat or fuel filter. Car isn't throwing any codes now (probably cuz the motor didn't start) any clues on what it can be?
Passat (B5) :: CEL And Code P1596 - Noise Coming While On Boost
Ok, I just bought this car a month ago, and I get this code coming up intermittently. I reset the code, and it will come back after driving a while. 2002 passat 1.8t 5 speed. It seems like it comes back when I roll backwards a little bit (like from a standing start on an incline) right before taking off. Could this be a leaky throttle body to inter cooler hose? Seems like the engine might move more while taking off from a backwards rolling start due to the torque. Also, I hear a lot of noise while on boost coming from the drivers front corner of the car, although it doesn't throw a code while on boost.
View 5 RepliesGolf IV / Jetta IV :: P0171 Code Come On - Tapping Noise Coming From Engine
P0171 system to lean.
I already replaced the MAF so what else could it be I cleared it once and the cel came right back on. I have a stasight pipe from the catback on my car and the cabin started smelling like burning plastic and eggs every time I accelerate. I'm going on a road trip tom and was wondering if I'll be fine. The car has a bit more noise coming from the engine the usual more like a swiping tapping noise
Golf IV / Jetta IV :: Surge / Stutter - No Boost Leaks
Replaced my coil packs/sparks, and just got around to changing my N75 valve today. The rough idle issue is gone but now when I go WOT it boosts but goes from 15psi-12-13-12-14-12...etc. I've checked and there are no boost leaks. I do have a CEL saying I need a new bank 1 sensor 1 Oxygen sensor. If it is that, why did this problem arise as soon as I changed the N75 valve and wasn't present earlier?
View 1 RepliesGolf IV / Jetta IV :: Car Won't Go Into Boost, 2 Error Codes Detected
I was having an issue with my car not going into boost so I plugged my code reader in and it had 2 codes 1 was p1200 n249 malfunction and the other was diverter valve malfunction so I did the quick easy one and got a new factory diverter valve but it still doesn't go into boost and still reads p1200 n249 what do I need to replace or should I do the n249 bypass it's a bone stock jetta 5 speed.
View 5 RepliesGolf IV / Jetta IV :: Car Runs Fine But Won't Boost Over Wg Pressure
I just got done with a complete engine rebuild on my 02 1.8t jetta, had everything hooked back up and went to start it for the first time and it wouldn't. I went back looking for loose connections, nothing. Worked and banged my head for a day or two, I had fuel and spark but couldn't get it to fire. Finally I "choked" the intake to see if it was getting too much air and it fired right up. I unplugged my map sensor giggles and it starts up perfectly. I then hooked everything back up and what do you know it starts up and runs fine, but if I plug the sensor back in it kills the motor after about 10 seconds of running and won't start until I unplug the map again.
Car runs and drives but wont boost over wg pressure but that's probably because sensor itself is unplugged. I just wanna know what could cause it besides the sensor itself being bad. I ordered a new one waiting for it to get here (hoping it fixes the problem).. And I'm talking map (manifold absolute pressure) not maf (mass air flow), just in case people are confused.
Golf IV / Jetta IV :: Engine / Boost Complication After Stationary
I got a Mk7 in October and my Mk4 has unfortunately been parked since. I started it and let it idle to warm once a week or so when I went on Vacation for 10 days. Before going on vacation I moved the car and after warming up everything seemed to be normal. Unfortunately I neglected it once I got back and haven't started it since the beginning of December. I'm selling it here soon and so went out to spruce her up tonight and upon trying to start the battery was dead so a buddy came over and jumped it.
It started right up but immediately was idling funny which I assumed was because of the cold (it's 25 degrees F tonight and has gotten in the negatives in the past few weeks due to snow storms). I shut it down and checked the fluids which were all pretty low especially the oil due to a small leak. So I topped off the all the fluids and started it again and let it idle to full warm.
I decided to take it for a drive around the block and it was still driving pretty rough, no knocking or anything but the engine was "sputtering" and the CEL was on and flashed when I gave it gas. I'm running stock boost so my gauge usually reads around 12psi but is now only going up to 3-5 psi and the vacuum is only at -15 which i think used to idle at -20. I drove it to the gas station and filled it up from a little less than a half tank but it's still running the same and there's a slight burning smell from the exhaust.
I was worried it was my turbo but it was perfectly fine a month ago. I was thinking of throwing some Seafoam or Heat.
Golf IV / Jetta IV :: Boost Gauge Is Reading Peak Of About 15 - 16 PSI
Okay, here's the car
AWP 1.8t mk4 GTI.
- stock DP
- Forge 007 splitter adjusted 25 clicks
- Swiss cheese stock intake with k&N high flow
- APR stage 1 93 tune.
My boost gauge is currently reading peak of about 15-16 psi. I replaces some vacuum hoses that appeared to be worn, and to no avail. I have no CEL, and no codes thrown at all. This sound like a boost leak.