GTI 337/20th Anniversary :: Turbo Manifold Installation
How hard it is to install a turbo manifold??
View 3 RepliesGTI 337/20th Anniversary :: Getting Two Codes - Engine Temperature Too Low - Turbo Boost Pressure Too High?
Engine temperature too low. Turbo boost pressure too high. The car has the APR 93 octane program, carbonio intake, and silicone TIP.
What could be causing these codes? The car gets up to temp (190) real quick and stays there, and I don't feel a fluctuation of boost.
GTI 337/20th Anniversary :: Lug Bolts Are Loosening - Leaking Little Trans Fluid?
I have a peculiar problem. When auto crossing and driving the car hard, the lug bolts on only the front driver's side wheel have a tendency to loosen. I torque the bolts to 100 ft-lbs with a torque wrench, so I am confident they are tight before I start driving. The retaining screw holding the rotor in place loosens as well. The wheel has fallen off once already while driving.
I do notice in the transition from accelerating to decelerating (only sometimes) that there is a stuttering from the front driver's side (sounds a little like an out of balance wheel). When it happens, it's often at 55MPH in 5th and at lower speeds in lower gears. The car was leaking a little trans fluid too (.5qt), but I can't tell from where. It has since stopped.
GTI 337/20th Anniversary :: Noise From Front Suspension When Backing Out Of Garage
Noticed the other day when I was backing my GLI out of the garage a clunking or popping noise that sounds like it's coming from the drivers side. It only doesn't it once and only when I am backing out and turning at the same time like out of my garage or parking spot at work. My car has roughly 54 thousand miles on it and still the original suspension.
View 10 RepliesGTI 337/20th Anniversary :: Car Keeps Shutting Off After Replacing A Manifold Hose
I'm new to VW but I just replaced a manifold hose and now my car keeps shutting off but if I let it sit for like 5 min. It starts right up. The hose that came on it was plastic n I switched it to a rubber one from advanced.
View 12 RepliesGTI 337/20th Anniversary :: Manifold Cracked While Installing Exhaust?
Just received my discount GHL exhaust. and Discount it is. To boot some friggen how the manifold is now cracked? and I wonder if the warranty will cover the broken manifold?
View 11 RepliesGTI 337/20th Anniversary :: Turbo Went Out / Car Is Sluggish
My 20th just hit 107k and in the past couple days I have noticed that my car is somewhat sluggish compared to normal and there is also a VERY audible whine when I take off from a stop.
The same thing happened to my friend's Turbo 300zx when his turbo went out and I think that may be whats happening to mine.
This is the perfect excuse for me to replace my K03 with a more respectable turbo like a K04 hybrid or possibly a BT setup. What I'm wondering is how expensive these options are and how worth it are they. I know you can get away with not upgrading certain things when going BT, but I want to do things right to avoid problems down the road
SO....
I currently have Stage 1 APR software, DG Short shifter, and and itg SRI.
I'm not trying to build a 500hp fwd beast, but what all is considered necessary to run a BT without issues and what would the price be? Again, estimates are totally fine, I can locate parts if i know what to look for
And lastly: What is the general opinion of the ATP Eliminator? I haven't heard much about it and all of my research is fairly inconclusive. I'm just trying to weigh my options.
GTI 337/20th Anniversary :: Trunk Made A Noise And Won't Close
I went to go get gas today and tried to open my fuel door with he button on my door and it wouldn't open. The trunk opened fine but when I pressed the gas button it made no noise and didn't move at all. I've never had a problem with my fuel cap and all of my locks besides this one work fine. I also can't manually open my fuel cap from the back, because in my GLI, you can't bet much further back behind the tail lights.
View 2 RepliesGTI 337/20th Anniversary :: Sunroof On 2004 GLI Opens By Itself And Now Won't Close
The sunroof on my 04 gli just decided to open by itself and now it won't close. Why this is happening?
