Ford Transmission :: Won't Go Into Park - Which E4OD - Replacing Trans?
having never been into an E4OD, I have a quandary. I have an F-350 with a 460 engine with the E4OD trans. the trans works fine, but wouldn't go into park. I pulled the pan and tail housing and found that the thrust washer behind the park wheel had broken and dropped down to obstruct the pawl from engaging. I have no problem in tearing into a C-6 on back, but the E4OD, I'm not so sure. I had considered just pulling the trans and replacing it with a used one. I can find all kinds of trannies, but NOT the '89 to '91 that I'm told is what is needed because of the electronics. I have been told that the '87 to '97 will work but I have to swap out the electronics? is this so, and how much of a mess is that to do? OR, someone told me that it is possible to use the 4X4 trans by putting on my tail housing? doesn't sound right to me, but what do I know? any pointers????
View 5 RepliesFord Transmission :: 1994 - E4OD Trans Rebuild - Clutch Thicker Than New One?
1994 E4OD Transmission.
Transmission was slipping terrible after vehicle warmed up. After feeling around for thoughts, it was suggested by numerous people that the transmission needed an overhaul.
Upon Disassembley the clutches were found to be excellent. They are actually thicker than the new ones in the kit. By .015" actually. Quite impressive considering they are 20 years old.
So now, I have kind of lost direction. If the original clutches are thicker than the new ones, and don't show signs of wear. What does that mean?
The fluid is pretty good, and there aren't fragments of metal. Nor is there any metallic shimmering to the color. It doesn't smell burnt or rotten either.
I have drained the torque converter and filled it with gasoline. I am going to spin it and hopefully knock any sediment loose.
[URL]
Ford Transmission :: 1993 E4OD - Trans Is Skipping Out Of Lockup For 1 - 2 Seconds And Then Goes Back To Normal Operation
Vehicle: 1994 TripleE RV based on Ford E350 7,3 Diesel, 70000 miles.
My trans is skipping out of lockup for 1-2 Seconds and then goes back to normal operation with lockup engaged. I am shure that it is the lockup disengaging because the increase in rpm is not as much as between gears.
This happens appr once or twice every hour when driving at normal constant highway speed. It happens both in 3rd and in OD. There is no flashing OD lamp, and the OD button is working (I use this actively when going up hill to keep up momentum and rpm)
I am not able to find out what causes this. I have replaced the speed sensor on the rear axle, the rpm sensor on the engine and the brake light switch on the brake pedal. Replaced one item at the time to be able to determine if any of these items was causing the problem. But none of them made any difference, the problem is still there. I have also inspected the harness connector on the trans and it seems fine to me.
Ford Transmission :: Auto Trans Jump From Drive To Neutral?
So I drive a 79' f-150 and my truck when I take left turns, start on a steeper incline or give it too much gas my automatic transmission tries to jump from drive to neutral. This only happens initially; if I'm on the free way and at a higher rate of speed it doesn't do this but it seems like when I give it any more than a little gas it tries to jump into neutral (it has once) it doesn't or hasn't really done this on right turns I don't know if that makes sense or not.
Why it may be doing this and if so what I might be able to do about it? I do have a book for my truck and I have done some small things but I don't really know a whole lot.
Ford Transmission :: 1992 - 4x4 Auto Trans Will Slip Out Of OD Into Neutral
I bought it for cheap. not shure what tranny is in it. So when you you put it in od it will take off and shift fine all the way to od. getting going and drive it a few miles and it will slip out of od into to neutral. I can put it in drive and it does fine. I did lose all forward gears earlier tonight though. First time it did this. OD is the only gear it slips out of. it willl re engage below 40 mph. But I usually just shift to drive and go on.
View 12 RepliesFord F-150 (2004-2008) :: 2006 - When Shifting While Driving Down The Road And Hit 30 MPH It Goes Into Neutral
Transmission trouble on an 2006 F150 5.4 triton ... The problem I am having is when you are driving down the road once you hit 30 mph and it goes to shift into the its like it goes into neutral. It does that rill you slow back down to a lower speed then it shifts back down the transmission picks right back up till you get up to speed again, then it like it goes into neutral again. When I turn overdrive off it won't shift out of second gear. I have changed the valve body to the transmission to no success.
View 3 RepliesTrans Sport :: 1995 Just Quit Driving Down The Road / Would Not Restart
My 1995 TS with 3.8 just quit driving down the road, would not restart. had to be towed home.
