Ford Ranger / B-Series :: 1996 - Rear Differential Whine - New Bearings?
i have a 96 ranger 2wd with a 2.3l engine and a 5 spd manual. everything works except the rear diff whines a little under load. putting new bearings in doesn't look to difficult that's what i will plan on doing but first i need to take the cover off and need to know what fluid to put in?
View 9 RepliesFord - E150 :: 1993 - Cooling Fan Clutch Too Long / Will Hit Radiator?
I need to replace the fan clutch on my 1993 Ford E150 Club Wagon 4.9L Chateau. The original part, YB466 has been replaced. The new ones are all too long and the fan will hit the radiator. The original is 2-3/8" long front to back, including the nut. The replacement ones available are 2-5/8" or longer. I have talked to our local machinist, and he says the new parts cannot be made shorter. The water pump shaft is not long enough to allow shortening. He says look for a shorter water pump.
View 11 RepliesFord - E150 :: 1993 - Horn Blows Won't Work Intermittently?
I've got a 93 ford 150 econo Van 310,000 miles. Steering volume ratchet shaft bused a couple of years ago. Horn worked then only the airbag lite would flash on and off. Got everything from the yard, steering wheel, air bag the whole thing. Replaced it and the air bag light stayed off and horn worked! About 6 months ago the airbag light again on & off then right after that the horn wouldn't work. However after a good rain and as I was turning mostly right sometimes left. The horn would just start blowing until I straighten the wheel and if someone was close by I would just wave. But the horn would still not work normally. it is finding a ground when I turn the wheel. I have no leak inside only happens in or after a rain sometimes. It rains a lot.
View 4 RepliesFord A/C :: 1993 E150 - Coolant Leaking From Trans Cooler Radiator Fitting
I decided to install a trans cooler since I was servicing the trans and got the pan dropped anyway. But when I cracked open the trans cooler connector(which is totally unnecessary and should be avoided completed), I noticed that I broke the trans cooler connector fitting to the radiator and now the coolant leaks badly from around the fitting. What are my options other than replacing the radiator? Would some liquid metal treatment do the magic? Or is there a way to remove and replace the fitting(I am not sure this would be possible since it looked like the fitting was welded to the radiator)?
View 5 RepliesFord Super Duty (1999-2016) :: 2012 4x4 - Front Wheel Bearings Replacement
Are just the bearings serviceable/replaceable or is the only option to get entire wheel hub assembly?
View 14 RepliesFord F-150 - 1997-2003 :: 2000 E150 - Transmission Quit Free Wheeling
I have a 2000 Ford E150 Van with 5.4L and auto trans. I left the lights on and ran the battery dead. Charged it back up and now ever since then, when I am going 50-60mph and let off the gas, the van freewheels for a short distance and then acts like it shifts out of overdrive and pulls the van down like its not in freewheel mode anymore. Only has 73K on it.
View 3 RepliesFord - E150 :: While Accelerating Slowly Vehicle Doesn't Move For Several Seconds Until Transmission Catches
I bought a used 89' Ford e150. Automatic transmission, 194k mi. I fixed it up a bit and it is very much drivable. I just took it up to northern az and then back down. I had to have it towed recently and now my transmission is acting up. When I want to move it i put it into gear, either reverse or drive, now while accelerating slowly the vehicle doesn't move for several seconds until the transmission catches and it then starts to move. It does this now while driving and having to stop for lights and signs. It has a delay until the transmission catches. I wonder if the vehicle is dragged up on to a flatbed tow truck this can damage my transmission or driveshaft And cause this. What can I do to fix it
View 5 RepliesPassat (B5) :: Grumble At Speeds Over 40 MPH - Front Wheel Bearings Replacement
Replacing front wheel bearings on my 99 Passat? There is a gentle 'wahwahwah' grumble at speeds over 40mph. The car has done 130,000 miles and is otherwise in nice condition.
View 3 RepliesFord F-150 - 1997-2003 :: Rear Differential Replacement?
Last week I broke the pinion and spider gears in in rear end. Well Im getting a used rear end rather than rebuidling mine. What is the gear ratio on the 97 F150 xlt 4.6l 4x4. I figured they would all be the same but my tag is missing on my diff and I was told by an auto parts store that there were a couple different ones.
View 14 RepliesSubaru - Forester :: Driver Side Rear Wheel Bearings Replacement
Have a 2000 Forester with 114K. Had to replace driver's rear wheel bearing at 100k & again at 110k; when replacement bearing started to fail, ABS light came on because wheel was not spinning true! Replaced passenger's rear wheel bearing at 105k (this one is getting noisy now).
Hard to believe I got 2 "bum' bearings! Not a difficult repair, but this will be 4 bearings in less than 2 years. The car's driven on paved roads & with little load, so it's not from harsh road conditions or heavy loads.
Ford Excursion :: Replacement Of Rear Differential Clutch Pack?
