GTI 337/20th Anniversary :: Blow Off Valve On Stock 1.8T?
I wanted to get a blow-off valve for my GLI but its bone stock, i was wondering if its possible or if it would cause problems. and if i can whats a good brand?
View 17 RepliesGTI 337/20th Anniversary :: CV Boot Blow Out After Few Hundred Miles
So the long story short, i bought a JB 20th with 36k miles on it, lowered on Neuspeed Race Springs and HD Koni Struts. When bought, both inner CV boots were torn on the car. I ordered OEM CV boot repair kits for all four joints (made by Rein OEM manufacturer) and rebuild the axles completely.
I got the car up in the air today and the drivers side inner CV boot is already torn, after only a few hundred miles (if that many).
From what i understand, it is a common problem on the O2M 1.8T setups after lowering? Is there a solution?
I searched around, but it is still not clear what is the source of it, even though i found plenty of threads that state that its a common problem.
Upon inspection, the geometry of the axle or the angle at which it operates when the car is on the ground does not look that bad, it simply does not make sense.
GTI 337/20th Anniversary :: Boost Losing - Loud Blow Off Noise At Around 15 Psi
I got a 04 jetta gli that is making a loud blow off noise at around 15 psi. Up until then the the boost holds fine but then at around 15 psi it just starts whistling really loud and loses all boost. I recently replaced the DV and venthose by the camshaft, and made sure that it is tight. I also installed a 42DD 3" exhaust recently. The car has about 96k on it with stock vacuum hoses except for the aforementioned adjustments. I'm pretty sure it's not the hose and DV I replaced because I made sure that they were tight to see if that was the problem, and it did not fix it.
View 2 RepliesGTI 337/20th Anniversary :: Valve Blow Off With Vacuum - Negative Boost?
This is my other question. I have an APR program and turbo-back billy boat exhaust. I installed a boost gauge that gets the reading off of the intake manifold (fuel regulator.)
So if I'm just tooling along, short-shifting and only using 1/10 throttle, and my boost gauge never reads above -5, let alone 0 or positive, why does my valve release pressure?
Why would there be pressure to release if there is a vacuum, according to the gauge? I wouldn't think that a recirculating or blow-off valve would work in reverse.
GTI 337/20th Anniversary :: Forge Splitter / Recirculation And Blow Off Valve Installation?
Looking to have it installed? I bought it but I haven't installed it yet...
View 2 RepliesGTI 337/20th Anniversary :: EPC And ASR Upon Cold Start
I get EPC and ASR upon cold start from time to time. Usually EPC goes away if I restart in a couple of minutes. ASR goes away after a while and restart.
So after car warms up and restarted, everything seems fine.
GTI 337/20th Anniversary :: Car Feels Like It Grinds When Cold
Got some issues going from first to second when the car is cold. Kinda feels like it grinds not sure if it is or not. When it warms up seems ok. Changed the fluid, smoother but kinda worries me.
View 6 RepliesGTI 337/20th Anniversary :: 2004 - AC Quits Blowing Cold
Have 66,000 on the clock. AC has blown cold since i have had the car, and yesterday quits blowing cold, summer is right around the corner.
View 2 RepliesGTI 337/20th Anniversary :: Car Takes 2 Or 3 Times To Start From Being Cold
Revo stage 2 --1.8t ... For the past few days I have tried to figure this issue out I am having with my 337. The car takes 2 or 3 times to start from being cold. Once its started it has no issue it drives awesome, pulls hard no codes when vag com'd. Can start it up anytime with ease for the rest of the day. Tried doing to solve:
-I have pretty new coilpacks---FSI- they are ok
-Spark plugs are 3 months old --checked those
-Checked Battery and its all normal and no issue
-Cleaned the throttle body = No change
-Installed new CTS yesturday (green) < no change
-Cleaned the MaF = NO change in start up but car runs way smoother
-Put in new Filter= No major change
-Did the Crank sensor under a month ago (Bosch)
I have a few more things on my list to check :
1. Fuel pump relay
2. Fuel Pressure Reg
3. ECU relay/ check immobilizer
4. Fuel Pump
GTI 337/20th Anniversary :: ESP Light On - No Traction Control When Cold?
so another winter has come to me in michigan and i had to take off my nice performance tires and put on the winter steelies. but as i come to now with them on, my ESp light has come on, on my dash and wont turn off even if i reset the car. i havent checked the VAGCOM yet cause that laptop is at my parents. the tires are the same i used last year and didnt have this happen either. any thoughts on this and what could be wrong? haveing no traction control in the winter is not cool to have in my book.