Fuel pressure just meets specs at 41 PSI engine off ( Gm says 41 to 47), but has been that way for some time. Put Actron scan tool on, got a code 361, EST not toggling. GM has no code 361, but based on past experience, this has usually pointed to a defective ignition module, and I thought that was that. While testing, scan tool kept losing communications and having to be reset.
Finally I unplugged power source of tool, and engine immediately quit and would not restart. Resetting scan tool would allow engine to restart, albeit very rough. Doing a wiggle test of engine wiring harness makes no change.
Crank sensor was replaced, about 12 years ago, so it not the trouble prone OEM; cam sensor about 10 years ago by a garage who was unsuccessful in solving a driveability issue.
Issue here is why would scan tool affect engine operation?
Ford Super Duty (1999-2016) :: 1990 F250 E4OD Tranny Would Seemingly Go Into Neutral While On Freeway
I have a 1990 F250 with a 7.5 liter and an E4OD. It starting acting up a couple months ago. Tranny would seemingly go into neutral while on freeway. I figured trans was going out... After reading several threads I've decided to try changing the mlps first, got a new one at the dealer!!!. It is the updated one with the connector on the top. I'm currently waiting on a new pigtail from autozone (the original is in bad shape, wires frayed, insulation missing. Also I think when it started having issues we were having some serious rains, which may have caused this connect to get wet.
I believe a previous owner may have had the trans rebuilt at some point. The connect has 6 wires going in it and when I trace those wires back, two are spliced into one farther up the harness a bit. Looks like one is tied into a wire that goes to the solenoid harness. I'm hoping I can cut and splice the 6 wires into the new pigtail and be good.
For now, while I was under there I decided to pull the solenoid plug as instructed to make access to mlps plug easier... the lock is on the backside almost impossible to get to, I messed the plug up all the way around, but not fubarred. When I pulled the plug out, it was soaked in transmission fluid... Is that normal?
Ford Transmission :: E4od Transmission Slipping - MLPS?
My tranny slips in drive and od when it is warmed up.It's fine for a few miles when it is cold.Did a quick search and it seems like it might be a bad mlps.
My question is, Will a bad mlps act up all the time or just when it's warmed up? Will a mlps and connector from a 91 tranny work on a 95 tranny? Don't really want to throw money at it if it will need a rebuild.
Camry :: Engine Will Rev Up Like Transmission Has Gone To Neutral While Driving
I have a 2005 Camry, Base, 4cyl, 190k. The last couple of weeks while everyday driving the engine will rev up like the transmission has gone to neutral. It only does it for a couple of seconds and then back to normal. There is no rhyme or reason why it does it. We bought the car brand new and the fluid has never been changed.
View 14 RepliesFord Transmission :: E4OD Shudder On Take Off
My 95 psd recently started shuddering on takeoff... Pretty sure its the torque converter. It has a full ATS tranny with 5 star t/c and all the goodies installed by the previous owner (warranty not transferable). Its only got about 25k on the trans but they have been far from easy miles.
Symptoms: If I hold the brake and keep the truck stopped while holding the throttle its totally smooth, not until the truck starts moving that the shudder begins. It shudders worse the more power i put to it. Does it in first gear and second gear takeoffs. Goes away at about 10 mph or once the speed catches up with the rpm.
Ford Transmission :: 2003 - Trans Will Unlock While Driving For A Few Seconds Then Lock Backup And Drive Fine
B1602 PATS Recieved Invalid FMT/Key CD
P0753 Shift Solenoid A Electrical
P0758 Shift Solenoid B Electrical
P0740 Torque Converter Clutch Fault
P1760 Pressure Control Solenoid A Short
p0305 Cylinder 5 misfire Detected
P0316 Engine misfire Detected on Startup
The Trans will unlock while driving for a few seconds then lock back up and drive fine, it seems to be worse over the past couple days. It is no different cold or hot. I also noticed the head lights dim and the voltage on my scanner drops to around 12 volts when the trans disengages. When it is not acting up it drives and shifts perfect.
I have checked a few grounds that were visible and cleaned battery connections. The misfire code has been fixed, not related.
Camry :: 2004 Auto Transmission Shifts To Neutral When Driving
My wife's 2004 V6 Camry is not happy. As you accelerate from a stop, the automatic transmission will go from first gear to second, and then sometimes just drop spontaneously into neutral. Because you are in the process of accelerating, the engine RPMs increase until you take your foot of the pedal. In the short trip to the dealership for testing, the problem seemed to reset itself when the car was fully stopped. Other times it just reengaged with the transmission on its own without stopping.