Have a growling noise in the rear when turning for the past two years. Getting worse so I assume I'm getting down to the metal on the clutches. Done all the other stuff like change the fluid and add friction additive. Have not pulled the cover and have the Mag Hytech diff that increases the capacity from 3 to 6 quarts of RP 75W-140 oil. Still does it. Just wanting to know if aftermarket clutch packs are available or is this a dealer only part. Ballpark how much are the clutch packs?
View 14 RepliesFord F-150 - 1997-2003 :: Differential Carrier Bearing Replacement
i'm just wondering if i need to worry about preload and backlash if i just pull the carrier out and replace only the carrier bearings. would simply replacing the shims in there original side keep the specs where they should be with new bearings or would i have to completely dismantle the housing and start from scratch.
I only ask because you can move the entire carrier by hand and see the slack in the bearings but i don't seem to have any noises or vibrations coming from the rear end so i don't know if it's worth tearing into...
Ford F-150 (2004-2008) :: U-joint Replacement At The Differential Side Of Shaft
how hard is it to replace the U-joint at the differential side of the shaft on an 04 FX4? Any special tools needed? At low speed (5-10mph) sounds like someone tapping on the rear end with a ball peen hammer, I guess it is the u-joints.
View 2 RepliesFord - Explorer :: 1993 - Rear Axle Replacement
The axle seal is bad on my 93 Explorer, manual, 4x4 both sides. The shocks and leaf springs are also shot. Instead of replacing the seals, was advised to just replace the entire axle and pick one up at the boneyard with springs.
I am wondering what axles from other vehicles will work? I have been able to find this before through RockAuto's website but there is no information concerning rear axle. Is there a source showing interchangeable parts between vehicles? Aside from the body, Explorer is basically rebuilt now, just needs the gearbox replaced.
Ford Transmission :: 1989 F150 - Rear Differential Rebuild?
I have a 1989 ford f150 xlt lariat it has a 5.0 and a 5 speed and is 4 wheel drive. Any way I am looking into rebuilding the rear end of the truck the pinion shaft has a lot of play in it up and down and both outer axle bearings seem to have lots of play in them. I believe it is a 8.8 inch in the rear. Just wondering if there hard to rebuild or what it all entails I have never taken one apart before and want to know what I am getting into. I have access to a press and a pinion and carrier bearing puller. the axle bearings i have done tons of them but never had to pull out the carrier. wondering how to set turning torque and backlash etc... and torque specs for everything.
View 8 RepliesFord Transmission :: 19987 - Two-wire Electrical Connection On The Differential?
OK, call me stupid but, what is the two-wire electrical connection on the differential of my '87 F250 lariat? I'm tracing all the wires from the rear to the front of the truck and replacing everything to make like new. I've never seen anything like this before.
View 2 RepliesAvalon 2005-12 :: Noise Coming From Front Left Tire - Front Wheel Bearings Replacement?
I've been having a lot of noise coming from the front left tire, and I finally had it diagnosed as a bad wheel bearing today.
I noticed that the front wheel bearings are sold individually while the rear wheel bearings are sold as hub assemblies. Is there a certain way that the front wheel bearings have to be removed and pressed on? I'm trying to see if this is a DIY repair.
Ford Transmission :: 1999 2WD - Limited Slip Rear Differential With No Leaks?
I recently changed the rear diff fluid on my 1999 F250 Super Duty (180k) It was due plus I was getting some chattering when making turns from a stop. The Diff fluid had about 60k miles on it and seemed to be a little low even though I don't see any leaks. I paid to have it done last time so I can't say what kind of a job they did.
I used Motorcraft diff fluid and 8oz of friction modifier. Two weeks later and about 500 miles, today I noticed on two occasions when turning a moaning sound coming from the rear of the truck. Could this be a sign of too much friction modifier and the cluthes are slipping or is something else going on?
Ford - Explorer :: 2001 - Small Leaks Coming From Transmission And Front Differential Gasket
I purchased my first truck 2 weeks ago private sale a 2001 Explorer Sport Trac 4v4 4.0L. I noticed it had small leaks coming from transmission and front differential gaskets (the diff is silicone) but the oil levels remain fine. Within days I heard a loud hum coming from the engine for 10 seconds then immediately after i was slowing down for a speed bump and my truck tried to stall and since that point it was riding very rough at low speed/idle and sometimes giving it gas seemed to just kill it. Next day a check engine light comes on and I get it checked It was Bank 1 running lean and B1155 (Output shaft speed signal) which concerned me from what I found it is located by the transmission oil filter which has the leak.
A few more days later I broke down on the side of the road, the alternator had died and killed the battery, I replaced the alternator and belt, replaced the 6 spark plugs, 3 of which i removed way to easily with my hands and all 6 had an incorrect gap. Initially the car was still rough but now with the new plugs it is drivable but still a little weird on startup and idle and a little bit of the shakes around 60-65mph and seems to be over actively shifting soon as i let off the gas even a little bit. Today I had the check engine light assessed again, now Bank 1 and Bank 2 are lean, still have the B1155 as well as a new C1676 (Battery pack voltage out of range) which light research said it could be ABS module or it could be a false code from being jumped days prior and that code wont clear on its own.