GTI 337/20th Anniversary :: Secondary Air Pump Whistles At Cold Start
Have a little oil on the outer part of the turbo and its making a raspy noise when my turbo is spoiled not sure whats going on the car pulls just as hard and boost levels are normal i had a check engine light on for a few days right after this started code was for p0411 dont think its related cause i know my secondary air pump whistles at cold start so im assuming that the code is for that and not related to the turbo.
View 1 RepliesGTI 337/20th Anniversary :: 2002 - Won't Start - Turns Over But Won't Fires Up
A buddy of mine has a gti that is not starting. he said the temp light has been coming on and the car would start to struggle. of course he kept driving. Today it came on and stalled out. Now the car turns over but wont start. I replaced the temp sensor (green plug) and it wasn't the issue. its a 1.8t with 80k on it. 2002. I am assuming its got to be fuel or spark.
View 15 RepliesGTI 337/20th Anniversary :: Increased Air Flow In Secondary Air System?
I just threw a check engine light saying that there was increased air flow in the secondary air system...what does that mean????
View 15 RepliesGTI 337/20th Anniversary :: Fuel Pump Not Priming - Car Won't Start
Ok, car won't start. fuel pump not priming. tested the fuse, no power coming to it, fuse is good. even used another fuse. my flex connection on my dp blew out, rusty had a leak there for a while. in any case patched it up McGyver style till a new dp arrives. I backed the car off the ramps and shut it off to clean up. when I went to test drive it fuel pump wasn't priming.
View 1 RepliesGTI 337/20th Anniversary :: 2005 GLI 1.8t - Secondary Air Injection System / Incorrect Flow Detected
Chassis Type: 9M - VW Jetta IV
Scan: 01 02 03 08 15 16 17 19 22 29 35 36 37 39 46 47 55 56 57 75 76
Address 01: Engine Labels: 06A-906-032-AWP.lbl
Part No: 06A 906 032 RN
Component: 1.8L R4/5VT G 0001
Coding: 07510
Shop #: WSC 00066
3VWSE69M14M129075 VWZ7Z0D9541648
1 Fault Found:
16795 - Secondary Air Injection System: Incorrect Flow Detected
P0411 - 35-00 - -
Readiness: 0000 0000
-------------------------------------------------------------------------------
Address 56: Radio Labels: 3B7-035-1xx-56.lbl
Part No: 3B7 035 180 G
Component: RADIO 3CP 0007
Coding: 00031
Shop #: WSC 00066
1 Fault Found:
00856 - Radio Antenna
36-00 - Open Circuit
End ---------------------------------------------------------------------
Passat (B5) :: Loud Noise For A Minute Or So On Cold Start - Secondary Air Pump?
I've got a 2004 1.8T 4motion passat and when it starts cold in the morning it makes a loud noise for a minute or so then it stops and is normal again, I'vev been told by a local autoparts store that it is possibly the auxiliary/secondary air pump that needs to be changed to fix this poblem. if it is the air pump how hard is it to change and do u need any special tooling to do it or is it fairly straight forward to change?
View 5 RepliesGTI 337/20th Anniversary :: Car Starts But It Turns Right Back Off
So my Gti 337 it starts but it turns right back off starts and turns right back off people are telling me it's the fuel pump checked it it's not that people are saying its my ECM.
View 5 RepliesGTI 337/20th Anniversary :: Temperature Gauge Turns Off / Needle Goes All The Way Down
Ok I was driving home right know from work, and looking at the speedometer, i notice that my temperature gauge turns off (the needle goes all the way down). what can it be?
View 2 RepliesGTI 337/20th Anniversary :: Gauge Cluster Needles Don't Move As Soon As Car Turns On
I have a 2005 mkiv GLI and my gas gauge, temp gauge, and information display stopped working when the car is running. They work when the car is on auxiliary but not while it's running. The lights all work on the cluster all the time but the needles don't move as soon as the car turns on.
View 3 RepliesGTI 337/20th Anniversary :: 2015 - Light Switch Turns On All Accessories
so i bought projector headlights on my 05 gli and they were easy to install and for the first few days no problems, when the car was off and the lights on it was the parking (P) lights (amber lights), later if the lights were on and the car was off the radio would turn on, the A/C and the low beams would be on even if the hand-break was up, and i still have the DTR lights on. is it a short circuit problem???