Each time the transmission disengages, another strange thing happens--the instrument panel goes bonkers. The speedometer needle drops to zero, but the tach keeps working. The ABS, check engine, and brake lights turn on.
The dealership had the car for several days and has only been able to scan codes indicating the ABS system and the rear wheel speed sensors. I'm skeptical--especially since the repair estimate is nearly $4,000! I'm taking the car to an independent shop tomorrow for a second opinion.
I can follow up with more details from the dealership's diagnostic report, but for now, all I can say is that the car has almost 100,000 miles and we haven't had a bit of trouble with it until now. I replaced the transmission fluid about 10,000 miles ago.
Passat (B5) :: 2000 GLS V6 Quit While Driving / Manual Transmission Went Into Neutral
2000 Passat GLS V6 Manual Transmission 102k miles
I was stopped at a light tonight making a left hand turn, I had the car in 1st gear and the my foot on the clutch. I slowly released the clutch and proceeded to make my left hand turn, halfway thru the turn the car made a noise that sounded like a pop (almost as if something came apart underneath the front end of the car and was loose) and then my manual transmission went into neutral. I slowly coasted to the side of the road and had the vehicle towed.
After I had coasted to the side, I tried putting the car into gear and the engine would rev up but the vehicle would not go forward or reverse. I tried all 5 gears and reverse. While sitting there the car would beep and the screen would say "hand brake on" and if I put the car into first this message would go off. The message only came on about 2 times in 5 minutes and never stayed on.
Toyota - Corolla :: 1995 - Transmission (AT) Shifts Into Neutral While Driving
My 1995 1.8L Corolla wagon (230K original) automatic transmission will shift to neutral while I am driving. It will do this at any speed. It lasts for one to five seconds. Otherwise it runs and shifts perfectly . It does it on level or graded roads, maybe one to five times per week. I no longer feel confident to drive it. At first I would be driving along and the speedometer would go to zero. This would last for one to three miles. Then, after this, the speedometer would go to zero and the overdrive light would go on/off, and the transmission would shift back and forth. I changed the VSS but it did not fix the problem. Now it does the same again, only the transmission shifts to neutral.(The lever stays in Drive) This lasts for one to five seconds. Moving the shift lever during this time has no effect.
View 5 RepliesTransmission :: Normal To Switch To Neutral While Driving Downhill On Automatic?
is it good practice to shift to neutral, while driving downhill on automatic transmission? the owner manual does not recommend, would like to know why.it makes sense to save gas, while doing this. (i used to do it while driving manual)
View 7 RepliesFord Transmission :: E4OD Is Slipping For A Few Seconds
I have an E350 1992 7.3l Diesel, with E40D. The transmission slips in the 3rd and OD position. Every time, if I want to accelerate it slips for a few seconds and then the drivetrain is correct connected. The shifting into another gear works properly, the transmissions slips by changing from free-wheeling into accelerating ( for example: at speed 90km/h and no changing the gear).
I have recognized that the oil temperature is getting higher now. That may an indication for additional losses in the transmission. What do I have to check?
Ford Transmission :: 1995 E4OD Shifting / Lag Going Into 3rd
I have seen a few threads about E4OD's and there valve issues just want to narrow down to a valve issue or if it needs a rebuild. I can shift threw all gears i just have lag going into 3rd. also when putting it in reverse it takes about 5 seconds to finally drop into reverse. This is also accompanied with P0782 2-3 shift malfunction.
View 6 RepliesFord Transmission :: Replaced E4OD But Won't Working?
A while back I picked up a 1994 Bronco with a bad tranny for a flip. I recently picked up a 1993 E4OD that seemed to work well with low miles to throw in it.
I got it in the Bronco but it does not work right. If you put it in drive if feels like it's taking off in 3rd or 4th gear pull the shifter down one notch and it feels like 2nd gear pull it down again into 1st and no change. It bangs into reverse really hard. When up shifting manully it bangs pretty hard. No kick down at all under any circumstance and no converter lockup. I can't tell if it's in OD or third gear when at highway speed. OD button on the shifter has no effect but the light does go on and off.
I'm not an automatic tranny guy at all but it seems like an electrical issue. I was not able to drive the truck with the original tranny other than reverse (no bang) but the PO told me it was fine till it started slipping. I did test drive the donor truck and the new tranny worked correctly in it.
Being new to the process I need more detail and some of the basics. I'm comfortable with electronics and have the test equipment I just don't know the procedure. I'm guessing a bad connection/wire or something not compatible between the 1993 tranny and the 1994 truck.