View 11 RepliesGTI 337/20th Anniversary :: Hard To Shift Into Second Gear At Cold Startup
It all started after it being cold outside it's hard to shift into second gear when i first start up the car, and then after a couple shifts like that i get a notchy shift. after a while of driving it all disappears.
View 3 RepliesGTI 337/20th Anniversary :: Secondary Air Pump Whistles At Cold Start
Have a little oil on the outer part of the turbo and its making a raspy noise when my turbo is spoiled not sure whats going on the car pulls just as hard and boost levels are normal i had a check engine light on for a few days right after this started code was for p0411 dont think its related cause i know my secondary air pump whistles at cold start so im assuming that the code is for that and not related to the turbo.
View 1 RepliesGTI 337/20th Anniversary :: 1.8T Cold Start Hesitation - Choking And Sputtering
Recently purchased a 2005 Jetta GLI with 31,xxx miles on it. It is my second 1.8T. My first was very reliable, with never any issues even after the 100k mile mark and is the reason I didn't hesitate to buy another one. That, and the Recaro Edition GLI has always been one of my favorite cars.
So I've had it for about a month now and I've noticed on occasion a problem with cold starting. One weekend it sat for almost two days because we used our other car, and then again this morning it was particularly chilly here in Pittsburgh, about 35degrees F and it took me two starts to get it going.
I always turn the key to 'on' for a few seconds and let the fuel pressurize and all the indicators light up. It doesn't appear to be the battery as it turns over strong, though I have not yet confirmed this is a Voltage reading. Once it kicks over, it seems to be choking or sputtering, unable to get up to idle. The second time, it does it again but gets past it and all is well...
I'm checking records now to see if the 30k mile service was completed. perhaps a tune up and new plugs would work?
GTI 337/20th Anniversary :: Squeak And Creak When Ride With Windows Up While Cold Outside
Here's my issue: as it gets colder out, I ride with the windows up, so all the little squeaks and creaks get that much more noticeable.
Ones in particular that drive me nuts are the squeaks that originate from the rear deck area (almost as if they are coming from the rear upper shock mounts between the C-pillars - I think this is a Jetta-only issue). I had a c-pillar bar in the past and it seemed... but the bar is a tad unsightly, and it rendered my rear seat belts useless.
Need finding and eliminating these noises in the back? I'd rather not run one of those bars again if at all possible.
GTI 337/20th Anniversary :: Clutch Soft In The Cold, Stiffens Up When Warmed Up
20th with 120,000 miles. Ok here's my problem, get in my car in the morning after a coldish night, (around freezing) clutch pedal goes almost to the floor with no resistance, i pump it a say 5 or 6 times and it gets stiffer but not 100% i drive it for 10 or 15 min and it warms up and the clutch gets back to normal stiffness. I'm thinking its the master or slave cylinder going bad or maybe it just needs to be bled and before i go and buy both of them and replace them, just wanted some opinions. Also its not leaking fluid at all and the reservoir is full.
View 2 RepliesGTI 337/20th Anniversary :: How To Prevent Water From Getting Into Cold Air Intake In The Rain
So I dont have the money to but a new intake, I am having problems with water getting into my cold air intake under the car. What i could do or something cheap to buy to prevent this problem??
View 13 RepliesGTI 337/20th Anniversary :: Rear Strut Mount Noise When Cold?
Is this possible? I recently installed raceland ultimos and I get this weird muffled noise from the top of the rear suspension. Took it all apart, cut the bump stops shorter, and lubed the strut mounts. Sound went away for about 10 mins of driving, went for another drive and the sound was back. The next day the weather was warmer and the noise was gone. Should I just get new strut mounts?
View 6 RepliesGTI 337/20th Anniversary :: Making Whistle Noise When Cold Start?
just noticed when i cold start my car the turbo makes a whistle noise until it warms up and when i drive hard when its spoiled it makes that whistle again......
View 3 RepliesFord - Fivehundred :: 2005 - AC Will Blow Cold When Running Fast And Then Blow Hot
I'm at the end of my rope! My 2005 Ford Five Hundred Limited has a constant problem with the A/C system and overheating. In the last year I've replaced the compress, expansion valve, dryer FOUR times. They have replaced the condenser, blower motor, and added Freon, and checked for leaks. It will blow cold when running fast and then blow hot. They have replaced belts pulleys, They have replaced the thermostat, fans, coolant reservoir, hoses. and it still overheats. I've taken it to 4 difference mechanics including two dealerships. No one can seem to fix this problem.
View 9 Replies