View 2 RepliesGTI 337/20th Anniversary :: Loss Of Power / Starts To Die At Idle And Hardly Turns Over
I have a 03 20th ae gti with about 84k just replaced the coil packs. driving on the freeway then power just goes away, press on gas and nothing. limp it off the freeway. Then it starts to die at idle and hardly turns over. car is pretty much stock. new clutch at 75k.
View 8 RepliesGTI 337/20th Anniversary :: Cruise Control Light Turns On In Cluster But Does Not Set
Cruise control stop working? mine hasn't been working for a while, and finally decided to ask. The light turns on in my cluster, but doesn't set when i try to set it.
View 5 RepliesGTI 337/20th Anniversary :: Stock Suspension - Right Front Rubbing On Hard Turns?
I have a 20th with 106k on it and I notice mostly my right front rubbing on hard turns. Suspension is totally stock other than a 28mm rear sway. Is it possible that's causing it or is my suspension just getting old? No spacer on the fronts.
View 9 RepliesGTI 337/20th Anniversary :: Loud Vibrating Sound When Making Left Turns?
Have a 05 GLI tiptronic. Every time while making a left turn there is a LOUD vibrating/rattling sound coming from underneath my shifter. Dealership told me it was my exhaust rattling since it was larger than OEM. That doesn't sound right at all.....
View 1 RepliesGTI 337/20th Anniversary :: Can't Get Fuel Pump To Turn Over
Alright, so upon starting my car earlier today, i was unable to get the fuel pump to turn on and send fuel to the motor, car will crank over and want to start, theres just no fuel getting to it. I'm going to replace the fuel pump relay and clean up the throttle body to cover the simple stuff. also i recently just installed a 3 inch down pipe, could have the o2 sensors shorted as a result of a bad knock?
View 2 RepliesGTI 337/20th Anniversary :: Water Pump Broke
my water pump broke they other day and then i was lifting up my seat and notcie it was wet. the whole left side of my car under the carpet is wet. why do you think there is water is only on th eleft side. could it be becuase the water pump broke??
View 19 RepliesGTI 337/20th Anniversary :: 2004 - Rubbing Noise When Accelerating Through Hard Left Turns
My 04 gli makes a rubbing noise when accelerating thru hard left turns.. but weird enough i can take the same turn at the same speed in neutral and have no noise at all. I changed both front wheel bearings and cant seem to find the answer. I brought it to vw and they checked the whole suspension struts springs cv's tie rods ect. and they all checked out good they said. the car used to have a exhaust and i just recently put it back to stock, could the exhaust make the noise perhaps?
View 1 RepliesGTI 337/20th Anniversary :: Coolant Leaking From The Water Pump
I replaced my timing belt, tensioner and water pump last weekend because I noticed I was leaking coolant from the water pump. The other day I popped my hood after driving and notice the reservoir bubbling a little bit because it sounded like the coolant was boiling and the line coming into the top of the reservoir felt hotter than normal. I opened the cap slowly and never heard any pressure release. I figured it was air in the line somewhere so I tried to work the air out. It sounded like the air came out and I took it for a drive and I finally heard pressure release after 3 different attempts. I opened the cap later when it was cool and noticed that the coolant was still at the original level.
Then the next day I was driving and came to a stop and noticed white smoke coming out when I gave it gas. It still drove fine though. I pulled over and opened the cap slowly but didn't hear any pressure release. I put in a little bit of radiator sealant and it seemed to do the trick.
The car has never overheated and there's no oil in the coolant or coolant in the oil. The heat also seems to be working correctly and my fans come.
GTI 337/20th Anniversary :: 2005 - Auxiliary Water Pump Works Intermittently?
Just want to make sure I'm naming the part correctly. It's a pump that between the radiator and the block. It stays on after the car is turned off. This is on a 2005 GLI 5 speed tip.
Lately, its not turning on. If it does, it's just for a brief moment and then turns off. After some searching, I've read post of other asking about by-passing it. Would that be a benefit? What's gained from that? I understand the pump is on while the engine is running, does it provide additional cooling? I'm planning on checking it out this weekend and wondering if it could be rebuilt? Could you guys indicate which vendor on the web has the best price?