View 16 RepliesGTI 337/20th Anniversary :: Turbo Is Going Out / All Acceleration Stops
I have a 2004 VW jetta GLI 1.8 turbo and when i get it to about three and a half grand it feels like my turbo is giving out, all acceleration stops. But I doesn't do it all the time, meaning not every time i step on the gas, like I can step on it all through first and second, and it will do it in third or visa-versa. Which leads me to believe that it could be a fuel delivery problem but I don't know, im new to the VW game. The check engine light will come on while the car is bogging down but as soon as the rpms go down it will turn off.
View 1 RepliesGTI 337/20th Anniversary :: Automatic Window And Sunroof Close When Turning Car Off
I picked up my beloved 20th last week. It has this feature that when you shut the car off it closes the windows and sunroof. It's very annoying. Is this an aftermarket item that is doing this or is it a stock program? I don't think the car has an aftermarket alarm but I'm not 100% positive.
View 20 RepliesGTI 337/20th Anniversary :: Turbo Going In And Out Of Limp Mode - MAP Sensor Bad?
So I have a bad map sensor and lately my turbos been going in and out of limp mode. I recently just replaced with a new n75 valve and it solved the problem for about a week and now it's acting up again. Its not a constant problem it occurs usually every 20 starts. Could the map sensor be the reason why my car is going into limp mode?
View 4 RepliesGTI 337/20th Anniversary :: Clutch Pedal Goes From Being Soft To Very Hard When Close To Disengaging
I have an Imola 20th and recently i have been having some problems with my clutch. The pedal goes from being soft to very hard when its close to disengaging. It also engages very heavily when I go to let it out. This only started happening recently when temperatures started to drop if this has any effect on a clutch. Also, I replaced a shift fork two months ago and was curious if there was possibly anything going on with seals around the slave cylinder.
View 2 RepliesGTI 337/20th Anniversary :: Rough Idle - Car Get Close To Stalling When Falling From High RPMs
Just checking in to see where you'd recommend to start looking for a rough idle issue. It seems to get worse once the car fully warms up. I took a vid, and although it may not seem horrible in the video, it sometimes causes throttle lag from a stop and causes the car to get close to stalling when falling from high RPM's. Take a look at the video .....
View 2 RepliesGTI 337/20th Anniversary :: Possible To Run Big Turbo With Side Mount Inter Cooler?
Like the title says....Is is possible to run a Big Turbo with a Side mount Intercooler? Im a not talking about a 600HP kit. More like a kit that can produce something around 350hp.
View 8 RepliesGTI 337/20th Anniversary :: Installed Downpipe - Smoke Coming From Turbo
i just installed my downpipe and i took it around the block and i opened the hood and there was smoke coming from the turbo could it be b.c i didnt put the washers witht he bolts to connect the dp but i put them on really tight or could it be the wd40 i sprayed on to loosen the bolts?
View 7 RepliesGTI 337/20th Anniversary :: Vibrating Noise Coming From Turbo When Rev Up To And About 2600 RPMs
When I drive my car past about 3000 rpms then let them fall i hear an odd sort of vibrating noise coming from the turbo between where ever I rev it up to and about 2600 rpms. Is this normal? Its fairly quiet and can only be heard without the radio on and if your listening for it. This worries me because I've only had this k03 for about 5000 miles .Some background info I am chipped with uni at 20psi, full 3" turbo back and an 007 dv.
View 3 RepliesGTI 337/20th Anniversary :: Almost Staples Out And Gas Doesn't Work When Use Turbo Or Bring RPMs High
So my 20th runs completely fine until rain is involved.. Once it rains and I bring my rpms high or use my turbo it almost staples out and the gas doesn't work.. Also I notice it shoots out a puff of white smoke and my. Turbo doesn't spool at the way.. It basically tries and just does something like psh psh psh psh like second spools? Could water get in my. Turbo or something.
View 19 RepliesGTI 337/20th Anniversary :: Sounds Like Turbo Diesel Truck Every Time Accelerate / Turn It On Or Rev It Up
I was randomly driving today and my turbo started to sound a little weird.
Every time i accelerate, turn it on or rev it up it sounds like a turbo diesel truck! I have no clue what it could be..